Simplicity 580447-0112-E2 Kasutusjuhend
- Kategooria
- Mootorsõidukite tarvikud
- Tüüp
- Kasutusjuhend
See käsiraamat sobib ka
en
English
sl
Slovenija
bg cs hret hu
Èeština
lt lv pl ro ru
eesti keel Hrvatski Latviešu Polski Ðóññêèé
Românã
Áúëãàðñêè LietuviųMagyar
en
Operator’s Manual
bg
Èíñòðóêöèè çà åêñïëîàòàöèÿ
cs
Návod k obsluze
et
Kasutusjuhend
hr
Priruènik za operatora
hu
Kezelési útmutató
lt
Naudojimo instrukcija
lv
Operatora rokasgrāmata
pl
Instrukcja obs³ugi
ro
Manual de utilizare
ru
Ðóêîâîäñòâî ïî ýêñïëóàòàöèè
sl
Priroènik za uporabo
Form No. 277108EST
Revision: E
01999-B8011
E 2010 Briggs & Stratton Corporation,
Milwaukee, WI, USA. All rights reserved.
Briggs & Stratton is a registered trademark
of Briggs & Stratton Corporation
Model 580000
Vanguardt
Gasoline
Not for Reproduction
2
BRIGGSandSTRATTON.COM
1
D
H
J
K
L
M
A
B
C
D
E
F
G
I
N
O
F
F
P
P
A
2
C
B
F
J
3
D
D
E
E
C
C
B
C
A
4 5
B
A
C
D
Not for Reproduction
3
A
B
A
6 7
G
H
G
8
A
B
C
A
B
C
D
D
B
C
9 10
B
D
E
A
F
C
G
Not for Reproduction
4 BRIGGSandSTRATTON.COM
General Information
This manual contains safety information to make you aware of the hazards and risks
associated with engines and how to avoid them. It also contains instructions for the
proper use and care of the engine. Because Briggs & Stratton Corporation does not
necessarily know what equipment this engine will power, it is important that you read and
understand these instructions and the instructions for the equipment. Save these
original instructions for future reference.
For replacement parts or technical assistance, record below the engine model, type, and
code numbers along with the date of purchase. These numbers are located on y our
engine (see the Features and Controls page).
Date of purchase:
Engine model:
MM/DD/YYYY
Model: Code:Type:
Engine Power Rating Information
For 3/LC engines, gross power ratings are based on SAE J1995 criteria and net power
ratings are based on SAE J1349 criteria. Actual power output of production engines
installed in applications may vary depending on a number of factors, including the engine
RPM limit of the application, environment al conditions, engine/equipment maintenance,
and other variables.
Operator Safety
Explosion
Toxic Fumes
Moving Parts
Shock
Hot Surface
Kickback
Fire
Fuel Shutoff
Read Manual
Choke
Oil
Fuel
On Off
Wear Eye
Protection
Slow
Fast
SAFETY AND CONTROL SYMBOLS
Hazardous
Chemical
Frostbite
Hot Liquid or
Steam
Stop
The safety alert symbol is used to identify safety information about hazards that can
result in personal injury. A signal word (DANGER, WARNING, or CAUTION) is used with the
alert symbol to indicate the likelihood and the potential severity of injury. In addition, a hazard
symbol may be used to represent the type of hazard.
DANGER indicates a hazard which, if not avoided, will result in death or
serious injury.
WARNING indicates a hazard which, if not avoided, could result in death or
serious injury.
CAUTION indicates a hazard which, if not avoided, could result in minor or
moderate injury.
NOTICE indicates a situation that could result in damage to the product.
WARNING
Certain components in this product and its related accessories contain
chemicals known to the State of California to cause cancer, birth defects, or
other reproductive harm. Wash hands after handling.
WARNING
The engine exhaust from this product contains chemicals known to the
State of California to cause cancer, birth defects, or other reproductive
harm.
WARNING
Briggs & Stratton does not approve or authorize the use of these engines
on 3-wheel All Terrain Vehicles (ATVs), motor bikes, fun/recreational
go-karts, aircraft products, or vehi cles intended for use in competitive
events. Use of these engines in such applications could result in property
damage, serious injury (including paralysis), or even death.
NOTICE: This engine was shipped from Briggs & Stratton without oil. Before you start
the engine, make sure you add oil according to the instructions in this manual. If you
start the engine without oil, it will be damaged beyond repair and will not be covered
under warranty.
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
When Adding Fuel
• Turn engine off and let engine cool at least 2 minutes before removing the fuel
cap.
• Fill fuel tank outdoors or in well -ventilated area.
• Do not overfill fuel tank. To allow for expansion of the fuel, do not fill above the
bottom of the fuel tank neck.
• Keep fuel away from sparks, open flames, pilot lights, heat, and other ignition
sources.
• Check fuel lines, tank, cap, and fittings frequently for cracks or leaks.
Replace if necessary
• If fuel spills, wait until it evaporates before starting engine.
When Starting Engine
• Ensure that spark plug, muffler, fuel cap and air cleaner (if equipped) are in
place and secured.
• Do not crank engine with spark plug removed.
• If engine floods, set choke (if equipped) to OPEN/RUN position, move throttle
(if equipped) to FAST position and crank until engine starts.
When Operating Equipment
• Do not tip engine or equipment at angle which causes fuel to spill.
• Do not choke the carburetor to stop engine.
• Never start or run the engine with the air cleaner assembly (if equipped) or the
air filter (if equipped) removed.
When Transporting Equipment
• Transport with fuel tank EMPTY or with fuel shut-off valve OFF.
When Storing Fuel Or Equipment With Fuel In Tank
• Store away from furnaces, stoves, water heaters or other appliances that have
pilot lights or other ignition sources because they can ignite fuel vapors.
Starting engine creates sparking.
Sparking can ignite nearby flammable gases.
Explosion and fire could result.
WARNING
• If there is natural or LP gas leakage in area, do not start engine.
• Do not use pressurized starting fluids because vapors are flammable.
Engines give off carbon monoxide, an odorless, colorless, poison gas.
Breathing carbon monoxide can cause nausea, fainting or death.
WARNING
• Start and run engine outdoors.
• Do not start or run engine in enclosed area, even if doors or windows are open.
Not for Reproduction
5
en
Rotating parts can contact or entangle hands, feet, hair, clothing, or
accessories.
Traumatic amputation or severe laceration can result.
WARNING
• Operate equipment with guards in place.
• Keep hands and feet away from rotating parts.
• Tie up long hair and remove jewelry.
• Do not wear loose-fitting clothing, dangling drawstrings or items that could
become caught.
Running engines produce heat. Engine parts, especially muffler,
become extremely hot.
Severe thermal burns can occur on contact.
Combustible debris, such as leaves, grass, brush, etc. can catch fire.
WARNING
• Allow muffler, engine cylinder and fins to cool before touching.
• Remove accumulated debris from muffler area and cylinder area.
• It is a violation of California Public Resource Code, Section 4442, to use or
operate the engine on any forest -covered, brush-covered, or grass-covered land
unless the exhaust system is equipped with a spark arrester, as defined in
Section 4442, maintained in effective working order. Other states or federal
jurisdictions may have similar laws. Contact the original equipment
manufacturer, retailer, or dealer to obtain a spark arrester designed for the
exhaust system installed on this engine.
Severe thermal burns can occur by escaping steam or hot coolant.
WARNING
• DO NOT remove radiator cap or reservoir cap if engine is warm or running.
• Stop engine and allow it to cool before removing radiator cap or reservoir cap
and before changing or adding coolant.
Unintentional sparking can result in fire or electric shock.
Unintentional start-up can result in entanglement, traumatic
amputation, or laceration.
Fire hazard
WARNING
Before performing adjustments or repairs:
• Disconnect the spark plug wire and keep it away from the spark plug.
• Disconnect battery at negative terminal (only engines with electric start.)
• Use only c orrect tools.
• Do not tamper with governor spring, links or other parts to increase engine
speed.
• Replacement parts must be of the same design and installed in the same
position as the original parts. Other parts may not perform as well, may damage
the unit, and may result in injury.
• Do not strike the flywheel with a hammer or hard object because the flywheel
may later shatter during operation.
When testing for spark:
• Use approved spark plug tester.
• Do not check for spark with spark plug removed.
Not for Reproduction
6 BRIGGSandSTRATTON.COM
Features and Controls
Compare illustration
1
with your engine to familiarize yourself with the location of
various features and controls.
A. Engine Identification
Model Type Code
B. Spark Plug
C. Dipstick
D. Oil Fill
E. Oil Filter
F. Oil Drain Plug
G. Oil Pressure Sensor
H. Electric Starter
I. Carburetor
J. Thermostat
K. Ignition Coil
L. Oil Pan
M. Alternator
N. Coolant Temperature Sending Unit
O. Engine Date Code
P. Fan
Operation
Oil capacity (see the Specifications section)
Oil Recommendations
We recommend the use of Briggs & Stratton Warranty Certified oils for best
performance. Other high-quality detergent oils are acceptable if classified for service SF,
SG, SH, SJ or higher. Do not use special additives.
Outdoor temperatures determine the proper oil viscosity for the engine. Use the chart to
select the best viscosity for the outdoor temperature range expected.
* Below 40°F(4°C) the use of SAE 30 will result in hard starting.
** Above 80°F(27°C) the use of 10W-30 may cause increased oil consumption. Check
oil level more frequently.
How To Check/Add Oil - Figure
2 3
Before adding or checking the oil
• Place engine level.
• Clean the oil fill area of any debris.
1. Remove the dipstick (A) and wipe with a clean cloth (Figure 2).
2. Completely insert the dipstick.
3. Remove the dipstick and check the oil level. It should be at the FULL mark (B)onthe
dipstick.
4. If the oil is low, remove the oil fill cap (J).
5. Remove the dipstick. Pour the oil slowly into the engine oil fill (C). Do not overfill.
Important: When adding oil, adequate venting is required as follows:
• Remove the dipstick.
• Make sure adequate clearance (D) is maintained between the oil fill device (E)
and the engine oil fill (C).SeeFigure3.
6. Install and tighten the oil fill cap.
NOTICE: Before starting the engine, wipe the engine clean of any spilled oil.
7. After adding oil, install the dipstick. Start and run engine at idle for five minutes. See
the How To Start The Engine section. Shut off engine. Wait three minutes and
check oil level. If required, add oil to bring oil level to the FULL mark (B)onthe
dipstick (Figure 2).
8. Install the dipstick.
Oil Pressure
If the oil pressure is too low, a pressure switch (if equipped) will either stop the engine or
activate a warning device on the equipment. If this occurs, stop the engine and check the
oil level with the dipstick.
If the oil level is below the ADD mark, add oil until it reaches the FULL mark. Start the
engine and check for proper pressure before continuing to operate.
If the oil level is between the ADD and FULL marks, do not start the engine. Contact
any Briggs & Stratton 3/LC Authorized Dealer to have the oil pressure problem
corrected.
Fuel Recommendations
Fuel must meet these requirements:
• Clean, fresh, unleaded gasoline.
• A minimum of 87 octane/87 AKI (91 RON). High altitude use, see below.
• Gasoline with up to 10% ethanol (gasohol) or up to 15% MTBE (methyl tertiary
butyl ether) is acceptable.
CAUTION: Do not use unapproved gasolines, such as E85. Do not mix oil in gasoline or
modify the engine to run on alternate fuels. This will damage the engine components and
void the engine warranty.
To protect the fuel system from gum formation, mix a fuel stabilizer into the fuel. See
Storage. All fuel is not the s ame. If starting or performance problems occur, change fuel
providers or change brands. This engine is certified to operate on gasoline. The
emissions control system for this engine is EM (Engine Modifications).
High Altitude
At altitudes over 3,000 feet (900 meters), a minimum 85 octane/85 AKI (89 RON)
gasoline is acceptable. To remain emissions compliant, high altitude adjustment is
required. Operation without this adjustment will cause decreased performance,
increased fuel consumption, and increased emissions. See a Briggs & Stratton 3/LC
Authorized Dealer for high altitude adjustment information.
Operation of the engine at altitudes below 2,500 feet (762 meters) with the high altitude
kit is not recommended.
How To Add Fuel - Figure
4
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
When Adding Fuel
• Turn engine off and let engine cool at least 2 minutes before removing the fuel
cap.
• Fill fuel tank outdoors or in well -ventilated area.
• Do not overfill fuel tank. To allow for expansion of the fuel, do not fill above the
bottom of the fuel tank neck.
• Keep fuel away from sparks, open flames, pilot lights, heat, and other ignition
sources.
• Check fuel lines, tank, cap, and fittings frequently for cracks or leaks.
Replace if necessary
• If fuel spills, wait until it evaporates before starting engine.
1. Clean the fuel cap area of dirt and debris. Remove the fuel cap (A, Figure 4).
2. Fill the fuel tank (B) with fuel. To allow for expansion o f the fuel, do not fill above the
bottom of the fuel tank neck (C).
3. Reinstall the fuel cap.
Coolant Recommendations
Coolant capacity (see the equipment manufacture’s manual)
NOTICE: This is a liquid-cooled engine. A 50/50% mixture of phosphate-free antifreeze
and tap water is required for cooling, rust resistance, and lubrication of the water pump.
Not for Reproduction
7
en
How To Check/Add Coolant
Severe thermal burns can occur by escaping steam or hot coolant.
WARNING
• DO NOT remove radiator cap or reservoir cap if engine is warm or running.
• Stop engine and allow it to cool before removing radiator cap or reservoir cap
and before changing or adding coolant.
1. Before operating, check the coolant level. The coolant level must be between the
FULL and the LOW/ADD marks on the coolant reservoir. If the coolant level is low,
add a 50/50% coolant mixture of phosphate-free antifreeze and tap water to the
reservoir.
2. To remove the reservoir cap after engine is cool, place a thick cloth over the reservoir
cap. Slowly turn the reservoir cap counterclockwise to remove.
3. If the reservoir is dry, then add coolant to both the reservoir and to the radiator. See
the equipment manual for location, operation, and maintenance of the coolant
reservoir and the radiator.
4. To remove the radiator cap after engine is cool, place a thick cloth over the radiator
cap. Slowly turn the radiator cap counterclockwise to the first stop. If pressurized
steam escapes from the cap, stand back to avoid injury. After all pressure is
released, push down and turn the radiator cap counterclockwise to remove.
Gauges And Lights
The gauges and lights shown are typical and represent various options that can be used.
See the equipment manual for location and operation of gauges and lights.
Coolant Temperature Gauge
Indicates coolant temperature when the electric start switch is in
the ON position.
Normal range 80º -- 9 0 º C (175º -- 195º F)
Dangerous range above 105º C (220º F)
Hour Meter Gauge
Indicates the total number of operating hours.
Fuel Gauge
Indicates the fuel remaining in the fuel tank. To minimize condensation,
keep the fuel tank full.
Temperature Light
If the temperature light comes on, the engine is overheating. Stop the
engine and check the coolant level (see the How To Check Coolant
section). Check the radiator for debris that could restrict air flow.
Ignition Light
When the electric start switch is turned to the ON position, the ignition light
should be on. When the engine is running, the ignition light should go out.
If the ignition light is out when then electric startswitchintheONposition, check for a
blown fuse.
Engine Oil Pressure Light
When the electric start switch is turned to the ON position, the engine oil
pressure light should be on. When the engine is running, the engine oil
pressure light should go out. If the engine oil pressure light comes on when the engine
is running, immediately stop the engine. First, check the oil level (see the How To
Check/Add Oil section). Next, check the electrical system.
Charge Light
When the electric start switch is turned to the ON position, the charge light
should be on. When the engine is running, the charge light should go out. If
the charge light comes on when the engine is running, check the electrical system.
How To Start The Engine - Figure
5
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
When Starting Engine
• Ensure that spark plug, muffler, fuel cap and air cleaner (if equipped) are in
place and secured.
• Do not crank engine with spark plug removed.
• If engine floods, set choke (if equipped) to OPEN/RUN position, move throttle
(if equipped) to FAST position and crank until engine starts.
Starting engine creates sparking.
Sparking can ignite nearby flammable gases.
Explosion and fire could result.
WARNING
• If there is natural or LP gas leakage in area, do not start engine.
• Do not use pressurized starting fluids because vapors are flammable.
Engines give off carbon monoxide, an odorless, colorless, poison gas.
Breathing carbon monoxide can cause nausea, fainting or death.
WARNING
• Start and run engine outdoors.
• Do not start or run engine in enclosed area, even if doors or windows are open.
NOTICE: This engine was shipped from Briggs & Stratton without oil. Before you start
the engine, make sure you add oil according to the instructions in this manual. If you
start the engine without oil, it will be damaged beyond repair and will not be covered
under warranty.
Note: Some engines and equipment have remote controls. See the equipment manual
for location and operation of remote controls.
1. Check the oil level. See the How To Check/Add Oil section.
2. Make sure equipment drive controls, if equipped, are disengaged.
3. Turn the fuel shut-off valve (A), if equipped, to the on position (Figure 5).
4. Move the throttle control (B) slightly past t he slow
position.
5. Turn the electric start switch (D) to the on/start position (Figure 5).
NOTICE: To prolong starter life, use short starting cycles, not to exceed 15 seconds
per minute. Extended cranking c an damage the starter motor.
6. If the engine does not immediately start, pull out the choke control ( C), if equipped, to
the c hoke
position.
Note: Choke is usually unnecessary when restarting a warm engine.
7. As the engine warms up, move the choke control (C)totherun
position.
How To Stop The Engine - Figure
5
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
• Do not choke the carburetor to stop engine.
1. Move the throttle control (B) to the slow
position. Turn the key switch (D)to
the off position (Figure 5). Remove the k ey and keep in a safe place out of the reach
of children.
2. After the engine stops, turn the fuel shut-off valve ( A), if equipped, to the closed
position.
Maintenance
We recommend that you see any Briggs & Stratton 3/LC Authorized Dealer for all
maintenance and service of the engine and engine parts.
NOTICE: All the components used to build this engine must remain in place for proper
operation.
Not for Reproduction
8
BRIGGSandSTRATTON.COM
Emissions Control
Maintenance, replacement, or repair of the emissions control devices and systems
may be performed by any non-road engine repair establishment or individual.
However, to obtain “no charge” emissions control service, the work must be performed
by a factory authorized dealer. See the Emissions Warranty.
Unintentional sparking can result in fire or electric shock.
Unintentional start-up can result in entanglement, traumatic
amputation, or laceration.
Fire hazard
WARNING
Before performing adjustments or repairs:
• Disconnect the spark plug wire and keep it away from the spark plug.
• Disconnect battery at negative terminal (only engines with electric start.)
• Use only c orrect tools.
• Do not tamper with governor spring, links or other parts to increase engine
speed.
• Replacement parts must be of the same design and installed in the same
position as the original parts. Other parts may not perform as well, may damage
the unit, and may result in injury.
• Do not strike the flywheel with a hammer or hard object because the flywheel
may later shatter during operation.
When testing for spark:
• Use approved spark plug tester.
• Do not check for spark with spark plug removed.
Maintenance Chart
Every8HoursorDaily
• Check engine oil level
• Check coolant level
First 50 Hours (initial Break-In)
• Change engine oil *
Every 100 Hours or Annually
• Check fan belt tension
• Clean radiator
• Clean air filter
• Check muffler and clean spark arrestor (if equipped)
Every 150 Hours or Annually
• Change engine oil *
• Replace oil filter
Every 600 Hours or Annually
• Replace air filter
• Check valve clearance H
• Replace fuel filter
• Replace spark plugs
Annually
• Change coolant
* Service more often when operating under heavy load or in high temperature.
H Not required unless engine performance problems are noted.
Carburetor Adjustment
Never make adjustments to the carburetor. The carburetor was set at the factory to
operate efficiently under most conditions. However, if adjustments are required, see a
Briggs & Stratton 3/LC Authorized Dealer for service.
NOTICE: The manufacturer of the equipment on which this engine is installed s pecifies
the top speed at which the engine will be operated. Do not exceed this speed.
How To Replace The Spark Plug - Figure
6
Check the gap (A, Figure 6) with a wire gauge (B). If necessary, reset the gap. Install
and tighten the spark plug to the recommended torque. For gap setting or torque, see the
Specifications section.
Note: In some areas, local law requires using a resistor spark plug to suppress ignition
signals. If this engine was originally equipped with a resistor spark plug, use the same
type for replacement.
Inspect Muffler And Spark Arrester
Running engines produce heat. Engine parts, especially muffler,
become extremely hot.
Severe thermal burns can occur on contact.
Combustible debris, such as leaves, grass, brush, etc. can catch fire.
WARNING
• Allow muffler, engine cylinder and fins to cool before touching.
• Remove accumulated debris from muffler area and cylinder area.
• It is a violation of California Public Resource Code, Section 4442, to use or
operate the engine on any forest -covered, brush-covered, or grass-covered land
unless the exhaust system is equipped with a spark arrester, as defined in
Section 4442, maintained in effective working order. Other states or federal
jurisdictions may have similar laws. Contact the original equipment
manufacturer, retailer, or dealer to obtain a spark arrester designed for the
exhaust system installed on this engine.
Remove accumulated debris from muffler area and cylinder area. Inspect the muffler for
cracks, corrosion, or other damage. Remove the spark arrester, if equipped, and inspect
for damage or carbon blockage. If damage is found, install replacement parts before
operating.
WARNING: Replacement parts must be of the same design and installed
in the same position as the original parts. Other parts may not perform as well, may
damage the unit, and may result in injury.
How To Check Coolant
NOTICE: This is a liquid cooled engine. A 50/50% coolant mixture of phosphate-free
antifreeze and tap water is required for cooling, rust resistance, and lubrication of the
water pump.
Severe thermal burns can occur by escaping steam or hot coolant.
WARNING
• DO NOT remove radiator cap or reservoir cap if engine is warm or running.
• Stop engine and allow it to cool before removing radiator cap or reservoir cap
and before changing or adding coolant.
1. Check the coolant level. The coolant level must be between the FULL and LOW, or
ADD, marks on the coolant reservoir. If the coolant level is low, add a 50/50%
coolant mixture of phosphate-free antifreeze and tap water to the reservoir.
2. To remove the reservoir cap after engine is cool, place a thick cloth over the reservoir
cap. Slowly turn the reservoir cap counterclockwise to remove.
3. If the reservoir is dry, add coolant to both the reservoir and to the radiator. See the
equipment manual for location, operation, and maintenance of the coolant reservoir
and of the radiator.
4. To remove the radiator cap after engine is cool, place a thick cloth over the radiator
cap. Slowly turn the radiator cap counterclockwise to the first stop. If pressurized
steam escapes from the cap, stand back to avoid injury. After all pressure is
released, push down and turn the radiator cap counterclockwise to remove.
How To Change The Oil - Figure
2 7
Used oil is a hazardous waste product and must be disposed of properly. Do not discard
with household waste. Check with your local authorities, service center, or dealer for s afe
disposal/ recycling facilities.
Remove Oil
1. With engine off but still warm, disconnect the spark plug wires (F, Figure 2) and keep
them away from the spark plugs.
2. Remove the oil drain plug (G, Figure 7). Drain the oil into an approved container.
3. After the oil has drained, install and tighten the oil drain plug.
Change The Oil Filter
For replacement intervals, see the Maintenance chart.
1. Drain the oil from the engine. See Remove Oil section.
2. Remove the oil filter (H, Figure 7) and dispose of properly.
3. Before you install the new oil filter, lightly lubricate the oil filter gasket with fresh,
clean oil.
4. Install the oil filter by hand until the gasket contacts the oil filter adapter, then tighten
theoilfilter1/2to3/4turns.
5. Add oil. See Add Oil section.
Not for Reproduction
9
en
Add Oil
• Place engine level.
• Clean the oil fill area of any debris.
• See the Specifications section for oil capacity.
1. Remove the dipstick (A, Figure 2).
2. Remove the oil fill cap (J).
3. Pour the oil slowly into the engine oil fill (C). Do not overfill.
Important: When adding oil, adequate venting is required as follows:
• Remove the dipstick.
• Make sure adequate clearance (D) is maintained between the oil fill device (E)
and the engine oil fill (C).SeeFigure3.
4. Install and tighten the oil fill cap.
NOTICE: Before starting the engine, wipe the engine clean of any spilled oil.
5. After adding oil, install the dipstick. Start and run engine at idle for five minutes.
Check for leaks. Shut off engine. Wait three minutes and check oil level. If required,
add oil to bring oil level to the FULL mark (B) on the dipstick (Figure 2).
6. Install the dipstick.
How To Service The Air Filter - Figure
8
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
• Never start or run the engine with the air cleaner assembly or the air filter
removed.
NOTICE: Do not use pressurized air or solvents to clean the filter. Pressurized air can
damage the filter and solvents will dissolve the filter.
See the Maintenance Chart for service requirements.
1. Open the latches (A) and remove the cover (B).SeeFigure8.
2. Remove the air filter (C).
3. To loosen debris, gently tap the air filter on a hard surface. If the air filter is
excessively dirty, replace with a new air filter.
4. Install the air filter.
5. Install the cover and close the latches.
How To Replace The Fuel Filter - Figure
9
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
• Keep fuel away from sparks, open flames, pilot lights, heat, and other ignition
sources.
• Check fuel lines, tank, cap, and fittings frequently for cracks or leaks.
Replace if necessary.
• Before replacing the fuel filter, drain the fuel tank or close the fuel shut-off valve.
• Replacement parts must be the same and installed in the same position as the
original parts.
• If fuel spills, wait until it evaporates before starting engine.
1. Before replacing the fuel filter (A, Figure 9), if equipped, drain the fuel tank or close
the fuel shut-off valve. Otherwise, fuel can leak out and cause a fire or explosion.
2. Use pliers to squeeze tabs (B) on the clamps (C), then slide the clamps away from
the fuel filter. Twist and pull the fuel lines (D) off of the fuel filter.
3. Check the fuel lines for cracks or leaks. Replace if necessary.
4. Replace the fuel filter with an original equipment replacement filter.
5. Secure the fuel lines with the clamps as shown.
How To Check/Adjust The Fan Belt - Figure
10
Check Fan Belt
1. Check the condition of the fan belt (A, Figure 10). If the fan belt has cracks or is
damaged, replace with a new belt.
2. Check the tension (B) of the fan belt. Press on the center (C) of the fan belt. If
tension is correct, the belt will move 3/8 -- 1/2 in (10 -- 12 mm) if 22 lbs (10 kg) of
force is applied to the center of the belt. If the tension is too loose, adjust as follows.
Adjust Fan Belt Tension
1. Loosen the alternator mounting bolts (D) and (E). See Figure 10).
2. Position a pry bar (F) against the alternator (G) and the side of the engine block. To
tighten the fan belt, pull on the pry bar. Temporarily tighten the alternator mounting
bolts.
3. Check the tension of the fan belt. See Check Fan Belt section. If necessary, repeat
the procedure.
4. Tighten the alternator mounting bolts.
Torque bolt (D)to14ft-lbs(19Nm).
Torque bolt (E)to45ft-lbs(61Nm).
Storage
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
When Storing Fuel Or Equipment With Fuel In Tank
• Store away from furnaces, stoves, water heaters or other appliances that have
pilot lights or other ignition sources because they can ignite fuel vapors.
Fuel System
Fuel can become stale when stored over 30 days. Stale fuel causes acid and gum
deposits to form in the fuel system or on essential carburetor parts. To keep fuel fresh,
use Briggs & Stratton FRESH START
®
fuel stabilizer, available as a liquid additive or a
drip concentrate cartridge.
There is no need to drain gasoline from the engine if a fuel stabilizer is added according
to instructions. Run the engine for 2 minutes to circulate the stabilizer throughout the fuel
system. The engine and fuel can then be stored up to 24 months.
If gasoline in the engine has not been treated with a fuel stabilizer, it must be drained into
an approved container. Run the engine until it stops from lack of fuel. The use of a fuel
stabilizer in the storage container is recommended to maintain freshness.
Engine Oil
While the engine is still warm, change the engine oil.
Troubleshooting
Need Assistance? Go to BRIGGSandSTRATTON.COM or call 1-800-233-3723.
Specifications
Engine Specifications
Model 580000
Displacement 58.16 ci (953 cc)
Bore 2.835 in (72 mm)
Stroke 3.071 in (78 mm)
Oil Capacity 3.5 qt (3.3 L)
Tune-up Specifications *
Model 580000
Spark Plug Gap 0.030 in (0.76 mm)
Spark Plug Torque 180 lb-in (20 Nm)
Intake Valve Clearance
Y
0.007 in (0.18 mm)
Exhaust Valve Clearance
Y
0.007 in (0.18 mm)
* Engine power will decrease 3.5% for each 1,000 feet (300 meters) above sea level and
1% for each 10° F(5.6° C) above 77° F(25° C). The engine will operate satisfactorily at
an angle up to 15°. Refer to the equipment operator’s manual for safe allowable
operating limits on slopes.
Y
Check when engine is cold.
Common Service Parts n
Service Part Part Number
Air Filter 820263
Oil Filter 491056
Fuel Filter 821026
Fuel Additive 5041
Resistor Spark Plug 496055, 5066
Spark Plug Wrench 19374
Spark Tester 19400
V-Belt (940 mm) 821075
V-Belt (970 mm) 820893
n We recommend that you see any Briggs & Stratton 3/LC Authorized Dealer for all
maintenance and service of the engine and engine parts.
Not for Reproduction
10 BRIGGSandSTRATTON.COM
BRIGGS & STRATTON 3/LC ENGINE OWNER WARRANTY POLICY
September 2009
Briggs & Stratton Corporation will repair or replace, free of charge, any part(s) of the engine that is defective in material or workmanship or both. Transportation charges on
product submitted for repair or replacement under this warranty must be borne by purchaser. This warranty is effective for and is subject to the time periods and conditions
stated below. For warranty service, find t he nearest Authorized Briggs & Stratton 3 /LC Service Dealer in our dealer locator map at BRIGGSandSTRATTON.COM, or
by calling 1-800-233-3723, or as listed in the ‘Yellow Pages’.
There is no other expressed warranty. Implied warranties, including those of merchantability and fitness for a particular purpose, are limited to one year from
purchase, or to the extent permitted by law. All other implied warranties are excluded. Liability for incidental or consequential damages are excluded to the
extent exclusion is permitted by law. Some states or countries do not allow limitations on how long an implied warranty lasts, and some states or countries do not allow
the exclusion or limitation of incidental or consequential damages, so the above limitation and exclusion may not apply to you. This warranty gives you specific legal rights
and you may also have other rights which vary from state to state and country to country.
LIMITED WARRANTY
OUR PRODUCT
Warranty Period
Vanguardt 3/LC
Major Parts Warranty * Parts & Labor *
Consumer and Commercial Use 2 years 3 years 2 years
* Note the following special warranty periods: For purposes of this warranty policy, Parts & Labor coverage is 2 years. Major parts only coverage is extended
through the third year of operation. Major Parts Warranty (M.P.W.) covers but is not limited to or exclusive to cylinder block, cylinder head, crankshaft,
camshaft, gears, pistons, rods, flywheel, flywheel housing, oil pump, fan, pulleys, mechanical governor, intake manifold, and oil pan. M.P.W. does not cover
and is not limited to piston rings, replaceable bearings, water pump, any electrical component, valve train components, accessory parts, seals, gaskets,
carburetors, exhaust manifold, hoses, all fuel system components, injectors, injector pump, turbocharger, muffler, any filters, radiator, t hermostat, spark plugs,
glow plugs, and fuel transfer pumps. The warranty period begins on the date of purchase by the fi rst retail consumer or commercial end user and continuesfor
the period of time stated in the table above.
No warranty registration is necessary to obtain warranty on Briggs & Stratton products. Save your proof of purchase receipt. If you do not provide proof of the initial
purchase date at the time warranty service is requested, the manufacturing date of the product will be used to determine the warranty period.
About Your Warranty
Briggs & Stratton welcomes warranty repair and apologizes to you for being
inconvenienced. Any Authorized Briggs & Stratton 3/LC Service Dealer may perform
warranty repairs. Most warranty repairs ar e handled routinely, but sometimes requests
for warranty s ervice may not be appropriate. For example, warranty would not apply if
engine damage occurred because of misuse, lack of routine maintenance, shipping,
handling, warehousing or improper installation. Similarly, warranty is v oid if the serial
number of the engine has been removed or the engine has been altered or modified.
If a customer differs with the decision of the Service Dealer, an investigation will be made
to determine whether the warranty applies. Ask the Service Dealer to submit all
supporting facts to his Distributor or the Fac tory for review. If the Distributor or the
Factory decides that the claim is justified, the customer will be fully reimbursed for those
items that are defective. To avoid misunderstanding which might occur between the
customer and the Dealer, listed below are s ome of the causes of engine failure that the
warranty does not cover.
Normal wear: Engines, like all mechanical devices, need periodic parts service and
replacement to perform well. Warranty will not cover repair when normal use has
exhausted the life of a part or an engine. Warranty would not apply if engine damage
occurred because of misuse, lack of routine maintenance, shipping, handling,
warehousing or improper installation. Similarly, warranty is void if the serial number of the
engine has been removed or the engine has been altered or modified.
Improper maintenance: The life of an engine depends upon the conditions under which
it operates, and the care it receives. Some applications, such as tillers, pumps and rotary
mowers, are very often used in dusty or dirty conditions, which can cause what appears
to be premature wear. Such wear, when caused by dirt, dust, spark plug cleaning grit, or
other abrasive material that has entered the engine because of improper maintenance, is
not covered by warranty.
This warranty covers engine related defective material and/or workmanship only
,
and not replacement or refund of the equipment to which the engine may be
mounted. Nor does the warranty extend to repairs required because of:
1 Engines that are not properly applied to equipment. It is strongly recommended that
the factory be contacted prior to applying a B&S 3/LC engine to equipment that did
not originally use a B&S 3/LC engine.
2 Problems caused by parts that are not original Briggs & Stratton parts.
3 Equipment controls or installations that prevent starting, cause unsatisfactory engine
performance, or shorten engine life. (Contact equipment manufacturer.)
4 Leaking carburetors, clogged fuel pipes or injectors, sticking valves, contaminated
injector pumps, or other damage, caused by using contaminated or stale fuel. Use
clean, fresh fuel (lead free gasoline, diesel fuel) and Briggs & Stratton fuel stabilizer,
Part No. 5041.
5 Parts which are scored or broken because an engine was operated with insufficient
or contaminated lubricating oil, or an incorrect grade of lubricating oil (Check oil level
daily or after every 8 hours of operation. Refill when necessary and change oil and
oil filter at recommended intervals). OIL GARD may not shut down running engine.
Engine damage may occur if oil level is not properly maintained. Read Operator’s
Manual.
6 Repair or adjustment of associated parts or assemblies such as clutches,
transmissions, remote controls, etc., which are not manufactured by Briggs &
Stratton.
7 Damage or wear to parts caused by dirt, which entered the engine because of
improper air c leaner maintenance, re-assembly, or use of a non-original air cleaner
element or cartridge. At recommended intervals, clean and/or replace the filter as
stated in the Operator’s Manual.
8 Parts damaged by over-speeding, or overheating caused by grass, debris, or dirt,
which plugs, clogs radiator or air cooling access openings, or damage caused by
operating the engine in a confined area without sufficient ventilation. Engine damage
caused by not using accurate mix of anti-freeze and tap water, or water entering the
engine due to any cause.
9 Engine or equipment parts broken by excessive vibration caused by a loose engine
mounting, loose cutter blades, unbalanced blades or loose or unbalanced impellers,
improper attachment of equipment to engine crankshaft, over-speeding or other
abuse in operation.
10 Routine tune-up or adjustment of the engine.
11 Engine or engine component failure, i.e., combustion chamber, valves, valve seats,
valve guides, or burned starter motor windings, caused by the use of alternate fuels
such as, liquified petroleum, natural gas, altered gasolines, etc.
W arranty service is available only through authorized service dealers by Briggs &
Stratton Corporation. Locate your nearest Authorized Briggs & Stratton 3/LC
Service Dealer in our dealer locator map on BRIGGSandSTRATTON.COM or by
calling 1-800-233-3723, or as listed in the ‘Yello w Pages’.
Not for Reproduction
11
en
Briggs & Stratton Corporation (B&S), the California Air Resources Board (CARB) and the United States Environmental Protection
Agency (U.S. EPA) Emissions Control System Warranty Statement (Owner’s Warranty Rights and Obligations)
January 2010
California Emissions Control Warranty Statement
Your Warranty Rights and Obligations
and
United States Emissions Control Warranty Statement
Your Warranty Rights and Obligations.
The California Air Resources Board (CARB), U.S. EPA and B&S are pleased to explain
the Emissions Control System Warranty on your model year 2010 off-road spark-ignition
engine. In California, new off-road large spark-ignition engines must be designed, built
and equipped to meet the State’s stringent anti-smog standards. Elsewhere in the United
States, new Non-road spark-ignition engines certified for model year 2010, must meet
similar standards set forth by the U.S. EPA. B&S must warrant the emissions control
system on your engine for the period of time listed below, provided there has been no
abuse, neglect or improper maintenance of your engine.
Your emissions control system may include parts such as the carburetor or fuel injection
system, t he air cleaner, ignition system, muffler, and catalytic converter. Also included
may be hoses, belts, connectors and other emissions-related assemblies.
Where a warrantable condition exists, B&S will repair your engine at no cost to you
including diagnosis, parts and labor.
Briggs & Stratton Corporation Warranty Coverage
The 2010 and later off-road spark-ignition engines are warranted for two years. If any
emissions-related part on your engine is defective, the part will be repaired or replaced
by B&S.
Owner’s Warranty Responsibilities
As the engine owner, you are responsible for the performance of the required
maintenance listed in your Operator’s Manual. B&S recommends that you retain all your
receipts covering maintenance on your engine, but B&S cannot deny warranty solely for
the lack of receipts or for your failure to ensure the performance of all scheduled
maintenance.
As the engine owner, you should however be aware that B&S may deny you warranty
coverage if your engine or a part has failed due to abuse, neglect, improper maintenance
or unapproved modifications. You are responsible for presenting your engine to an
Authorized B&S Service Dealer as soon as a problem exists.
The warranty repairs should be completed in a reasonable amount of time, not to exceed
30 days. If you have questions regarding your warranty rights and responsibilities, you
should contact a B&S Service Representative at 1--800--233--3723.
EMISSION COMPLIANCE PERIOD: 1000 HOURS
General Emissions Warranty Coverage
B&S warrants to the ultimate purchaser and each subsequent purchaser that the off-road
engine is: designed, built and equipped so as to conform with all applicable regulations;
and free from defects in materials and workmanship that cause the failure of a warranted
part to be identical in all material respects to that part as described in B&S’s application
for certification. The warranty period begins on the date the off-road engine is delivered
to an ultimate purchaser or first placed into service. The warranty period is two years.
Subject to certain conditions and exclusions as stated below, the warranty on
emissions-related parts is as follows:
1. Any warranted part that is not scheduled for replacement as required maintenance
in the written instructions supplied, is warranted for the warranty period stated
above. If the part fails during the period of warranty coverage, the part will be
repaired or replaced by B&S according to subsection (4) below. Any such part
repaired or replaced under warranty will be warranted for the remainder of the
period.
2. Any warranted part that is scheduled only for regular inspection in the written
instructions supplied is warranted for the warranty period stated above. Any such
part repaired or replaced under warranty will be warranted for the remaining
warranty period.
3. Any warranted part that is scheduled for replacement as required maintenance in
the written instructions supplied is warranted for the period of time before the first
scheduled replacement date for that part. If the part fails before the first scheduled
replacement, the part will be repaired or replaced by B&S according to subsection
(4) below. Any such part repaired or replaced under warranty will be warranted for
the remainder of the period prior to the first scheduled replacement point for the
part.
4. Repair or replacement of any warranted part under the warranty provisions herein
must be performed at a warranty station at no charge to the owner.
5. Notwithstanding the provisions herein, warranty services or repairs will be provided
at all of our distribution centers that are franchised to service the subject engines or
equipment.
6. The off-road engine owner will not be charged for diagnostic labor that is directly
associated with diagnosis of a defective, emissions -related warranted part, provided
that such diagnostic work is performed at a warranty station.
7. B&S is liable f or damages to other engine or equipment components proximately
caused by a failure under warranty of any warranted part.
8. Throughout the off-road engine warranty period stated above, B&S will maintain a
supply of warranted parts sufficient to meet the expected demand for such parts.
9. Any replacement part may be used in the performance of any warranty
maintenance or repairs and must be provided without charge to the owner. Such
use will not reduce the warranty obligations of B&S.
10. Add-on or modified parts that are not exempted by the Air Resources Board may
not be used. The use of any non-exempted add-on or modified parts by the ultimate
purchaser will be grounds for disallowing a warranty claims. B&S will not be liable t o
warrant failures of warranted parts caused by the use of a non-exempted add-on or
modified part.
Warranted Parts
a. Fuel Metering System
• Carburetor and internal parts (if applicable)
• Cold start enrichment system (if applicable)
• Fuel injection system (if applicable)
• Air/fuel ratio feedback control system (if applicable)
• Fuel pump
• Fuel filter
b. Air I nduction System
• Air cleaner
• Intake manifold
• Throttle body (if applicable)
c. Ignition System
• Spark plug
• Ignition coil
• Ignition processor (if applicable)
d. Exhaust System
• Exhaust manifold (if applicable)
e. Catalyst System
• Catalytic converter (if applicable)
f. Miscellaneous Items Used in Above System
• Pressure, temperature, position, speed sensitive devices
• Electronic controls
• Connectors and assemblies
• Hoses
Not for Reproduction
12 BRIGGSandSTRATTON.COM
Îáùà èíôîðìàöèÿ
‚îâà ˜úêîâîäñòâî ñúäú˜¥à ñâåäåíè çà áåçîïàñíà ˜àáîòà, çà äà ñòå íàñíî ñ
àâà˜èèòå è îïàñíîñòèòå, ñâú˜çàíè ñ òåçè äâèãàòåëè è êàê äà ãè èçáãâàòå. ‚î
ñúäú˜¥à è èíñò˜óêöèè çà ï˜àâèëíàòà èì óïîò˜åáà è ïîää˜ú¥êà. ‚úé êàòî â
ÿî˜ïî˜àöè Briggs & Stratton íå áèõà ìîãëè äà çíàò êàêâà ìàμèíà ùå ñå
çàäâè¥âà ñ òîçè äâèãàòåë, âà¥íî å äà ï˜î…åòåòå è ˜àçáå˜åòå òåçè èíñò˜óêöèè u
èíñò˜óêöèèòå çà çàäâè¥âàíàòà ìàμèíà. Çàïèøåòå òåçè îðèãèíàëíè èíñòðóêöèè
çà áúäåùè ñïðàâêè.
Çà ˜åçå˜âíè …àñòè èëè òåõíè…åñêà ïîìîù çàïèμåòå îòäîëó ìîäåëà íà äâèãàòåë,
òèïà è êîäîâèòå íîìå˜à ñ äàòàòà íà êóïóâàíåòî ìó. ‚åçè íîìå˜à ñå íàìè˜àò âú˜õó
äâèãàòåë âè. (íàï˜àâåòå ñï˜àâêà íà ñò˜àíèöàòà ñ ˜àçäåë Åëåìåíòè è
Óïðàâëåíèÿ).
Äàòà íà êóïóâàíå:
Ìîäåë íà äâèãàòåëÿ:
MM/ÄÄ/øøøø
flîäåë: ÿîä:‚èï:
Èíôîðìàöèÿ çà íîìèíàëíàòà ìîùíîñò íà äâèãàòåëèòå
Çà äâèãàòåëèòå 3/LC (3-öèëèíä˜îâè ñ âîäíî îõëà¥äàíå) ïúëíàòà ìîùíîñò ñå
îñíîâàâà íà ê˜èòå˜èèòå ñúãëàñíî fi˜àâèëíèêà J1995 íà SAE (Ęó¥åñòâîòî íà
èí¥åíå˜èòå îò àâòîìîáèëíàòà ï˜îìèμëåíîñò è ò˜àíñïî˜òà), à ïîëåçíàòà ìîùíîñò
- ñúãëàñíî ê˜èòå˜èèòå îò J 1349 íà SAE. fiîëåçíàòà ï˜îèçâîäñòâåíà ìîùíîñò íà
äâèãàòåëè, ìîíòè˜àíè çà ˜àçëè…íè ï˜èëî¥åíè, ìî¥å äà âà˜è˜à â çàâèñèìîñò îò
ãîëì á˜îé ôàêòî˜è, âêë˚…èòåëíî ã˜àíè…íèòå îáî˜îòè íà ï˜èëî¥íè ìåõàíèçúì,
óñëîâèòà íà îêîëíàòà ñ˜åäà, ïîää˜ú¥êàòà íà äâèãàòåë/îáî˜óäâàíåòî è ä˜óãè
ï˜îìåíëèâè.
Òåõíèêà çà áåçîïàñíîñò íà îïåðàòîðà
Âçðèâîîïàñíî
Îòðîâíè
ãàçîâå
Äâèæåùè
ñå ÷àñòè
Îïàñíîñò çà ïîðàæåíèÿ
îò åëåêòðè÷åñêè ò îê
Ãîðåùà
ïîâúðõíîñò
Îáðàòåí
óäàð
Îãíåîïàñíî
Ïðåêðàòÿâàíå
ïîäàâàíåòî íà ãîðèâî
Ïðî÷åòåòå
Ðúêîâîäñòâîòî
Ñìóêà÷
Ìàñëî
Ãîðèâî
Âêë. Èçêë.
Äà ñå íîñÿò
ïðåäïàçíè î÷èëà
Áúðçè
îáîðîòè
Áàâíè
îáîðîòè
ÑÈÌÂÎËÈ ÇÀ ÁÅÇÎÏÀÑÍÎÑÒ È ÓÏÐÀÂËÅÍÈÅ
Îïàñíè
õèìèêàëè
Îïàñíîñò îò
èçìðúçâàíå
Ãîðåùà
òå÷íîñò
èëè ïàðà
Ñòîï
fi˜åäóï˜åäèòåëíèò ñèìâîë çà îïàñíîñò îï˜åäåë ï˜åäîõ˜àíèòåëíà
èíôî˜ìàöè çà ˜èñêîâå, êîèòî ìîãàò äà äîâåäàò äî íà˜àíâàíå íà ïå˜ñîíàëà.
Ñèãíàëèçè˜àùà äóìà (›fiæÑ‹›, fiˆÅćfiˆÅ≠ÄÅ‹¤Å èëè ◊‹¤fl拤Å) ñå ïîñòàâ
çàåäíî ñ ï˜åäóï˜åäèòåëåí ñèìâîë, çà äà ïîñî…è âå˜îòíîñòòà è ïîòåíöèàëíàòà
ñå˜èîçíîñò íà íà˜àíâàíåòî. Äîïúëíèòåëíî, åäèí ñèìâîë çà îïàñíîñò ìî¥å äà
ïîêàçâà âèäà íà îïàñíîñòòà.
ÎÏÀÑÍÎ ïîñî…âà îïàñíîñò, êîòî, àêî íå áúäå èçáåãíàòà, ùå äîâåäå
äî ñìúðò èëè ñåðèîçíî íàðàíÿâàíå.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ ïîñî…âà îïàñíîñò, êîòî, àêî íå áúäå
èçáåãíàòà, ìîæå äà äîâåäå äî ñìúðò èëè ñåðèîçíî íàðàíÿâàíå.
ÂÍÈÌÀÍÈÅ ïîñî…âà îïàñíîñò, êîòî, àêî íå áúäå èçáåãíàòà, ìîæå äà
äîâåäå äî ìàëêà èëè ñðåäíà ñòåïåí íà íàðàíÿâàíå.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ ïîñî…âà ñèòóàöè,êîòî áèìîãëàäàäîâåäå
äî ïîâðåæäàíå íà ïðîäóêòà.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
‹êîè îò ñúñòàâíèòå åëåìåíòè íà òîçè ï˜îäóêò è ñâú˜çàíèòå ñ òõ
ï˜èñïîñîáëåíè ñúäú˜¥àò õèìè…íè âåùåñòâà, èçâåñòíè â ùàòà ÿàëèôî˜íè
êàòî ï˜è…èíèòåëè íà ˜àê, óâ˜åäà íà íîâî˜îäåíèòå èëè ä˜óãè óâ˜åäè íà
˜åï˜îäóêòèâíàòà ñïîñîáíîñò. Ñëåä ˜àáîòà ñ òõ, èçìèâàéòå ˜úöåòå ñè.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
¤çãî˜åëèòå ãàçîâå îò òîçè äâèãàòåë ñúäú˜¥àò õèìè…åñêè ñúåäèíåíè,
èçâåñòíè íà ùàòà ÿàëèôî˜íè êàòî ï˜è…èíèòåëè íà ˜àê, óâ˜å¥äàíè ï˜è
˜à¥äàíå, èëè ä˜óãè óâ˜å¥äàíè, ñâú˜çàíè ñ ˜åï˜îäóêòèâíîñòòà.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
ÿî˜ïî˜àöè Briggs & Stratton íå îäîá˜âàèíåïîçâîëâà èçïîëçâàíåòî íà
òåçè äâèãàòåëè âú˜õó âñúäåõîäè íà 3 êîëåëà, ìîòîöèêëåòè, óâåñåëèòåëíè
êîëè…êè/êà˜òèíã, ëåòàòåëíè àïà˜àòè èëè ò˜àíñïî˜òíè ñ˜åäñòâà çà ó…àñòèå â
ñúñòåçàòåëíè ìå˜îï˜èòè. ¤çïîëçâàíåòî íà òåçè äâèãàòåëè íà òàêèâà
ìàμèíè ìî¥å äà äîâåäå äî ìàòå˜èàëíè ùåòè, ñå˜èîçíè íà˜àíâàíè
(âêë˚…èòåëíî ïà˜àëèçà) è äî˜è äî ñìú˜ò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ‹àñòîùèò äâèãàòåë ñå äîñòàâ îò Briggs & Stratton áåç
ìàñëî. fi˜åäè äà ñòà˜òè˜àòå äâèãàòåë ñå óâå˜åòå, …å ñòå íàëåëè ìàñëî â íåãî
ñïî˜åä èíñò˜óêöèèòå â òîâà ˜úêîâîäñòâî. æêî ãî ñòà˜òè˜àòå áåç ìàñëî, òîé ùå ñå
ïîâ˜åäè, áåç äà áúäå âúçìî¥íî äà ñå ˜åìîíòè˜à è áåç ïîê˜èòèå îò ãà˜àíöèòà.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
Ïðè äîëèâàíå íà ãîðèâî
• ¤çêë˚…åòå äâèãàòåë è ãî îñòàâåòå äà ñå îõëàäè íàé-ìàëêî 2 ìèíóòè,
ï˜åäè äà ñâàëèòå êàïà…êàòà íà ˜åçå˜âîà˜à çà ãî˜èâî.
• fiúëíåòå ˜åçå˜âîà˜à çà ãî˜èâî íà îòê˜èòî èëè â äîá˜å âåíòèëè˜àíî
ïîìåùåíèå.
• íå ï˜åïúëâàéòå ˜åçå˜âîà˜à çà ãî˜èâî. Çà äà ïîçâîëèòå ˜àçμè˜åíèå íà
áåíçèíà, íå ïúëíåòå íàä äîëíàòà îñíîâà íà ãú˜ëîâèíàòà çà íàëèâàíå íà
ãî˜èâî.
• Ęú¥òå ãî˜èâîòî äàëå… îò èñê˜è, îòê˜èòè ïëàìúöè, ñèãíàëíè ëàìïè,
òîïëèíà è ä˜óãè çàïàëèòåëíè èçòî…íèöè.
• fi˜îâå˜âàéòå …åñòî ãî˜èâîï˜îâîäèòå, ˜åçå˜âîà˜à, êàïà…êàòà è
ñúåäèíåíèòà çà ïóêíàòèíè èëè òå…îâå. Çàìåíåòå ãè, àêî å íåîáõîäèìî.
• æêî ãî˜èâîòî ñå ˜àçëåå, èç…àêàéòå äîêàòî òî ñå èçïà˜è, ï˜åäè äà
ñòà˜òè˜àòå äâèãàòåë.
Ïðè ñòàðòèðàíå íà äâèãàòåëÿ
• ‡âå˜åòå ñå, …å çàïàëèòåëíàòà ñâåù, μóìîçàãëóμèòåë, êàïà…êàòà íà
˜åçå˜âîà˜à çà ãî˜èâî è âúçäóμíè ôèëòú˜ (àêî èìà òàêèâà) ñà íà
ìñòîòî ñè è ñà îáåçîïàñåíè.
• ‹å ˜àçâú˜òàéòå äâèãàòåë ñ èçâàäåíà çàïàëèòåëíà ñâåù.
• æêî äâèãàòåëò ñå çàäàâè, ïîñòàâåòå ñìóêà…à (àêî èìà òàêúâ) íà ïîçèöè
OPEN/RUN, ï˜èäâè¥åòå ˜ú…íàòà ãàç (àêî èìà òàêàâà) íà ïîçèöè FAST è
˜àçâú˜òàéòå, äîêàòî äâèãàòåëò ñòà˜òè˜à.
Ïðè ðàáîòåùà ìàøèíà
• ‹å íàêëîíâàéòå äâèãàòåë èëè ìàμèíàòà ïîä úãúë, êîéòî âîäè äî
˜àçëèâàíå íà ãî˜èâîòî.
• ‹å çàïóμâàéòå êàìå˜àòà íà êà˜áó˜àòî˜à, çà äà ñï˜åòå äâèãàòåë.
• ‹èêîãà íå ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåë ï˜è îòñò˜àíåí êîìïëåêò
íà âúçäóμíè ôèëòú˜ (àêî èìà òàêúâ) èëè ï˜è îòñò˜àíåí âúçäóμåí
ôèëòú˜ (àêî èìà òàêúâ).
Ïðè òðàíñïîðòèðàíå íà ìàøèíàòà
• ‚˜àíñïî˜òè˜àéòå ñ
fiˆæÇÅ‹ ˜åçå˜âîà˜, èëè ñ ê˜àí çà ïîäàâàíå íà ãî˜èâî
íà ïîçèöè OFF.
Ïðè ñêëàäèðàíå íà ãîðèâî èëè íà ìàøèíà ñ ãîðèâî â ðåçåðâîàðà
• Ñêëàäè˜àéòå äàëå… îò ïåùè, ïå…êè, âîäîíàã˜åâàòåëè èëè ä˜óãè
åëåêò˜è…åñêè ï˜èáî˜è, êîèòî èìàò ñèãíàëíè ëàìïè èëè ä˜óãè çàïàëèòåëíè
èçòî…íèöè, çàùîòî òå ìîãàò äà âúçïëàìåíò èçïà˜åíèòà îò ãî˜èâîòî.
Not for Reproduction
13
bg
Ïóñêàíåòî íà äâèãàòåëÿ ñúçäàâà èñêðåíå.
Èñêðåíåòî ìîæå äà âúçïëàìåíè íàìèðàùèòå ñå íàîêîëî
çàïàëèìè ãàçîâå.
Òîâà ìîæå äà äîâåäå äî åêñïëîçèÿ è ïîæàð.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
• æêî èìà èçòè…àíå íà ï˜è˜îäåí èëè âòå…íåí ãàç ï˜îïàí â ïîìåùåíèåòî, íå
ñòà˜òè˜àéòå äâèãàòåë.
• ‹å èçïîëçâàéòå ãî˜èâà çà íà…àëíî çàïàëâàíå ïîä íàëãàíå, çàùîòî
ïà˜èòå èì ñà çàïàëèòåëíè.
Äâèãàòåëèòå èçïóñêàò âúãëåðîäåí îêèñ, êîéòî å îòðîâåí ãàç, áåç
ìèðèñ è öâÿò.
Âäèøâàíåòî íà âúãëåðîäåí îêèñ ìîæå äà ïðè÷èíè ãàäåíå,
ïðèïàäúê èëè ñìúðò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
• Ñòà˜òè˜àéòå è ˜àáîòåòå ñ äâèãàòåë íàâúí.
• ‹å ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåë â çàòâî˜åíî ïîìåùåíèå, äî˜è è
ï˜è îòâî˜åíè â˜àòè èëè ï˜îçî˜öè.
Âúðòÿùèòå ñå ÷àñòè ìîãàò äà äîïðàò èëè çàõâàíàò ðúöå, êðàêà,
êîñà, îáëåêëî èëè ïðèíàäëåæíîñòè.
Ìîæå äà ñå äîñòèãíå äî òðàâìàòè÷íà àìïóòàöèÿ èëè ñåðèîçíî
íàðàíÿâàíå.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
• ˆàáîòåòå ñ äâèãàòåë ï˜è ïîñòàâåíè çàùèòíè êàïàöè.
• Ęú¥òå ˜úöåòå è ê˜àêàòà ñè äàëå… îò âú˜òùè ñå …àñòè.
• fi˜èâú˜çâàéòå äúëãèòå êîñè è ñâàëéòå óê˜àμåíèòà.
• ‹å íîñåòå ïî ñåáå ñè μè˜îêî îáëåêëî, âèñùè μíó˜îâå èëè âåùè, êîèòî
ìîãàò äà áúäàò çàõâàíàòè.
Ðàáîòåùèòå äâèãàòåëè îòäåëÿò òîïëèíà. ×àñòèòå íà äâèãàòåëèòå,
îñîáåíî øóìîçàãëóøèòåëÿ, ñòàâàò èçêëþ÷èòåëíî ãîðåùè.
Ïðè äîïèð ìîæå äà ïîëó÷èòå ñåðèîçíî èçãàðÿíå.
Ãîðèìèòå îòïàäúöè, êàòî ëèñòà, òðåâè, õðàñòàëàê è äðóãè, ìîãàò
äà ñå çàïàëÿò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
• ›ñòàâåòå μóìîçàãëóμèòåë, öèëèíäú˜à íà äâèãàòåë è ˜åá˜àòà äà ñå
îõëàäò, ï˜åäè äà ãè äîêîñâàòå.
• ›òñò˜àíåòå íàò˜óïàíèòå îòëîìêè îêîëî μóìîçàãëóμèòåë è öèëèíäú˜à.
• ¤çïîëçâàíåòî èëè ˜àáîòàòà ñ äâèãàòåë, ïî çàëåñåíè ñ ãî˜è, õ˜àñòè èëè ñ
ò˜åâè ïëîùè, ñïî˜åä fi˜àâèëíèêà íà ÿàëèôî˜íè çà îáùåñòâåíèòå
˜åñó˜ñè, ˆàçäåë 4442, ï˜åäñòàâëâà íà˜óμåíèå, îñâåí àêî äâèãàòåëò
íå å ñíàáäåí ñ èñê˜îãàñèòåë, ïîääú˜¥àí â åôèêàñíî ˜àáîòíî ñúñòîíèå,
êàêòî å îï˜åäåëåíî â ˆàçäåë 4442. ◊ ä˜óãèòå ùàòè è ôåäå˜àëíè
˚˜èñäèêöèè ìî¥å äà èìà ïîäîáíè çàêîíè. Ñâú˜¥åòå ñå ñ ï˜îèçâîäèòåë,
ï˜îäàâà…à íà ä˜åáíî èëè äèñò˜èáóòî˜à íà î˜èãèíàëíîòî ñúî˜ú¥åíèå, çà
äà ïîëó…èòå èñê˜îãàñèòåë, ï˜îåêòè˜àí çà ìîíòè˜àíàòà íà òîçè äâèãàòåë
èçïóñêàòåëíà ñèñòåìà.
Ìîãàò äà ñå ïîëó÷àò ñåðèîçíè èçãàðÿíèÿ îò îñâîáîæäàâàùàòà ñå
ïàðà èëè îò ãîðåùàòà îõëàæäàùà òå÷íîñò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
• ‹Å Ñ◊æ⁄ßÉ‚Å êàïà…êèòå îò ˜àäèàòî˜à èëè ˜åçå˜âîà˜à, àêî äâèãàòåëòå
ãî˜åù èëè ˜àáîòè.
• Ñï˜åòå äâèãàòåë è ãî îñòàâåòå äà ñå îõëàäè, ï˜åäè ñâàëíå íà
êàïà…êèòå íà ˜àäèàòî˜à èëè ˜åçå˜âîà˜à è ï˜åäè ñìíàòà èëè íàëèâàíåòî
íà îõëà¥äàùàòà òå…íîñò.
Ñëó÷àéíî èñêðåíå ìîæå äà äîâåäå äî ïîæàð èëè ïîðàçÿâàíå îò
åëåêòðè÷åñêè òîê.
Íåâîëíî ñòàðòèðàíå ìîæå äà äîâåäå äî çàõâàùàíå, òðàâìàòè÷íà
àìïóòàöèÿ èëè äî ðàíÿâàíå.
Îïàñíîñò îò ïîæàð
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ïðåäè èçâúðøâàíå íà ðåãóëèðîâêè è ïîïðàâêè:
• ›òêà…åòå êàáåëà íà çàïàëèòåëíàòà ñâåù è ãî ä˜ú¥òå äàëå… îò íå.
• ›òêà…åòå ìèíóñ-êëåìàòà íà àêóìóëàòî˜à (ñàìî ï˜è äâèãàòåëè ñ
åëåêò˜è…åñêè ñòà˜òå˜).
• ¤çïîëçâàéòå ñàìî ïîäõîäùè èíñò˜óìåíòè.
• ‹å çàñòîïî˜âàéòå ñ ˜åãóëè˜àùàòà ï˜ó¥èíà, ëîñòîâèòå ñ èñòåìè èëè ñ
ä˜óãè…àñòè,çàäàïîâèμèòå îáî˜îòèòå íà äâèãàòåë.
• ˆåçå˜âíèòå …àñòè ò˜áâà äà áúäàò ñúñ ñúùàòà êîíñò˜óêöè èäàñå
ìîíòè˜àò â ñúùîòî ïîëî¥åíèå, êàêòî î˜èãèíàëíèòå …àñòè. ˝àñòè îò ä˜óã
ï˜îèçâîäèòåë ìî¥å äà íå ˜àáîòò äîá˜å, ìî¥å äà ïîâ˜åäòàã˜åãàòàèëè
äà äîâåäàò äî íà˜àíâàíå.
• ‹å óä˜éòå ìàõîâèêà ñ …óê èëè òâú˜ä ï˜åäìåò, çàùîòî òîé ìî¥å äà ñå
ñò˜îμè ïî â˜åìå íà ˜àáîòà.
Ïðè èçïðîáâàíå çà èñêðà:
• ¤çïîëçâàéòå îäîá˜åí òèï òåñòå˜ çà ñâåùè.
• ‹å ï˜àâåòå ï˜îâå˜êà çà èñê˜à ï˜è èçâàäåíà çàïàëèòåëíà ñâåù.
Not for Reproduction
14 BRIGGSandSTRATTON.COM
Åëåìåíòè è óïðàâëåíèÿ
јàâíåòå èë˚ñò˜àöèòà
1
ñâàμè äâèãàòåë, çà äà ñå çàïîçíàåòå ñ
˜àçïîëî¥åíèåòî íà ˜àçëè…íèòå åëåìåíòè è óï˜àâëåíè.
A. flà˜êè˜îâêà íà äâèãàòåë
Ìîäåë Òèï Êîä
B. Çàïàëèòåëíà ñâåù
C. ‹èâîïîêàçàòåë
D. ›òâî˜ çà íàëèâàíå íà ìàñëî
E. flàñëåí ôèëòú˜
F. fi˜îáêà çà èçòî…âàíå íà ìàñëîòî
G. Äàò…èê çà íàëãàíå íà ìàñëîòî
H. Åëåêò˜è…åñêè ñòà˜òå˜
I. ÿà˜áó˜àòî˜
J. ‚å˜ìîñòàò
K. Çàïàëèòåëíà áîáèíà
L. ÿà˜òå˜ çà ìàñëîòî
M. Aëòå˜íàòî˜
N. Äàò…èê çà òåìïå˜àòó˜àòà íà îõëà¥äàùè àãåíò
O. Äâèãàòåë Äàòà ÿîä
P. ◊åíòèëàòî˜
Ðàáîòà
◊ìåñòèìîñò çà ìàñëî (íàï˜àâåòå ñï˜àâêà â ˜àçäåë Òåõíè÷åñêè äàííè)
Ïðåïîðúêè çà ìàñëîòî
Çà ïîëó…àâàíå íà íàé-äîá˜è òåõíè…åñêè ïîêàçàòåëè ï˜åïî˜ú…âàìå èçïîëçâàíåòî
íà ìàñëàòà íà Briggs & Stratton ñ ãà˜àíöè è ñå˜òèôèêàò çà êà…åñòâî. Ęóãè
âèñîêîêà…åñòâåíè ìàñëà ñ ìèåùè ï˜èñàäêè ñà ï˜èåìëèâè, àêî ñà êëàñèôèöè˜àíè
çà ˜àáîòíè ˜å¥èìè SF, SG, SH, SJ èëè ïî-âèñîêè. Äà íå ñå èçïîëçâàò ñïåöèàëíè
äîáàâêè.
◊úíμíèòå òåìïå˜àòó˜è îï˜åäåëò ï˜àâèëíè âèñêîçèòåò íà ìàñëîòî çà
äâèãàòåë. ¤çïîëçâàéòå òàáëèöàòà, çà äà èçáå˜åòå íàé-äîá˜è âèñêîçèòåò çà
î…àêâàíè äèàïàçîí íà âúíμíèòå òåìïå˜àòó˜è.
SAE 30.
10W-30
Ñèíòåòè÷íî 5W-30
5W-30
°F °C
* æêî ï˜è òåìïå˜àòó˜è ïîä 40°F(4°C) ñå èçïîëçâà ìàñëî SAE 30, òîâà ùå
äîâåäå äî ò˜óäíî ñòà˜òè˜àíå íà äâèãàòåë.
** fi˜è òåìïå˜àòó˜è íàä 80° F(27°C) èçïîëçâàíåòî íà ìàñëî 10 W-30 ìî¥å äà
ïîâèμè êîíñóìàöèòà íà ìàñëî. fi˜îâå˜âàéòå ïî …åñòî íèâîòî ìó.
Êàê ñå ïðîâåðÿâà/íàëèâà ìàñëî - Ôèãóðà
2 3
Ïðåäè íàëèâàíå èëè ïðîâåðÿâàíå íà ìàñëîòî
• ˆàçïîëî¥åòå õî˜èçîíòàëíî äâèãàòåë.
• fiî…èñòåòå ìñòîòî îêîëî îòâî˜à çà íàëèâàíå íà ìàñëî îò âñè…êè îòëîìêè.
1. Ñâàëåòå íèâîïîêàçàòåë çà ìàñëîòî (A) è ãî èçáú˜μåòå ñ …èñò ïëàò (·èãó˜à
2).
2. ¤çöëî âìúêíåòå íèâîïîêàçàòåë çà ãî˜èâîòî.
3. Ñâàëåòå íèâîïîêàçàòåë è ï˜îâå˜åòå íèâîòî íà ìàñëîòî. ‚î ò˜áâà äà áúäå
äî ìà˜êè˜îâêàòà FULL (B) íà íèâîïîêàçàòåë.
4. æêî å ïîíè¥åíî íèâîòî íà ìàñëîòî, ñíåìåòå êàïà…êàòà îò îòâî˜à çà íàëèâàíå
íà ìàñëî (J).
5. Ñâàëåòå íèâîïîêàçàòåë. ‹àëåéòå âíèìàòåëíî ìàñëîòî â äâèãàòåë ï˜åç
îòâî˜à çà ïúëíåíå (C). Íå ïðåïúëâàéòå.
Âàæíî: ÿîãàòî íàëèâàòå ìàñëî, ï˜àâèëíî âåíòèëè˜àíå ñå èçèñêâà, êàêòî
ñëåäâà:
• Ñâàëåòå íèâîïîêàçàòåë çà ìàñëîòî.
• ‡áåäåòå ñå, …å ïîääú˜¥àòå íó¥íîòî ˜àçñòîíèå (D) ìå¥äó ôóíèòà çà
íàëèâàíå íà ìàñëî (E) è ñòåíàòà íà îòâî˜à çà ïúëíåíå íà äâèãàòåë (C).
◊è¥òå ·èãó˜à 3.
6. flîíòè˜àéòå è çàòåãíåòå êàïà…êàòà íà îòâî˜à çà ïúëíåíå ñ ìàñëî.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: fi˜åäè äà ñòà˜òè˜àòå äâèãàòåë ãî èçáú˜μåòå îò
âñêàêâî ˜àçëíî ìàñëî.
7. Ñëåä íàëèâàíåòî íà ìàñëîòî, ïîñòàâåòå íèâîïîêàçàòåë. Ñòà˜òè˜àéòå è
îñòàâåòå äâèãàòåë äà ˜àáîòè ïåò ìèíóòè íà ï˜àçåí õîä. ¤çêë˚…åòå
äâèãàòåë. ¤ç…àêàéòå ò˜è ìèíóòè è ï˜îâå˜åòå íèâîòî íà ìàñëîòî. æêî ñå
íàëàãà, íàëåéòå îùå ìàñëî, çà äà äîñòèãíà íèâîòî ìó äî ìà˜êè˜îâêàòà FULL
(B) âú˜õó íèâîïîêàçàòåë (·èãó˜à 2).
8. fiîñòàâåòå íèâîïîêàçàòåë íà ìàñëîòî.
Íàëÿãàíå íà ìàñëîòî
æêî íèâîòî íà ìàñëîòî å ìíîãî íèñêî åäèí äàò…èê çà íàë ãàíå (àêî èìà òàêúâ),
èëè ùå ñï˜å äâèãàòåë, èëè ùå çàäåéñòâà àëà˜ìåíîòî ìó óñò˜îéñòâî. æêî òîâà ñå
ñëó…è, ñï˜åòå äâèãàòåë è ï˜îâå˜åòå íèâîòî íà ìàñëîòî ñ íèâîïîêàçàòåë.
æêî íèâîòî íà ìàñëîòî å ïîä ìà˜êè˜îâêàòà ADD, äîáàâåòå ìàñëî, äîêàòî
äîñòèãíå ìà˜êè˜îâêàòà FULL. Ñòà˜òè˜àéòå äâèãàòåë è ï˜îâå˜åòå íàëãàíåòî,
ï˜åäè äà ï˜îäúë¥èòå äà ˜àáîòèòå.
æêî íèâîòî íà ìàñëîòî å ìå¥äó ìà˜êè˜îâêèòå ADD è FULL íå ñòàðòèðàéòå
äâèãàòåë. ›áú˜íåòå ñå êúì íêîé óïúëíîìîùåí ï˜åäñòàâèòåë íà Briggs &
Stratton çà äâèãàòåë 3/LC, çà äà îòñò˜àíèòå ï˜îáëåìà ñ íàëãàíåòî íà ìàñëîòî.
Ïðåïîðúêè çà ãîðèâîòî
Ãîðèâîòî òðÿáâà äà îòãîâàðÿ íà ñëåäíèòå èçèñêâàíèÿ:
• ˝èñò, ï˜åñåí, áåçîëîâåí áåíçèí.
• flèíèìàëíî îêòàíîâî …èñëî îò 87/87 AKI (91 RON). Çà ãîëìà íàäìî˜ñêà
âèñî…èíà, âè¥òå ïî-äîëó.
• Ÿåíçèí ñúñ ñ úäú˜¥àíèå íà íå ïîâå…å îò 10% åòàíîë (áåíçîñïè˜ò) èëè äî
15% MTBE (ò˜è-ìåòèë áóòèëîâ åòå˜) å ï˜èåìëèâ.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ‹å èçïîëçâàéòå íå îäîá˜åíè áåíçèíè êàòî E85. ‹å
ñìåñâàéòå áåíçèíà ñ ìàñëî, íå ãî ìîäèôèöè˜àéòå çà ˜àáîòà ñ àëòå˜íàòèâíè
ãî˜èâà. ‚îâà ùå ïîâ˜åäè êîìïîíåíòèòå íà äâèãàòåë è ùå àíóëèðà ãàðàíöèÿòà
ìó.
Çà äà ï˜åäïàçèòå ãî˜èâíàòà ñèñòåìà îò îá˜àçóâàíå íà ñìîëè, äîáàâåòå
ñòàáèëèçàòî˜ â ãî˜èâîòî. ‹àï˜àâåòå ñï˜àâêà â Ñêëàäèðàíå. øî˜èâàòà íå ñà åäíè
ñúùè. æêî íàñòúïè ï˜îáëåì ñúñ ñòà˜òè˜àíåòî èëè òåõíè…åñêèòå ïîêàçàòåëè,
ñìåíåòå äîñòàâ…èöèòå èëè ìà˜êèòå íà ãî˜èâîòî. ‹àñòîùèòäâèãàòåëèìà
ñå˜òèôèêàò çà ˜àáîòà ñ áåíçèí. Ñèñòåìàòà çà áî˜áà ñ â˜åäíèòå åìèñèè çà òîçè
äâèãàòåë å EM (flîäèôèêàöèè íà äâèãàòåëèòå).
Ãîëÿìà íàäìîðñêà âèñî÷èíà
fi˜è íàäìî˜ñêè âèñî…èíè íàä 3 000 ôóòà (900 ìåò˜à) å ï˜èåìëèâ áåíçèí ñ
ìèíèìàëíî îêòàíîâî …èñëî 85/85 AKI (89 RON). Çà äà îñòàíå ñúâìåñòèì ñ
èçèñêâàíèòà çà íèâîòî íà â˜åäíèòå åìèñèè, ñå íàëàãà íàñò˜îéêà íà äâèãàòåë â
ñúîòâåòñòâèå ñ ãîëìàòà íàäìî˜ñêà âèñî…èíà. ˆàáîòàòà ìó áåç òàêàâà íàñò˜îéêà
ùå äîâåäå äî ïîíè¥àâàíå íà òåõíè…åñêèòå ïîêàçàòåëè, ïîâèμàâàíå íà
êîíñóìàöèòà íà ãî˜èâî è óâåëè…åíè â˜åäíè åìèñèè. ‹àï˜àâåòå ñï˜àâêà ï˜è
‡ïúëíîìîùåí ï˜åäñòàâèòåë íà Briggs & Stratton çà ñâåäåíè îòíîñíî ˜àáîòíàòà
íàñò˜îéêà íà äâèãàòåë 3/LC ï˜è ãîëìà íàäìî˜ñêà âèñî…èíà.
‹å ñå ï˜åïî˜ú…âà ˜àáîòà íà äâèãàòåë ñ ˜åãóëè˜àù êîìïëåêò çà ãîëìà
íàäìî˜ñêà âèñî…èíà ï˜è âèñî…èíè ïîä 2 500 ôóòà (762 ìåò˜à).
Êàê ñå íàëèâà ìàñëî - Ôèãóðà
4
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
Ïðè äîëèâàíå íà ãîðèâî
• ¤çêë˚…åòå äâèãàòåë è ãî îñòàâåòå äà ñå îõëàäè íàé-ìàëêî 2 ìèíóòè,
ï˜åäè äà ñâàëèòå êàïà…êàòà íà ˜åçå˜âîà˜à çà ãî˜èâî.
• fiúëíåòå ˜åçå˜âîà˜à çà ãî˜èâî íà îòê˜èòî èëè â äîá˜å âåíòèëè˜àíî
ïîìåùåíèå.
• íå ï˜åïúëâàéòå ˜åçå˜âîà˜à çà ãî˜èâî. Çà äà ïîçâîëèòå ˜àçμè˜åíèå íà
áåíçèíà, íå ïúëíåòå íàä äîëíàòà îñíîâà íà ãú˜ëîâèíàòà çà íàëèâàíå íà
ãî˜èâî.
• Ęú¥òå ãî˜èâîòî äàëå… îò èñê˜è, îòê˜èòè ïëàìúöè, ñèãíàëíè ëàìïè,
òîïëèíà è ä˜óãè çàïàëèòåëíè èçòî…íèöè.
• fi˜îâå˜âàéòå …åñòî ãî˜èâîï˜îâîäèòå, ˜åçå˜âîà˜à, êàïà…êàòà è
ñúåäèíåíèòà çà ïóêíàòèíè èëè òå…îâå. Çàìåíåòå ãè, àêî å íåîáõîäèìî.
• æêî ãî˜èâîòî ñå ˜àçëåå, èç…àêàéòå äîêàòî òî ñå èçïà˜è, ï˜åäè äà
ñòà˜òè˜àòå äâèãàòåë.
1. fiî…èñòåòå ï˜îñò˜àíñòâîòî îêîëî êàïà…êàòà íà ˜åçå˜âîà˜à çà ãî˜èâî îò
ì˜úñîòè è íàñëîâàíè. Ñâàëåòå êàïà…êàòà (A,·èãó˜à4).
2. ‹àïúëíåòå ˜åçå˜âîà˜à çà ãî˜èâî (B) ñ ãî˜èâî. Çà äà ïîçâîëèòå ˜àçμè˜åíèå íà
ãî˜èâîòî, íå ïúëíåòå íàä äîëíàòà îñíîâà íà ãú˜ëîâèíàòà çà íàëèâàíå íà
ãî˜èâî (C).
3. fiîñòàâåòå îá˜àòíî êàïà…êàòà.
Not for Reproduction
15
bg
Ïðåïîðúêè çà îõëàæäàùàòà òå÷íîñò
◊ìåñòèìîñò çà îõëà¥äàùàòà òå…íîñò (âè¥òå ˆúêîâîäñòâîòî çà ˜àáîòà íà
ï˜îèçâîäèòåë íà îáî˜óäâàíåòî)
Âàæíî: ‚îâà å äâèãàòåë, îõëà¥äàí ñ îõëà¥äàùà ò å…íîñò. 50/50% ñìåñ îò
íåñúäú˜¥àù ôîñôàòè àíòèô˜èç è âîäîï˜îâîäíà âîäà å íåîáõîäèìà çà
îõëà¥äàíå, îñèãó˜âàíå óñòîé…èâîñòòà íà êî˜îçè è ñìàçâàíåòî íà âîäíàòà
ïîìïà.
Êàê ñå ïðîâåðÿâà/íàëèâà îõëàæäàùàòà òå÷íîñò
Ìîãàò äà ñå ïîëó÷àò ñåðèîçíè èçãàðÿíèÿ îò îñâîáîæäàâàùàòà ñå
ïàðà èëè îò ãîðåùàòà îõëàæäàùà òå÷íîñò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
• ‹Å Ñ◊æ⁄ßÉ‚Å êàïà…êèòå îò ˜àäèàòî˜à èëè ˜åçå˜âîà˜à, àêî äâèãàòåëòå
ãî˜åù èëè ˜àáîòè.
• Ñï˜åòå äâèãàòåë è ãî îñòàâåòå äà ñå îõëàäè, ï˜åäè ñâàëíå íà
êàïà…êèòå íà ˜àäèàòî˜à èëè ˜åçå˜âîà˜à è ï˜åäè ñìíàòà èëè íàëèâàíåòî
íà îõëà¥äàùàòà òå…íîñò.
1. fi˜åäè ˜àáîòà, ï˜îâå˜åòå íèâîòî íà îõëà¥äàùàòà òå…íîñò. ‹èâîòî ù ò˜áâà
äà áúäå ìå¥äó ìà˜êè˜îâêèòå FULL è LOW/ADD, îòáåëçàíè íà ˜åçå˜âîà˜à çà
îõëà¥äàùà òå…íîñò. æêî íèâîòî ù å íèñêî, íàëåéòå â ˜åçå˜âîà˜à 50/50%
ñìåñ îò àíòèô˜èç, êîéòî íå ñúäú˜¥à ôîñôàòè è âîäà îò âîäîñíàáäèòåëíàòà
ì˜å¥à.
2. Çà äà ñâàëèòå êàïà…êàòà íà ˜åçå˜âîà˜à, ñëåä êàòî äâèãàòåëò å îõëàäåí,
ïîñòàâåòå ïà˜…å äåáåë ïëàò âú˜õó íå. ◊íèìàòåëíî îòâèéòå â ïîñîêà,
îá˜àòíà íà äâè¥åíèåòî íà …àñîâíèêîâàòà ñò˜åëêà.
3. æêî ˜åçå˜âîà˜úò å ï˜àçåí, äîëåéòå â íåãî è â ˜àäèàòî˜à îõëà¥äàùà òå…íîñò.
‹àï˜àâåòå ñï˜àâêà â ˆúêîâîäñòâîòî çà ˜àáîòà ñ îáî˜óäâàíåòî îòíîñíî
˜àçïîëî¥åíèåòî, ˜àáîòàòà è ïîää˜ú¥êàòà íà ˜åçå˜âîà˜à è ˜àäèàòî˜à çà
îõëà¥äàùàòà òå…íîñò.
4. Çà äà ñâàëèòå êàïà…êàòà íà ˜àäèàòî˜à, ñëåä êàòî äâèãàòåëò å îõëàäåí,
ïîñòàâåòå âú˜õó íå ïà˜…å äåáåë ïëàò. ◊íèìàòåëíî îòâèéòå â ïîñîêà,
îá˜àòíà íà äâè¥åíèåòî íà …àñîâíèêîâàòà ñò˜åëêà äî ïú˜âîòî è ñïè˜àíå. æêî
ïîä íå èçëèçà ïà˜à ïîä íàëãàíå, çàñòàíåòå íàçàä, çà äà èçáåãíåòå
íà˜àíâàíå. Ñëåä êàòî íàëãàíåòî ñïàäíå, íàòèñíåòå êàïà…êàòà íà ˜àäèàòî˜à
íàäîëó è îòâèéòå â ïîñîêà, îá˜àòíà íà äâè¥åíèåòî íà …àñîâíèêîâàòà
ñò˜åëêà.
Èçìåðâàòåëíè óðåäè è ñâåòëèííè èíäèêàòîðè
fiîêàçàíèòå èçìå˜âàòåëíè ó˜åäè è ñâåòëèííè èíäèêàòî˜è ñà ñòàíäà˜òíè è
ñúùåñòâóâàò â ˜àçëè…íè îïöèè, êîèòî ìîãàò äà áúäàò èçïîëçâàíè. Çà
˜àçïîëî¥åíèåòî è ôóíêöèîíè˜àíåòî èì íàï˜àâåòå ñï˜àâêà â ˆúêîâîäñòâîòî çà
˜àáîòà.
Òåðìîìåòúð çà îõëàæäàùàòà òå÷íîñò
fiîêàçâà òåìïå˜àòó˜àòà íà îõëà¥äàùàòà òå…íîñò, êîãàòî
êîíòàêòíèòêë˚… å íà ïîçèöè ON (◊êë.).
‹î˜ìàëåí îáõâàò - 80º √ 90º C (175º √ 195º F)
›ïàñåí îáõâàò - íàä 105º C (220º F)
×àñîâè áðîÿ÷
›ò…èòà ñóìà˜íè á˜îé ˜àáîòíè …àñîâå.
Èçìåðâàòåëåí óðåä çà íàëè÷íî ãîðèâî
fiîêàçâà îñòàâàùîòî â ˜åçå˜âîà˜à ãî˜èâî. Çà äà íàìàëèòå
êîíäåíçàöèòà íà âîäà, âèíàãè ïîääú˜¥àéòå ïúëåí ˜åçå˜âîà˜.
Ñâåòëèíåí èíäèêàòîð çà òåìïåðàòóðà
æêî ñâåòëèííèò èíäèêàòî˜ çà òåìïå˜àòó˜àòà ñâåòíå, çíà…è, …å
äâèãàòåëò å ï˜åã˜ë. Ñï˜åòå äâèãàòåë è ï˜îâå˜åòå íèâîòî íà
îõëà¥äàùàòà òå…íîñò (âè¥òå ˜àçäåë Êàê ñå ïðîâåðÿâà
îõëàæäàùàòà òå÷íîñò). fi˜îâå˜âàéòå ˜àäèàòî˜à çà íàñëîâàíè, êîèòî ìîãàò
äà îã˜àíè…àò âúçäóμíè ïîòîê.
Ñâåòëèíåí èíäèêàòîð çà çàïàëâàíå
ÿîãàòî êîíòàêòíèòêë˚… å íà ïîçèöè ON (◊êë.), ñâåòëèííèò
èíäèêàòî˜ çà çàïàëâàíå ò˜áâà äà ñâåòè. Âîì äâèãàòåëò çà˜àáîòè,
èíäèêàòî˜úò ò˜áâà äà èçãàñíå. æêî èíäèêàòî˜úò íå ñâåòè ï˜è êîíòàêòåí êë˚…
íà ïîçèöè ON (◊êë.), ï˜îâå˜åòå çà èçãî˜ë ï˜åäïàçèòåë.
Ñâåòëèíåí èíäèêàòîð çà íàëÿãàíå íà ìàñëîòî â äâèãàòåëÿ
ÿîãàòî êîíòàêòíèòêë˚… å íà ïîçèöè ON (◊êë.), ñâåòëèííèò
èíäèêàòî˜ çà íàëãàíåòî íà ìàñëîòî ò˜áâà äà ñâåòè. Âîì
äâèãàòåëò çà˜àáîòè, ñâåòëèííèò èíäèêàòî˜ çà íàëãàíåòî íà ìàñëîòî ò˜áâà
äà çàãàñíå. æêî ñâåòëèííèò èíäèêàòî˜ çà íàëãàíåòî íà ìàñëîòî ñâåòè ï˜è
˜àáîòåù äâèãàòåë, íåçàáàâíî ãî ñï˜åòå. fiú˜âî ï˜îâå˜åòå íèâîòî íà ìàñëîòî
(íàï˜àâåòå ñï˜àâêà â ˜àçäåë Êàê ñå ïðîâåðÿâà/íàëèâà ìàñëî). Ñëåä òîâà
ï˜îâå˜åòå åëåêò˜è…åñêàòà ñèñòåìà.
Ñâåòëèíåí èíäèêàòîð çà çàðåæäàíå
ÿîãàòî êîíòàêòíèòêë˚… å íà ïîçèöè ON (◊êë.), ñâåòëèííèò
èíäèêàòî˜ çà çà˜å¥äàíå ò˜áâà äà ñâåòè. Âîì äâèãàòåëò çà˜àáîòè,
èíäèêàòî˜úò ò˜áâà äà èçãàñíå. æêî ñâåòëèííèò èíäèêàòî˜ çà çà˜å¥äàíåòî
ñâåòè ï˜è ˜àáîòåù äâèãàòåë, ï˜îâå˜åòå åëåêò˜è…åñêàòà ñèñòåìà.
Êàê ñå ñòàðòèðà äâèãàòåëÿ - Ôèãóðà
5
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
Ïðè ñòàðòèðàíå íà äâèãàòåëÿ
• ‡âå˜åòå ñå, …å çàïàëèòåëíàòà ñâåù, μóìîçàãëóμèòåë, êàïà…êàòà íà
˜åçå˜âîà˜à çà ãî˜èâî è âúçäóμíè ôèëòú˜ (àêî èìà òàêèâà) ñà íà
ìñòîòî ñè è ñà îáåçîïàñåíè.
• ‹å ˜àçâú˜òàéòå äâèãàòåë ñ èçâàäåíà çàïàëèòåëíà ñâåù.
• æêî äâèãàòåëò ñå çàäàâè, ïîñòàâåòå ñìóêà…à (àêî èìà òàêúâ) íà ïîçèöè
OPEN/RUN, ï˜èäâè¥åòå ˜ú…íàòà ãàç (àêî èìà òàêàâà) íà ïîçèöè FAST è
˜àçâú˜òàéòå, äîêàòî äâèãàòåëò ñòà˜òè˜à.
Ïóñêàíåòî íà äâèãàòåëÿ ñúçäàâà èñêðåíå.
Èñêðåíåòî ìîæå äà âúçïëàìåíè íàìèðàùèòå ñå íàîêîëî
çàïàëèìè ãàçîâå.
Òîâà ìîæå äà äîâåäå äî åêñïëîçèÿ è ïîæàð.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
• æêî èìà èçòè…àíå íà ï˜è˜îäåí èëè âòå…íåí ãàç ï˜îïàí â ïîìåùåíèåòî, íå
ñòà˜òè˜àéòå äâèãàòåë.
• ‹å èçïîëçâàéòå ãî˜èâà çà íà…àëíî çàïàëâàíå ïîä íàëãàíå, çàùîòî
ïà˜èòå èì ñà çàïàëèòåëíè.
Äâèãàòåëèòå èçïóñêàò âúãëåðîäåí îêèñ, êîéòî å îòðîâåí ãàç, áåç
ìèðèñ è öâÿò.
Âäèøâàíåòî íà âúãëåðîäåí îêèñ ìîæå äà ïðè÷èíè ãàäåíå,
ïðèïàäúê èëè ñìúðò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
• Ñòà˜òè˜àéòå è ˜àáîòåòå ñ äâèãàòåë íàâúí.
• ‹å ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåë â çàòâî˜åíî ïîìåùåíèå, äî˜è è
ï˜è îòâî˜åíè â˜àòè èëè ï˜îçî˜öè.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ‹àñòîùèò äâèãàòåë ñå äîñòàâ îò Briggs & Stratton áåç
ìàñëî. fi˜åäè äà ñòà˜òè˜àòå äâèãàòåë ñå óâå˜åòå, …å ñòå íàëåëè ìàñëî â íåãî
ñïî˜åä èíñò˜óêöèèòå â òîâà ˜úêîâîäñòâî. æêî ãî ñòà˜òè˜àòå áåç ìàñëî, òîé ùà ñå
ïîâ˜åäè áåç äà áúäå âúçìî¥íî äà ñå ˜åìîíòè˜à è ãà˜àíöèòà íìà äà ïîê˜èâà
ùåòàòà.
Çàáåëåæêà: ‹êîè äâèãàòåëè è îáî˜óäâàíå ñà ñíàáäåíè ñ óñò˜îéñòâà çà
äèñòàíöèîííî óï˜àâëåíèå. ‹àï˜àâåòå ñ ï˜àâêà â ˆúêîâîäñòâîòî çà ˜àáîòà ñ
îáî˜óäâàíåòî çà ˜àçïîëî¥åíèåòî è ˜àáîòàòà ñ óñò˜îéñòâàòà çà äèñòàíöèîííî
óï˜àâëåíèå.
1. fi˜îâå˜åòå íèâîòî íà ìàñëîòî. ‹àï˜àâåòå ñï˜àâêà â ˜àçäåëà Êàê ñå
ïðîâåðÿâà/íàëèâà ìàñëî.
2. ‡âå˜åòå ñå, …å çàäâè¥âàùèòå óï˜àâëåíè íà îáî˜óäâàíåòî, àêî èìà òàêèâà,
ñà èçêë˚…åíè.
3. Çàâú˜òåòå ê˜àí…åòî çà ïîäàâàíå íà ãî˜èâî ( A), àêî èìà òàêîâà, íà ïîçèöè
∆on∆ (·èãó˜à 5).
4. fi˜åìåñòåòå ëîñòà íà ˜ú…íàòà ãàç (B) ìàëêî ñëåä ïîçèöèòà slow
.
5. Çàâú˜òåòå êë˚…à çà åëåêò˜è…åñêè ñòà˜òå˜ (D) íà ïîçèöè on/ start (·èãó˜à 5).
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: Çà äà ï˜îäúë¥èòå ¥èâîòà íà ñòà˜òå˜à, èçïîëçâàéòå
ê˜àòêè ñòà˜òîâè öèêëè, íå ïî-äúëãè îò 15 ñåê/ìèí. fi˜îäúë¥èòåëíîòî
˜àçâú˜òàíå ìî¥å äà ïîâ˜åäè ñòà˜òå˜à.
6. æêî äâèãàòåëò íå ñòà˜òè˜à âåäíàãà, èçòåãëåòå ëîñòà íà ñìóêà…à (C), àêî èìà
òàêúâ, íà ïîçèöè choke
.
Çàáåëåæêà: ›áèêíîâåíî èçïîëçâàíåòî íà ñìóêà… íå å íåîáõîäèìî ï˜è
ïîâòî˜íî ñòà˜òè˜àíå íà òîïúë äâèãàòåë.
7. Âîì äâèãàòåëò çàã˜åå, ïîñòàâåòå ëîñòà íà ñìóêà…à (C) íà ïîçèöè run
(˜àáîòåí ˜å¥èì)
.
Not for Reproduction
16
BRIGGSandSTRATTON.COM
Êàê äà ñïðåòå äâèãàòåëÿ - Ôèãóðà
5
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
• ‹å çàïóμâàéòå êàìå˜àòà íà êà˜áó˜àòî˜à, çà äà ñï˜åòå äâèãàòåë.
1. fi˜åìåñòåòå ˜ú…íàòà ãàç (B) íà ïîçèöè çà áàâíè îáî˜îòè slow
.
Çàâú˜òåòå êë˚…à (D) íà ïîçèöè off (èçêë.) (·èãó˜à 5). Ñâàëåòå êë˚…àèãî
ä˜ú¥òå íà áåçîïàñíî ìñòî, äàëå… îò îáñåãà íà äåöà.
2. Ñëåä ñïè˜àíå íà äâèãàòåë, çàâú˜òåòå ê˜àí…åòî çà ïîäàâàíå íà ãî˜èâîòî (A),
àêî èìà òàêîâà, íà çàòâî˜åíî ïîëî¥åíèå.
Òåõíè÷åñêî îáñëóæâàíå
‹èå âè ï˜åïî˜ú…âàìå äà ïîñåòèòå íêîé îò ‡ïúëíîìîùåíèòå ï˜åäñòàâèòåëè íà
Briggs & Stratton çà âñè…êè îïå˜àöèè ïî òåõíè…åñêîòî è ñå˜âèçíîòî îáñëó¥âàíå íà
äâèãàòåë 3/LC è ˜åçå˜âíèòå …àñòè.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ◊ñè…êè êîìïîíåíòè, èçïîëçâàíè ï˜è ï˜îèçâîäñòâîòî íà
òîçè äâèãàòåë, ò˜áâà äà áúäàò íà ìñòîòî ñè çà ï˜àâèëíàòà ìó ˜àáîòà.
Êîíòðîë í à åìèñèèòå
Ïîääðúæêàòà, ñìÿíàòà èëè ðåìîíòúò íà óñòðîéñòâàòà çà êîíòðîë íà
âðåäíèòå åìèñèè ìîãàò äà áúäàò èçâúðøâàíè îò âñåêè ðåìîíòåí öåõ èëè
òåõíèê, ðåìîíòèðàùè äâèãàòåëè, êîèòî íå ñå èçïîëçâàò çà òðàíñïîðòíè öåëè.
◊ñå ïàê, çà äà ïîëó…èòå ∆áåçïëàòíî∆ îáñëó¥âàíå íà óñò˜îéñòâàòà çà êîíò˜îë íà
â˜åäíèòå åìèñèè, ˜àáîòàòà ò˜áâà äà áúäå èçâú˜μåíà îò óïúëíîìîùåí çàâîäñêè
ï˜åäñòàâèòåë. ‹àï˜àâåòå ñï˜àâêà â øà˜àíöèòà îòíîñíî â˜åäíèòå åìèñèè.
Ñëó÷àéíî èñêðåíå ìîæå äà äîâåäå äî ïîæàð èëè ïîðàçÿâàíå îò
åëåêòðè÷åñêè òîê.
Íåâîëíî ñòàðòèðàíå ìîæå äà äîâåäå äî çàõâàùàíå, òðàâìàòè÷íà
àìïóòàöèÿ èëè äî ðàíÿâàíå.
Îïàñíîñò îò ïîæàð
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ïðåäè èçâúðøâàíå íà ðåãóëèðîâêè è ïîïðàâêè:
• ›òêà…åòå êàáåëà íà çàïàëèòåëíàò à ñâåù è ãî ä˜ú¥òå äàëå… îò íå.
• ›òêà…åòå ìèíóñ-êëåìàòà íà àêóìóëàòî˜à (ñàìî ï˜è äâèãàòåëè ñ
åëåêò˜è…åñêè ñòà˜òå˜).
• ¤çïîëçâàéòå ñàìî ïîäõîäùè èíñò˜óìåíòè.
• ‹å çàñòîïî˜âàéòå ñ ˜åãóëè˜àùàòà ï˜ó¥èíà, ëîñòîâèòå ñèñòåìè èëè ñ
ä˜óãè …àñòè, çà äà ïîâèμèòå îáî˜îòèòå íà äâèãàòåë.
• ˆåçå˜âíèòå …àñòè ò˜áâà äà áúäàò ñúñ ñúùàòà êîíñò˜óêöè èäàñå
ìîíòè˜àò â ñúùîòî ïîëî¥åíèå, êàêòî î˜èãèíàëíèòå …àñòè. ˝àñòè îò ä˜óã
ï˜îèçâîäèòåë ìî¥å äà íå ˜àáîòò äîá˜å, ìî¥å äà ïîâ˜åäò àã˜åãàòà èëè
äà äîâåäàò äî íà˜àíâàíå.
• ‹å óä˜éòå ìàõîâèêà ñ …óê èëè òâú˜ä ï˜åäìåò, çàùîòî òîé ìî¥å äà ñå
ñò˜îμè ïî â˜åìå íà ˜àáîòà.
Ïðè èçïðîáâàíå çà èñêðà:
• ¤çïîëçâàéòå îäîá˜åí òèï òåñòå˜ çà ñâåùè.
• ‹å ï˜àâåòå ï˜îâå˜êà çà èñê˜à ï˜è èçâàäåíà çàïàëèòåëíà ñâåù.
Ãðàôèê çà òåõíè÷åñêî îáñëóæâàíå
Íà âñåêè 8 ÷àñà èëè åæåäíåâíî
• Äà ñå ï˜îâå˜âà íèâîòî íà ìàñëîòî â äâèãàòåë
• Äà ñå ï˜îâå˜âà íèâîòî íà îõëà¥äàùàòà òå…íîñò
Ñëåä ïúðâèòå 50 ÷àñà ðàáîòà (Íà÷àëíà ðàçðàáîòêà)
• Äà ñå ñìåí ìàñëîòî íà äâèãàòåë *
Íà âñåêè 100 ÷àñà èëè åæåãîäíî
• Äà ñå ï˜îâå˜âà îïúâàíåòî íà âåíòèëàòî˜íè ˜åìúê
• Äà ñå ïî…èñòâà ˜àäèàòî˜à
• Äà ñå ïî…èñòâà âúçäóμíè ôèëòú˜
• Äà ñå ï˜îâå˜âà μóìîçàãëóμèòåë èäàñåïî…èñòâàèñê˜îãàñèòåë (àêî èìà
òàêèâà)
Íà âñåêè 150 ÷àñà èëè åæåãîäíî
• Äà ñå ñìåí ìàñëîòî íà äâèãàòåë *
• Äà ñå ñìåí ìàñëåíè ôèëòú˜
Íà âñåêè 600 ÷àñà èëè åæåãîäíî
• Äà ñå ñìåí âúçäóμíè ôèëòú˜.
• Äà ñå ï˜îâå˜âà ìå¥äèíàòà íà êëàïàíèòå H
• Äà ñå ñìåí ôèëòú˜à çà ãî˜èâî
• Äà ñå ñìåíò çàïàëèòåëíèòå ñâåùè
Åæåãîäíî
• Äà ñå ñìåí îõëà¥äàùàòà òå…íîñò
* Äà ñå ï˜îâå¥äà ïî-…åñòî îáñëó¥âàíå, êîãàòî ˜àáîòíèò ˜å¥èì å òå¥úê èëè ñå
˜àáîòè ï˜è âèñîêè òåìïå˜àòó˜è.
H ‹å ñå íàëàãà, îñâåí àêî íå áúäàò çàáåëçàíè ï˜îáëåìè ñ òåõíè…åñêèòå
ïîêàçàòåëè íà äâèãàòåë.
Ðåãóëèðàíå íà êàðáóðàòîðà
‹èêîãà íå ï˜àâåòå íàñò˜îéêè íà êà˜áó˜àòî˜à. ‚îé å ˜åãóëè˜àí â çàâîäà äà ˜àáîòè
åôåêòèâíî ï˜è ïîâå…åòî óñëîâè. ◊ñå ïàê, àêî ñå íàëàãàò íàñò˜îéêè íà äâèãàòåë
3/LC, ñå îáú˜íåòå êúì ‡ïúëíîìîùåí ñå˜âèçåí ï˜åäñòàâèòåë íà Briggs & Stratton.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: fi˜îèçâîäèòåëò íà îáî˜óäâàíåòî, íà êîåòî òîçè äâèãàòåë
ùå áúäå ìîíòè˜àí, îï˜åäåë ìàêñèìàëíèòå îáî˜îòè, ï˜è êîèòî ùå ˜àáîòè
äâèãàòåëò. Íå íàäâèøàâàéòå òåçè îáî˜îòè.
Êàê ñå ñìåíÿ çàïàëèòåëíàòà ñâåù - Ôèãóðà
6
fi˜îâå˜âàéòå ìå¥äèíàòà (A, ·èãó˜à 6) ñ ïîìîùòà íà êàëèáú˜ çà òåë (B). æêî å
íåîáõîäèìî, ˜åãóëè˜àéòå ìå¥äèíàòà. flîíòè˜àéòå è çàòåãíåòå ñâåùòà ñ
ï˜åïî˜ú…âàíè âú˜òù ìîìåíò. Çà ˜åãóëè˜àíå íà ìå¥äèíàòà èëè îòíîñíî
âú˜òùè ìîìåíò çà çàòãàíå, íàï˜àâåòå ñï˜àâêà â ˜àçäåë Òåõíè÷åñêè äàííè.
Çàáåëåæêà: ‹à íêîè ìåñòà, ìåñòíèò çàêîí èçèñêâà óïîò˜åáà íà ˜åçèñòî˜íà
ñâåù, çà äà ñå ïîäòèñíàò ˜àäèîñìóùåíèòà. æêî íàñòîùèòäâèãàòåëå
ôàá˜è…íî îáî˜óäâàí ñ ˜åçèñòî˜íà ñâåù, èçïîëçâàéòå ñúùè òèï ñâåù çà ñìíà.
Äà ñå ïðîâåðÿâà âíèìàòåëíî øóìîçàãëóøèòåëÿ è
èñêðîãàñèòåëÿ
Ðàáîòåùèòå äâèãàòåëè îòäåëÿò òîïëèíà. ×àñòèòå íà äâèãàòåëèòå,
îñîáåíî øóìîçàãëóøèòåëÿ, ñòàâàò èçêëþ÷èòåëíî ãîðåùè.
Ïðè äîïèð ìîæå äà ïîëó÷èòå ñåðèîçíî èçãàðÿíå.
Ãîðèìèòå îòïàäúöè, êàòî ëèñòà, òðåâè, õðàñòàëàê è äðóãè, ìîãàò
äà ñå çàïàëÿò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
• ›ñòàâåòå μóìîçàãëóμèòåë,öèëèíäú˜àíàäâèãàòåë è ˜åá˜àòà äà ñå
îõëàäò, ï˜åäè äà ãè äîêîñâàòå.
• ›òñò˜àíåòå íàò˜óïàíèòå îòëîìêè îêîëî μóìîçàãëóμèòåë è öèëèíäú˜à.
• ¤çïîëçâàíåòî èëè ˜àáîòàòà ñ äâèãàòåë, ïî çàëåñåíè ñ ãî˜è, õ˜àñòè èëè ñ
ò˜åâè ïëîùè, ñïî˜åä fi˜àâèëíèêà íà ÿàëèôî˜íè çà îáùåñòâåíèòå
˜åñó˜ñè, ˆàçäåë 4442, ï˜åäñòàâëâà íà˜óμåíèå, îñâåí àêî äâèãàòåëò
íå å ñíàáäåí ñ èñê˜îãàñèòåë, ïîääú˜¥àí â åôèêàñíî ˜àáîòíî ñúñòîíèå,
êàêòî å îï˜åäåëåíî â ˆàçäåë 4442. ◊ ä˜óãèòåùàòèèôåäå˜àëíè
˚˜èñäèêöèè ìî¥å äà èìà ïîäîáíè çàêîíè. Ñâú˜¥åòå ñå ñ ï˜îèçâîäèòåë,
ï˜îäàâà…à íà ä˜åáíî èëè äèñò˜èáóòî˜à íà î˜èãèíàëíîòî ñúî˜ú¥åíèå, çà
äà ïîëó…èòå èñê˜îãàñèòåë, ï˜îåêòè˜àí çà ìîíòè˜àíàòà íà ò îçè äâèãàòåë
èçïóñêàòåëíà ñèñòåìà.
Not for Reproduction
17
bg
›òñò˜àíåòå íàò˜óïàíèòå îòëîìêè îò ï˜îñò˜àíñòâàòà îêîëî μóìîçàãëóμèòåë è
öèëèíäú˜à. fi˜îâå˜åòå μóìîçàãëóμèòåë çà ïóêíàòèíè, êî˜îçè èëè ä˜óãà
ïîâ˜åäà. Äåìîíòè˜àéòå èñê˜îãàñèòåë, (àêî èìà òàêúâ) è ãî ï˜îâå˜åòå çà ïîâ˜åäà
èëè çàïóμâàíå ñúñ ñà¥äè. æêî îòê˜èåòå ïîâ˜åäà, ìîíòè˜àéòå ˜åçå˜âíèòå …àñòè,
ï˜åäè äà çàïî…íåòå ˜àáîòà.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ˆåçå˜âíèòå …àñòè ò˜áâà äà áúäàò ñúñ
ñúùàòà êîíñò˜óêöè è äà ñå ìîíòè˜àò â ñúùîòî ïîëî¥åíèå, êàêòî
î˜èãèíàëíèòå …àñòè. ˝àñòè îò ä˜óã ï˜îèçâîäèòåë ìî¥å äà íå ˜àáîòò äîá˜å,
ìî¥å äà ïîâ˜åäò àã˜åãàòà èëè äà äîâåäàò äî íà˜àíâàíå.
Êàê ñå ïðîâåðÿâà îõëàæäàùàòà òå÷íîñò
Âàæíî: ‚îâà å äâèãàòåë ñ îõëà¥äàùà òå…íîñò. Çà îõëà¥äàíå, îñèãó˜âàíå
óñòîé…èâîñòòà íà êî˜îçè è ñìàçâàíå íà âîäíàòà ïîìïà å íåîáõîäèìà ñìåñ
50/50% îò àíòèô˜èç, êîéòî íå ñúäú˜¥à ôîñôàòè è âîäà îò âîäîñíàáäèòåëíàòà
ì˜å¥à.
Ìîãàò äà ñå ïîëó÷àò ñåðèîçíè èçãàðÿíèÿ îò îñâîáîæäàâàùàòà ñå
ïàðà èëè îò ãîðåùàòà îõëàæäàùà òå÷íîñò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
• ‹Å Ñ◊æ⁄ßÉ‚Å êàïà…êèòå îò ˜àäèàòî˜à èëè ˜åçå˜âîà˜à, àêî äâèãàòåëòå
ãî˜åù èëè ˜àáîòè.
• Ñï˜åòå äâèãàòåë è ãî îñòàâåòå äà ñå îõëàäè, ï˜åäè ñâàëíå íà
êàïà…êèòå íà ˜àäèàòî˜à èëè ˜åçå˜âîà˜à è ï˜åäè ñìíàòà èëè íàëèâàíåòî
íà îõëà¥äàùàòà òå…íîñò.
1. fi˜îâå˜åòå íèâîòî íà îõëà¥äàùàòà òå…íîñò. ‹èâîòî ù ò˜áâà äà áúäå ìå¥äó
ìà˜êè˜îâêèòå FULL è LOW, èëè ADD, îòáåëçàíè íà ˜åçå˜âîà˜à çà
îõëà¥äàùà òå…íîñò. æêî íèâîòî ù å íèñêî, íàëåéòå â ˜åçå˜âîà˜à ñìåñ
50/50% îò àíòèô˜èç, êîéòî íå ñúäú˜¥à ôîñôàòè è âîäà îò
âîäîñíàáäèòåëíàòà ì˜å¥à.
2. Çà äà ñâàëèòå êàïà…êàòà íà ˜åçå˜âîà˜à, ñëåä êàòî äâèãàòåëò å îõëàäåí,
ïîñòàâåòå ïà˜…å äåáåë ïëàò âú˜õó íå. ◊íèìàòåëíî îòâèéòå â ïîñîêà,
îá˜àòíà íà äâè¥åíèåòî íà …àñîâíèêîâàòà ñò˜åëêà.
3. æêî ˜åçå˜âîà˜úò å ï˜àçåí, äîëåéòå îõëà¥äàùà òå…íîñò â íåãî è â ˜àäèàòî˜à.
›òíîñíî ˜àçïîëî¥åíèåòî, ˜àáîòàòà è ïîää˜ú¥êàòà íà ˜åçå˜âîà˜à è
˜àäèàòî˜à çà îõëà¥äàùàòà òå…íîñò, íàï˜àâåòå ñï˜àâêà â ˆúêîâîäñòâîòî çà
˜àáîòà ñ îáî˜óäâàíåòî.
4. Çà äà ñâàëèòå êàïà…êàòà íà ˜àäèàòî˜à, ñëåä êàòî äâèãàòåëò å îõëàäåí,
ïîñòàâåòå ïà˜…å äåáåë ïëàò âú˜õó íå. ◊íèìàòåëíî îòâèéòå â ïîñîêà,
îá˜àòíà íà äâè¥åíèåòî íà …àñîâíèêîâàòà ñò˜åëêà äî ïú˜âîòî ù ñïè˜àíå. æêî
ïîä íå èçëèçà ïà˜à ïîä íàëãàíå, çàñòàíåòå íàçàä, çà äà èçáåãíåòå
íà˜àíâàíå. Ñëåä êàòî íàëãàíåòî ñïàäíå, íàòèñíåòå êàïà…êàòà íà ˜àäèàòî˜à
íàäîëó è îòâèéòå â ïîñîêà, îá˜àòíà íà äâè¥åíèåòî íà …àñîâíèêîâàòà
ñò˜åëêà.
Êàê ñå ñìåíÿâà ìàñëîòî - Ôèãóðà
2 7
›ò˜àáîòèëîòî ìàñëî å îïàñåí îòïàäú…åí ï˜îäóêò è ò˜áâà äà ñå ñêëàäè˜à ïî
ïîäõîäù íà…èí. ‹å ãî èçõâú˜ëéòå ñ äîìàêèíñêèòå îòïàäúöè. fi˜îâå˜åòå
ñúâìåñòíî ñ îáùèíñêèòå âëàñòè, çà îáñëó¥âàù öåíòú˜ èëè çà ï˜åäñòàâèòåë íà
èíñòàëàöèè çà áåçîïàñíî äåïîíè˜àíå/˜åöèêëè˜àíå íà îò˜àáîòèëîòî ìàñëî.
Èçòî÷âàíå íà ìàñëîòî
1. fi˜è èçêë˚…åí, íî âñå îùå òîïúë äâèãàòåë, îòêà…åòå êàáåëèòå çà ñâåùèòå (F,
·èãó˜à 2) è ãè ä˜ú¥òå äàëå…å îò òõ.
2. Ñâàëåòå ï˜îáêàòà îò îòâî˜à çà èçòî…âàíå íà ìàñëîòî (G, ·èãó˜à 7). ¤çòî…åòå
ãî â ïîäõîäù êîíòåéíå˜.
3. Ñëåä êàòî ìàñëîòî å èçòî…åíî, ïîñòàâåòå è çàòåãíåòå ï˜îáêàòà.
Ñìÿíà íà ìàñëåíèÿ ôèëòúð
›òíîñíî èíòå˜âàëèòå çà ñìíàòà ìó íàï˜àâåòå ñï˜àâêà â êà˜òàòà Òåõíè÷åñêî
îáñëóæâàíå.
1. ¤çòî…âàíå íà ìàñëîòî îò äâèãàòåë. ‹àï˜àâåòå ñï˜àâêà â ˜àçäåë Èçòî÷âàíå
íà ìàñëîòî.
2. Ñâàëåòå ìàñëåíè ôèëòú˜ (H, ·èãó˜à 7) è ãî äåïîíè˜àéòå ïî ïîäõîäùè
íà…èí.
3. fi˜åäè äà ìîíòè˜àòå íîâè ìàñëåí ôèëòú˜, ëåêî ñìà¥åòå ôèëòú˜íàòà
ãà˜íèòó˜à ñ íîâî, …èñòî ìàñëî.
4. flîíòè˜àéòå ìàñëåíè ôèëòú˜ íà ˜úêà, äîêàòî ãà˜íèòó˜àòà îï˜å âúâ
ôèëòú˜íè àäàïòå˜, ñëåä êîåòî ãî çàòåãíåòå ñ îùå 1/2 äî 3/4 îáî˜îòà.
5. ‹àëèâàíå íà ìàñëî. ‹àï˜àâåòå ñï˜àâêà â ˜àçäåë Íàëèâàíå íà ìàñëî.
Íàëèâàíå íà ìàñëî
• ˆàçïîëî¥åòå õî˜èçîíòàëíî äâèãàòåë.
• fiî…èñòåòå ìñòîòî îêîëî îòâî˜à çà íàëèâàíå íà ìàñëî îò âñè…êè îòëîìêè.
• ‹àï˜àâåòå ñï˜àâêà â ˜àçäåë Òåõíè÷åñêè äàííè îòíîñíî âìåñòèìîñòòà çà
ìàñëîòî.
1. Ñâàëåòå íèâîïîêàçàòåë (A,·èãó˜à2).
2. Ñâàëåòå êàïà…êàòà íà îòâî˜à çà íàëèâàíå íà ìàñëî (J).
3. ‹àëåéòå âíèìàòåëíî ìàñëîòî â äâèãàòåë ï˜åç îòâî˜à çà ïúëíåíå (C). Íå
ïðåïúëâàéòå.
Âàæíî: ÿîãàòî íàëèâàòå ìàñëî, ï˜àâèëíî âåíòèëè˜àíå ñå èçèñêâà, êàêòî
ñëåäâà:
• Ñâàëåòå íèâîïîêàçàòåë çà ìàñëîòî.
• ‡áåäåòå ñå, …å ïîääú˜¥àòå íó¥íîòî ˜àçñòîíèå (D) ìå¥äó ôóíèòà çà
íàëèâàíå íà ìàñëî (E) è ñòåíàòà íà îòâî˜à çà ïúëíåíå íà äâèãàòåë (C).
◊è¥òå ·èãó˜à 3.
4. flîíòè˜àéòå è çàòåãíåòå êàïà…êàòà íà îòâî˜à çà ïúëíåíå ñ ìàñëî.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: fi˜åäè äà ñòà˜òè˜àòå äâèãàòåë ãî èçáú˜μåòå îò
âñêàêâî ˜àçëíî ìàñëî.
5. Ñëåä íàëèâàíåòî íà ìàñëîòî, ïîñòàâåòå íèâîïîêàçàòåë. Ñòà˜òè˜àéòå è
îñòàâåòå äâèãàòåë äà ˜àáîòè ïåò ìèíóòè íà ï˜àçåí õîä. fi˜îâå˜åòå çà
òå…îâå. ¤çêë˚…åòå äâèãàòåë. ¤ç…àêàéòå ò˜è ìèíóòè è ï˜îâå˜åòå íèâîòî íà
ìàñëîòî. æêî ñå íàëàãà, íàëåéòå îùå ìàñëî, çà äà äîñòèãíå íèâîòî ìó äî
ìà˜êè˜îâêàòà FULL (B) âú˜õó íèâîïîêàçàòåë (·èãó˜à 2).
6. fiîñòàâåòå íèâîïîêàçàòåë íà ìàñëîòî.
Êàê äà ñå îáñëóæâà âúçäóøíèÿ ôèëòúð - Ôèãóðà
8
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
• ‹èêîãà íå ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåë ï˜è îòñò˜àíåí êîìïëåêò
íà âúçäóμíè ôèëòú˜.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ‹å èçïîëçâàéòå ñãúñòåí âúçäóõ èëè ˜àçòâî˜èòåëè, çà äà
ïî…èñòâàòå ôèëòú˜à. Ñãúñòåíèò âúçäóõ ìî¥å äà ïîâ˜åäè ôèëòú˜à, à
˜àçòâî˜èòåëèòå ãî ˜àçòâà˜ò.
›òíîñíî èçèñêâàíè òà çà ñå˜âèçíî îáñëó¥âàíå, íàï˜àâåòå ñï˜àâêà â Êàðòàòà çà
òåõíè÷åñêîòî îáñëóæâàíå.
1. ›òâî˜åòå ôèêñàòî˜èòå (A) è ñâàëåòå êàïàêà (B). ◊è¥òå ·èãó˜à 8.
2. Ñâàëåòå âúçäóμíè ôèëòú˜ (C).
3. Çà äà îòñò˜àíèòå íàñëîâàíèòà, âíèìàòåëíî ïî…óêâàéòå âúçäóμíè ôèëòú˜
âú˜õó òâú˜äà ïîâú˜õíîñò. æêî å ï˜åêàëåíî çàìú˜ñåí, ñìåíåòå ãî ñ íîâ
ôèëòú˜.
4. flîíòè˜àéòå âúçäóμíè ôèëòú˜.
5. fiîñòàâåòå êàïàêà è çàòâî˜åòå ôèêñàòî˜èòå.
Êàê ñå ñìåíÿ ôèëòúðà çà ãîðèâî - Ôèãóðà
9
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
• Ęú¥òå ãî˜èâîòî äàëå… îò èñê˜è, îòê˜èòè ïëàìúöè, ñèãíàëíè ëàìïè,
òîïëèíà è ä˜óãè çàïàëèòåëíè èçòî…íèöè.
• fi˜îâå˜âàéòå …åñòî ãî˜èâîï˜îâîäèòå, ˜åçå˜âîà˜à, êàïà…êàòà è
ñúåäèíåíèòà çà ïóêíàòèíè è òå…îâå. Çàìåíéòå ãè àêî å íåîáõîäèìî.
• fi˜åäè ïî…èñòâàíå èëè ñìíà íà ôèëòú˜à çà ãî˜èâî, èçòî…åòå ˜åçå˜âîà˜à
èëè çàòâî˜åòå ê˜àí…åòî çà ïîäàâàíå íà ãî˜èâî.
• ˆåçå˜âíèòå …àñòè ò˜áâà äà áúäàò ñúñ ñúùîòî êà…åñòâî è äà ñå ìîíòè˜àò
â ñúùàòà ïîçèöè, êàêòî î˜èãèíàëíèòå …àñòè.
• æêî ãî˜èâîòî ñå ˜àçëåå, èç…àêàéòå äîêàòî òî ñå èçïà˜è, ï˜åäè äà
ñòà˜òè˜àòå äâèãàòåë.
1. fi˜åäè ñìíà íà ôèëòú˜à çà ãî˜èâî (A, ·èãó˜à 9), àêî èìà òàêúâ, èçòî…åòå
˜åçå˜âîà˜à çà ãî˜èâîòî èëè çàòâî˜åòå ê˜àí…åòî çà ïîäàâàíå íà ãî˜èâî. ◊
ï˜îòèâåí ñëó…àé, ãî˜èâîòî ìî¥å äà ï˜îòå…å, ñúçäàâàéêè îïàñíîñò îò ïî¥à˜
èëè åêñïëîçè.
2. ¤çïîëçâàéòå ïëîñêè êëåùè äà ï˜èòèñíåòå ïëàñòèíèòå (B) íà ñêîáèòå (C), ñëåä
òîâà ïëúçíåòå ñêîáèòå íàñò˜àíè îò ôèëòú˜à çà ãî˜èâî. ‡ñó…åòå è èçòåãëåòå
ãî˜èâîï˜îâîäèòå (D) îò ôèëòú˜à çà ãî˜èâî.
3. fi˜îâå˜åòå ãî˜èâîï˜îâîäèòå çà ïóêíàòèíè èëè òå…îâå. Çàìåíåòå ãè, àêî å
íåîáõîäèìî.
4. Ñìåíåòå ôèëòú˜à çà ãî˜èâî ñ î˜èãèíàëåí ˜åçå˜âåí ôèëòú˜.
5. Çàê˜åïåòå ãî˜èâîï˜îâîäèòå ñúñ ñêîáè, êàêòî å ïîêàçàíî.
Not for Reproduction
18
BRIGGSandSTRATTON.COM
Êàê ñå ïðîâåðÿâà/ðåãóëèðà ðåìúêà íà
âåíòèëàòîðà - Ôèãóðà
10
Ïðîâåðÿâàíå íà ðåìúêà íà âåíòèëàòîðà
1. fi˜îâå˜åòå ñúñòîíèåòî (A, ·èãó˜à 10). æêî ïî ˜åìúêà íà âåíòèëàòî˜à èìà
ïóêíàòèíè èëè å ïîâ˜åäåí, ñìåíåòå ãî ñ íîâ.
2. fi˜îâå˜åòå îïúâàíåòî (B) íà ˜åìúêà íà âåíòèëàòî˜à. ‹àòèñíåòå ñ˜åäàòà (C)
íà ˜åìúêà íà âåíòèëàòî˜à. æêî îïúâàíåòî å ï˜àâèëíî, ñ˜åäàòà íà ˜åìúêà ùå
ñå ï˜åìåñòâà ñ 3/8 √ 1/2 èí…à (10 √ 12 mm) ï˜è ï˜èëàãàíå íà 22 ïàóíäà (10
kg) ñèëà âú˜õó íå. æêî îïúâàíåòî å ñëàáî, ˜åãóëè˜àéòå ãî êàêòî ñëåäâà.
Ðåãóëèðàíå íà îïúâàíåòî íà ðåìúêà íà âåíòèëàòîðà
1. ˆàçõëàáåòå ìîíòà¥íèòå áîëòîâå íà àëòå˜íàòî˜à (D)è(E). ◊è¥òå ·èãó˜à 10).
2. fiîñòàâåòå ìîíòà¥íà ùàíãà ( F) ñ˜åùó àëòå˜íàòî˜à (G) è ñò˜àíàòà íà áëîêà íà
äâèãàòåë. Çà äà îáòåãíåòå ˜åìúêà íà âåíòèëàòî˜à, èçòåãëåòå ìîíòà¥íàòà
ùàíãà. Çàòåãíåòå â˜åìåííî ìîíòà¥íèòå áîëòîâå íà àëòå˜íàòî˜à.
3. fi˜îâå˜åòå îïúâàíåòî íà ˜åìúêà íà âåíòèëàòî˜à. ‹àï˜àâåòå ñï˜àâêà â ˜àçäåë
Ïðîâåðêà íà ðåìúêà íà âåíòèëàòîðà. æêî ñå íàëàãà, ïîâòî˜åòå ï˜îöåäó˜àòà.
4. Çàòåãíåòå ìîíòà¥íèòå áîëòîâå íà àëòå˜íàòî˜à.
Çàòåãíåòå áîëòà (D) ñ âú˜òù ìîìåíò îò 14 ïàóíäôóòà (19 Nm).
Çàòåãíåòå áîëòà (E) ñ âú˜òù ìîìåíò îò 45 ïàóíäôóòà (61 Nm).
Ñêëàäèðàíå
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
Ïðè ñêëàäèðàíå íà ãîðèâî èëè íà ìàøèíà ñ ãîðèâî â ðåçåðâîàðà
• Ñêëàäè˜àéòå äàëå… îò ïåùè, ïå…êè, âîäîíàã˜åâàòåëè èëè ä˜óãè
åëåêò˜è…åñêè ï˜èáî˜è, êîèòî èìàò ñèãíàëíè ëàìïè èëè ä˜óãè çàïàëèòåëíè
èçòî…íèöè, çàùîòî òå ìîãàò äà âúçïëàìåíò èçïà˜åíèòà îò ãî˜èâîòî.
Ãîðèâíà ñèñòåìà
øî˜èâîòî îñòà˜âà ñëåä ñêëàäè˜àíå çà ïîâå…å îò 30 äíè. ›ñòà˜ëîòî ãî˜èâî âîäè
äî îá˜àçóâàíå íà êèñåëèííè è ñìîëåñòè îòëî¥åíè â ãî˜èâíàòà ñèñòåìà èëè ïî
îñíîâíèòå …àñòè íà êà˜áó˜àòî˜à. Çà äà çàïàçèòå ãî˜èâîòî ñâå¥î, èçïîëçâàéòå
ñòàáèëèçàòî˜à çà ãî˜èâî FRESH START
®
íà Briggs & Stratton, êîéòî å äîñòúïåí
ïîä ôî˜ìàòà òå…íà äîáàâêà èëè ôëàêîí çà êàïêîâî ïîäàâàíå.
æêî ñå äîáàâ ñòàáèëèçàòî˜à çà ãî˜èâîòî ñúãëàñíî èíñò˜óêöèèòå, íìà íó¥äà
áåíçèíúò äà ñå èçòî…âà. ›ñòàâåòå äâèãàòåëò äà ˜àáîòè îêîëî 2 ìèíóòè, çà äà
öè˜êóëè˜à ñòàáèëèçàòî˜úò â ãî˜èâíàòà ñèñòåìà. ‚îãàâà äâèãàòåëò è ãî˜èâîòî
ìîãàòäàñåñúõ˜àíâàò äî 24 ìåñåöà.
æêî áåíçèíúò â äâèãàòåë íå å áèë îá˜àáîòâàí ñúñ ñòàáèëèçàòî˜, òîé ò˜áâà äà
áúäå èçòî…åí â ïîäõîäù çà öåëòà ñúä. ›ñòàâåòå äâèãàòåëò äà ˜àáîòè, äîêàòî
ñï˜å ïî˜àäè èç…å˜ïâàíå íà ãî˜èâîòî. Çà äà ïîääú˜¥àòå ñâå¥åñòòà íà ãî˜èâîòî
ï˜è ñêëàäè˜àíåòî ìó, ï˜åïî˜ú…âàìå èçïîëçâàíåòî íà ñòàáèëèçàòî˜.
Ìàñëîòî íà äâèãàòåëÿ
Äîêàòî äâèãàòåëò å âñå îùå òîïúë ñìåíåòå ìàñëîòî.
Îòêðèâàíå è îòñòðàíÿâàíå íà íåèçïðàâíîñòè
‹ó¥äàåòå ëè ñå îò ïîìîù? fiîñåòåòå BRIGGSandSTRATTON.COM èëè ñå îáàäåòå
íà 1-800-233-3723.
Òåõíè÷åñêè äàííè
Ñïåöèôèêàöèè çà äâèãàòåëÿ
flîäåë 580000
ˆàáîòåí îáåì 58,16 in
3
(953 cm
3
)
◊úò˜åμåí äèàìåòú˜ íà öèëèíäú˜à 2,835 in (72 mm)
ˆàáîòåí õîä íà áóòàëîòî 3,071 in (78 mm)
◊ìåñòèìîñò çà ìàñëî 3,5 qt (3,3 L)
Ðåãóëèðîâú÷íè äàííè *
flîäåë 580000
¤ñê˜îâà ìå¥äèíà íà çàïàëèòåëíàòà ñâåù 0,030 in (0,76 mm)
◊ú˜òù ìîìåíò çà çàòãàíå íà çàïàëèòåëíàòà ñâåù 180 lb-in (20 Nm)
flå¥äèíà íà ñìóêàòåëíè êëàïàí
Y
0,007 in (0,18 mm)
flå¥äèíà íà èçïóñêàòåëíè êëàïàí
Y
0,007 in (0,18 mm)
* flîùíîñòòà íà äâèãàòåë íàìàëâà ñ 3,5% íà âñåêè 1000 ôóòà (300 ìåò˜à) íàä
ìî˜ñêîòî íèâî è ñ 1% çà âñåêè 10° F(5,6° C) íàä 77° F(25° C). Äâèãàòåëòùå
˜àáîòè çàäîâîëèòåëíî ï˜è íàêëîí äî 15°. ‹àï˜àâåòå ñï˜àâêà â ˆúêîâîäñòâîòî çà
˜àáîòà ñ îáî˜óäâàíåòî çà áåç îïàñíèòå ã˜àíèöè çà ˜àáîòà íà íàêëîíè.
Y
Äà ñå ï˜îâå˜âà, êîãàòî äâèãàòåëò å ñòóäåí.
Îáèêíîâåíè ÷àñòè çà ïîääðúæêà n
Ñåðâèçíà ÷àñò Íîìåð íà ÷àñòòà
◊úçäóμåí ôèëòú˜ 820263
flàñëåí ôèëòú˜ 491056
·èëòú˜ çà ãî˜èâî 821026
øî˜èâíà äîáàâêà 5041
ˆåçèñòî˜íà çàïàëèòåëíà ñâåù 496055, 5066
ÿë˚… çà ñâåù 19374
¤ñê˜îâ òåñòå˜ 19400
V-îá˜àçåí ˜åìúê (940 mm) 821075
V-îá˜àçåí ˜åìúê (970 mm) 820893
n ‹èå âè ï˜åïî˜ú…âàìå äà ïîñåòèòå íêîé îò ‡ïúëíîìîùåíèòå ï˜åäñòàâèòåëè
íà Briggs & Stratton çà âñè…êè îïå˜àöèè ïî òåõíè…åñêîòî è ñå˜âèçíîòî îáñëó¥âàíå
íà äâèãàòåë 3/LC è ˜åçå˜âíèòå …àñòè.
Not for Reproduction
19
bg
ÃÀÐÀÍÖÈÎÍÍÀ ÏÎËÈÖÀ ÍÀ BRIGGS & STRATTON ÇÀ ÑÎÁÑÒÂÅÍÈÊ ÍÀ
3-ÖÈËÈÍÄÐÎÂ ÄÂÈÃÀÒÅË Ñ ÂÎÄÍÎ ÎÕËÀÆÄÀÍÅ 3/LC
Ñåïòåìâðè 2009 ã.
ÿî˜ïî˜àöè Briggs & Stratton ùå ˜åìîíòè˜à èëè çàìåíè áåçïëàòíî âñêà …àñò (âñè…êè …àñòè) íà äâèãàòåë, êîòî (êîèòî) å (ñà) ïîâ˜åäåíà(è), ïî˜àäè äåôåêòåí
ìàòå˜èàë èëè ï˜îèçâîäñòâî, èëè ïî˜àäè äâåòå. ‚˜àíñïî˜òíèòå ˜àçõîäè íà èçï˜àòåíèòå çà ˜åìîíò èëè ñìíà …àñòè ïî òàçè ãà˜àíöè ñå ïîåìàò îò êóïóâà…à.
‚àçè ãà˜àíöè å âàëèäíà çà îï˜åäåëåíè ñ˜îê è å ï˜åäìåò íà óñëîâèòà, ôèêñè˜àíè ïî-äîëó. Çà îáñëó¥âàíå ïî ãà˜àíöèòà ñå îáú˜íåòå êúì íàé-áëèçêè
‡ïúëíîìîùåí ñå˜âèçåí ï˜åäñòàâèòåë çà äâèãàòåëèòå 3 /LC, êîéòî ìî¥å äà îòê˜èåòå â íàμè óêàçàòåë íà àä˜åñ BRIGGSandSTRATTON.COM, èëè êàòî
ñå îáàäèòå íà òåëåôîí 1-800-233-3723, èëè êàòî å ïîñî…åíî â «≠úëòèòå ñò˜àíèöè».
Íÿìà äðóãà ñïåöèàëíà ãàðàíöèÿ. Ïîäðàçáèðàùèòå ñå ãàðàíöèè, âêëþ÷èòåëíî òåçè çà ãîäíîñòòà çà ïðîäàæáà èëè çà íÿêàêâà ñïåöèàëíà öåë, ñà
îãðàíè÷åíè äî åäíà ãîäèíà îò äàòàòà íà êóïóâàíå èëè äî ñðîêà, ðàçðåøåí ïî çàêîí. Âñè÷êè äðóãè ñâúðçàíè (ïî ïîäðàçáèðàíå) ãàðàíöèè ñå
èçêëþ÷âàò. Îòãîâîðíîñò çà ñëó÷àéíè èëè ïîñëåäâàùè ùåòè ñå èçêëþ÷âà â ñòåïåí, ðàçðåøåíà ïî çàêîí. ‹êîè ùàòè èëè ñò˜àíè íå ïîçâîëâàò
îã˜àíè…åíè çà â˜åìåò˜àåíåòî íà ïîä˜àçáè˜àùàòà ñå ãà˜àíöè,àíêîè ùàòè èëè ñò˜àíè íå ïîçâîëâàò èçêë˚…âàíåòî èëè îã˜àíè…àâàíåòî íà ñëó…àéíè èëè
ïîñëåäâàùè ùåòè, òàêà …å å âúçìî¥íî ãî˜íîòî îã˜àíè…åíèå è èçêë˚…åíèå äà íå âà¥è çà âàñ. ‚àçè ãà˜àíöè âè äàâà ñïåöèôè…íè çàêîíîâè ï˜àâà, à âèå
ìî¥åòå äà èìàòå è ä˜óãè òàêèâà, êîèòî ñå èçìåíò â åäèí èëè ä˜óã ùàò, èëè â åäíà èëè ä˜óãà ñò˜àíà.
ÎÃÐÀÍÈ×ÅÍÀ ÃÀÐÀÍÖÈß
ÍÀØ ÏÐÎÄÓÊÒ
Ãàðàíöèîíåí ïåðèîä Äâèãàòåë Vanguardt 3/LC Ãàðàíöèÿ çà îñíîâíè ÷àñòè * Ðåçåðâíè ÷àñòè è âëàãàí òðóä *
Çà ëè…íî è òú˜ãîâñêî ïîëçâàíå 2 ãîäèíè 3 ãîäèíè 2 ãîäèíè
* Îòáåëåæåòå ñëåäíèòå ñïåöèàëíè ãàðàíöèîííè ïåðèîäè: Çà öåëèòå íà òàçè ãà˜àíöèîííà ïîëèòèêà, ïîê˜èòèåòî çà ˜åçå˜âíèòå …àñòè è âëàãàíèòçà
çàìíàòà èì ò˜óä å çà ïå˜èîä îò 2 ãîäèíè. Ñàìî çà îñíîâíèòå ˜åçå˜âíè …àñòè ãà˜àíöèîííîòî ïîê˜èòèå å ˜àçμè˜åíî è çà ò˜åòàòà ˜àáîòíà ãîäèíà.
Ãàðàíöèÿòà çà îñíîâíèòå ÷àñòè (Ã.Î.×) ïîêðèâà, íî íå ñå îã˜àíè…àâà åäèíñòâåíî è ñàìî äî öèëèíä˜îâè áëîê, öèëèíä˜îâàòà ãëàâà, êîëåí…àòè âàë,
˜àçï˜åäåëèòåëíè âàë, çúáíèòå ï˜åäàâêè, áóòàëàòà, ìîòîâèëêèòå, ìàõîâèêà, êî¥óõà çà ìàõîâèêà, ìàñëåíàòà ïîìïà, âåíòèëàòî˜à, ˜åìú…íèòå μàéáè,
ìåõàíè…íè ˜åãóëàòî˜, ñìóêàòåëíè êîëåêòî˜ è ìàñëåíè êà˜òå˜. Ã.Î.× íå ïîêðèâà è íå ñå îã˜àíè…àâà åäèíñòâåíî è ñàìî çà áóòàëíèòå ñåãìåíòè,
ñìåíåìèòå ëàãå˜è, âîäíàòà ïîìïà, âñåêè åëåìåíò îò åëåêò˜è…åñêàòà èíñòàëàöè, çàäâè¥âàùèòå åëåìåíòè çà êëàïàíèòå, ñïîìàãàòåëíèòå …àñòè,
óïëúòíåíèòà, ãà˜íèòó˜èòå, êà˜áó˜àòî˜èòå, êîëåêòî˜à çà èçãî˜åëèòå ãàçîâå, ãúâêàâèòå ï˜îâîäè, âñè…êè åëåìåíòè íà ãî˜èâíàòà ñèñòåìà,
˜àçï˜úñêâàùèòå ä˚çè, íàãíåòàòåëíàòà ïîìïà, òó˜áîêîìï˜åñî˜à, μóìîçàãëó μèòåë, âñè…êè ôèëò˜è, ˜àäèàòî˜à, òå˜ìîñòàòà, çàïàëèòåëíèòå ñâåùè,
íàã˜åâàòåëíèòå ñâåùè è ïîìïèòå çà ïîäàâàíå íà ãî˜èâî. øà˜àíöèîííèò ïå˜èîä çàïî…âà îò äàòàòà íà êóïóâàíå îò ïú˜âè ïîò˜åáèòåë íà ä˜åáíî èëè îò
êóïóâà…à çà òú˜ãîâñêè öåëè è ï˜îäúë¥àâà çà ïå˜èîäà îò â˜åìå, ôèêñè˜àí â ãî˜íàòà òàáëèöà.
Íå å íåîáõîäèìà ðåãèñòðàöèÿ íà ãàðàíöèÿòà, çà äà ñå ïîëó÷è ãàðàíöèîííî îáñëóæâàíå çà ïðîäóêòèòå íà Briggs & Stratton. Ïàçåòå çà äîêàçàòåëñòâî
êâèòàíöèÿòà îò ïîêóïêàòà. Àêî íå îñèãóðèòå äîêàçàòåëñòâî çà íà÷àëíàòà äàòà íà êóïóâàíå, ïðè ïîèñêâàíå íà ãàðàíöèîííî îáñëóæâàíå, äàòàòà íà
ïðîèçâîäñòâî íà ïðîäóêòà ùå áúäå èçïîëçâàíà çà îïðåäåëÿíå íà ãàðàíöèîííèÿ ïåðèîä.
Îòíîñíî âàøàòà ãàðàíöèÿ
Briggs & Stratton ï˜èåìàò ñ ãîòîâíîñò ãà˜àíöèîííè ˜åìîíò è ñå èçâèíâàò çà
ï˜è…èíåíîòî âè íåóäîáñòâî. ◊ñåêè ›òî˜èçè˜àí ñå˜âèçåí ï˜åäñòàâèòåë íà Briggs
& Stratton ìî¥å äà îñúùåñòâè ãà˜àíöèîííèòå ˜åìîíòè íà äâèãàòåëèòå 3/LC.
fiîâå…åòî ãà˜àíöèîííè ˜åìîíòè ñå ï˜îâå¥äàò ˜óòèííî, íî ïîíêîãà å âúçìî¥íî
èñêàíèòà çà ãà˜àíöèîííî ñå˜âèçíî îáñëó¥âàíå äà íå ñà îï˜àâäàíè. ‹àï˜èìå˜,
ãà˜àíöè íìà äà ñå ï˜èçíàå, àêî ïîâ˜åäàòà â äâèãàòåë ñå äúë¥è íà íåï˜àâèëíà
óïîò˜åáà, íà ëèïñà íà ˜åäîâíî òåõíè…åñêî îáñëó¥âàíå, íà íåï˜àâèëíî
ò˜àíñïî˜òè˜àíå, ìàíåâ˜è˜àíå è ñ êëàäè˜àíå èëè íà íåêà…åñòâåí ìîíòà¥. Ñúùî
òàêà, ãà˜àíöèòà ñå ãóáè, àêî ñå˜èéíèò íîìå˜ íà äâèãàòåë å îòñò˜àíåí èëè ñà
ï˜àâåíè ï˜îìåíè ïî ñàìè äâèãàòåë.
æêîêóïóâà…úòíååñúãëàñåíñ˜åμåíèåòî íà Ñå˜âèçíè ï˜åäñòàâèòåë, ùå ñå
íàï˜àâè ï˜îó…âàíå, çà äà ñå óñòàíîâè äàëè ãà˜àíöèòà ñå ï˜èçíàâà. ¤çèñêâàéòå
îò Ñå˜âèçíè ï˜åäñòàâèòåë äà ï˜åäîñòàâè çà ï˜åãëåä âñè…êè äîïúëíèòåëíè
ôàêòè íà ñ âî äèñò˜èáóòî˜ èëè íà çàâîäà. æêî äèñò˜èáóòî˜úò èëè çàâîäúò ˜åμè,
…å òîâà èñêàíå å îï˜àâäàíî, êóïóâà…úò ùå áúäå íàïúëíî îáåçùåòåí çà
äåôåêòíèòå …àñòè. Çà äà ñå èçáåãíå íåäî˜àçóìåíèåòî, êîåòî ìî¥å äà âúçíèêíå
ìå¥äó êóïóâà…à è ï˜åäñòàâèòåë, ïî-äîëó ñà èçá˜îåíè íêîè îò ï˜è…èíèòå çà
ïîâ˜åäà â äâèãàòåë, êîèòî ãà˜àíöèòà íå ïîê˜èâà.
Íîðìàëíî èçíîñâàíå: Äâèãàòåëèòå, êàêòî âñè…êè ìåõàíè…íè óñò˜îéñòâà, ñå
íó¥äàò îò ïå˜èîäè…íà çàìíà íà …àñòè è îáñëó¥âàíå, çà äà ˜àáîòò äîá˜å.
øà˜àíöèòà íå ïîê˜èâà ˜åìîíòà, êîãàòî ï˜è íî˜ìàëíî èçíîñâàíå äàäåíà …àñò èëè
äâèãàòåëò ñà èç…å˜ïàëè ¥èâîòà ñè. øà˜àíöèòà íå ñå ï˜èëàãà, àêî â äâèãàòåë ñå
ñëó…è ïîâ˜åäà, ïî˜àäè íåï˜àâèëíî ïîëçâàíå èëè îòñúñòâèå íà ˜óòèííà
ïîää˜ú¥êà, ò˜àíñïî˜òè˜àíå, ìàíèïóëè˜àíå, ñúõ˜àíâàíå èëè íåï˜àâèëåí
ìîíòà¥. Ñúùî òàêà, ãà˜àíöèòà ñå ãóáè, àêî ñå˜èéíèò íîìå˜ íà äâèãàòåë å
îòñò˜àíåí èëè ïî íåãî ñà ï˜àâåíè ï˜îìåíè.
Íåïðàâèëíî ïîääúðæàíå: ≠èâîòúò íà äàäåí äâèãàòåë çàâèñè îò óñëîâèòà, ï˜è
êîèòî ˜àáîòè è îò ã˜è¥èòå, êîèòî ïîëó…àâà. ‹êîè ï˜èëî¥åíè, êàòî
êóëòèâàòî˜è, ïîìïè, è ˜îòàöèîííè êîñà…êè, ìíîãî …åñòî ñå èçïîëçâàò â ï˜àμíà è
çàìú˜ñåíà ñ˜åäà, êîåòî ìî¥å äà äîâåäå äî ï˜åäâà˜èòåëíîòî èì èçíîñâàíå.
‚àêîâà èçíîñâàíå íå ñå ïîê˜èâà îò ãà˜àíöèòà, êîãàòî ñå äúë¥è íà ì˜úñîòè,
ï˜àõ, àá˜àçèâ çà ïî…èñòâàíå íà ñâåùòà èëè ä˜óãè àá˜àçèâíè ìàòå˜èàëè,
ïîïàäíàëè â äâèãàòåë ïî˜àäè íåêà…åñòâåíî ïîääú˜¥àíå.
Òàçè ãàðàíöèÿ ïîêðèâà ñàìî
óïîòðåáåí â äâèãàòåëÿ äåôåêòåí ìàòåðèàë
è/èëè èçðàáîòêà, à íå çàìÿíàòà èëè âúçñòàíîâÿâàíåòî íà ìàøèíàòà, êúì
êîÿòî äâèãàòåëÿò ìîæå äà áúäå ìîíòèðàí. Ãàðàíöèÿòà íå ïîêðèâà è
ïîèñêàíè ðåìîíòè ïîðàäè:
1 Äâèãàòåëè, êîèòî íå ñà ï˜àâèëíî ìîíòè˜àíè êúì ç àäâè¥âàíàòà ìàμèíà.
‹àñòîé…èâî ñå ï˜åïî˜ú…âà ï˜åäâà˜èòåëíî äà ñå îáú˜íåòå êúì çàâîäà, êîãàòî
ùå ìîíòè˜àòå 3-öèëèíä˜îâ äâèãàòåë ñ âîäíî îõëà¥äàíå B&S 3/LC êúì
ìàμèíà, êîòî íå èçïîëçâà, ïî íà…àëî, äâèãàòåë B&S 3/LC.
2 Ïðîáëåìè, ïðè÷èíåíè îò ÷àñòè, êîèòî íå ñà îðèãèíàëíè ÷àñòè íà Briggs &
Stratton.
3 ‡ñò˜îéñòâà çà óï˜àâëåíèå íà ìàμèíàòà èëè ñúî˜ú¥åíè, êîèòî ï˜å…àò íà
ñòà˜òè˜àíåòî íà äâèãàòåë, âîäò äî íåçàäîâîëèòåëíàòà ìó ˜àáîòà èëè
ñêúñâàò ¥èâîòà ìó. (ÿîíñóëòè˜àéòå ñå ñ ï˜îèçâîäèòåë íà óñò˜îéñòâàòà.)
4 ÿà˜áó˜àòî˜è ñ òå…îâå, çàä˜úñòåíè ï˜îâîäè èëè ˜àçï˜úñêâàùè ä˚çè çà
ãî˜èâîòî, çàëåïíàëè êëàïàíè, çàìú˜ñåíè íàãíåòàòåëíè ïîìïè èëè ä˜óãà
ïîâ˜åäà, ï˜è…èíåíà îò çàìú˜ñåíî èëè ï˜åñòîëî ãî˜èâî. ‡ïîò˜åáâàéòå
…èñòî, ï˜ñíî ãî˜èâî (áåíçèí áåç ñúäú˜¥àíèå íà îëîâî, äèçåëîâî ãî˜èâî) è
ñòàáèëèçàòî˜ íà ãî˜èâî Briggs & Stratton ñ êàòàëî¥åí No 5041.
5 ˝àñòè, êîèòî ñà íàä˜àíè èëè ñ…óïåíè, çàùîòî äâèãàòåëò å ˜àáîòèë ñ
íåäîñòàòú…íî èëè çàìú˜ñåíî ìàñëî, èëè ñ ìàñëî ñ íåïîäõîäùî êà…åñòâî
(fi˜îâå˜âàéòå å¥åäíåâíî íèâîòî íà ìàñëîòî èëè ñëåä âñåêè 8 …àñà ˜àáîòà.
ÿîãàòî å íåîáõîäèìî, äîëèâàéòå è ñìåíéòå ìàñëîòî è ìàñëåíè ôèëòú˜ íà
ï˜åïî˜ú…âàíèòå èíòå˜âàëè îò â˜åìå). æâà˜èéíîòî óñò˜îéñòâî OIL GARD
ìî¥å äà íå ñï˜å ˜àáîòåùè äâèãàòåë. æêî íèâîòî íà ìàñëîòî íå ñå ïîääú˜¥à
òî…íî, äâèãàòåëò ìî¥å äà ñå ïîâ˜åäè. fi˜î…åòåòå ˆúêîâîäñòâîòî ç à ˜àáîòà.
6 ˆåìîíò èëè ˜åãóëè˜àíå íà ìîíòè˜àíè …àñòè èëè àã˜åãàòè êàòî ñúåäèíèòåëè,
ï˜åäàâàòåëíè ìåõàíèçìè, äèñòàíöèîííè óï˜àâëåíè èä˜.,êîèòîíåñà
ï˜îèçâåäåíè îò Briggs & Stratton.
7 fiîâ˜åäà èëè èçíîñâàíå íà …àñòè, ï˜è…èíåíè îò íå…èñòîòè, ïîïàäíàëà â
äâèãàòåë, ïî˜àäè íåêà…åñòâåíî ïîääú˜¥àíå íà âúçäóμíè ôèëòú˜,
íåêà…åñòâåí ïîâòî˜åí ìîíòॠèëè îò èçïîëçâàíå íà íåî˜èãèíàëíè åëåìåíòè
çà ôèëòú˜à. ‹à ï˜åïî˜ú…âàíèòå èíòå˜âàëè îò â˜åìå ïî…èñòâàéòå è/èëè
ñìåíâàéòå ôèëòú˜à, êàêòî å ïîñî…åíî â ˆúêîâîäñòâîòî çà ˜àáîòà.
8 ˝àñòè, ïîâ˜åäåíè ïî˜àäè íàäâèμåíè ìàêñèìàëíè îáî˜îòè èëè ïî˜àäè
ï˜åã˜âàíå, äúë¥àùî ñå íà ò˜åâè, íàñëîâàíè èëè çàìú˜ñâàíå, êîèòî
çàïóμâàò, çàä˜úñòâàò ˜àäèàòî˜à èëè îòâî˜èòå ç à äîñòúï íà îõëà¥äàùè
âúçäóõ, èëè ïîâ˜åäà, äúë¥àùà ñå íà ˜àáîòà â çàòâî˜åíî ï˜îñò˜àíñòâî ñ
íåäîñòàòú…íà âåíòèëàöè. fiîâ˜åäà íà äâèãàòåë, äúë¥àùà ñå íà
íåñïàçâàíåòî íà òî…íîòî ñúîòíîμåíèå íà àíòèô˜èç è ïèòåéíà âîäà èëè íà
ï˜îíèêâàíåòî íà âîäà â íåãî ïî íêàêâà ï˜è…èíà.
9 ˝àñòè íà äâèãàòåë èëè ìàμèíàòà, ñ…óïåíè îò ï˜åêîìå˜íà âèá˜àöè,
äúë¥àùà ñå íà õëàáàâ ìîíòॠíà äâèãàòåë, õëàáàâè ˜å¥åùè íî¥îâå,
õëàáàâè ïëàñòèíè è õëàáàâè èëè çëå áàëàíñè˜àíè ˜àáîòíè êîëåëà, íà
íåäîá˜î êóïëè˜àíå íà ìàμèíàòà êúì êîëåí…àòè âàë íà äâèãàòåë,íà
ñâ˜úõâèñîêè îáî˜îòè èëè ä˜óãà çëîóïîò˜åáà ï˜è ˜àáîòà.
10 ˆóòèííà íàñò˜îéêà è ˜åãóëè˜îâêà íà äâèãàòåë.
11 fiîâ˜åäà íà äâèãàòåë èëè íà íåãîâ åëåìåíò, ò.å. ãî˜èâíà êàìå˜à, êëàïàíè,
êëàïàííè ëåãëà, êëàïàííè âîäà…è, èëè èçãî˜åëè íàìîòêè íà ñòà˜òå˜à ïî˜àäè
èçïîëçâàíåòî íà àëòå˜íàòèâíè ãî˜èâà êàòî íàôòà, ï˜è˜îäåí ãàç, áåíçèíè ñ
ï˜îìåíåíè êà…åñòâà è ò.í.
Ãàðàíöèîííîòî ñåðâèçíî îáñëóæâàíå å äîñòúïíî åäèíñòâåíî ÷ðåç
Îòîðèçèðàíèòå ñåðâèçíè ïðåäñòàâèòåëè íà Êîðïîðàöèÿ Briggs & Stratton.
Íàìåðåòå íàé-áëèçêèÿ Îòîðèçèðàí ñåðâèçåí ïðåäñòàâèòåë çà äâèãàòåëèòå
3/LC â íàøàòà óêàçàòåëíà êàðòà çà ïðåäñòàâèòåëèòå íà àäðåñ
BRIGGSandSTRATTON.COM, èëè êàòî ñå îáàäèòå íà òåë. 1-800-233-3723, èëè
êàêòî å ïîñî÷åíî â „Æúëòèòå ñòðàíèöè”.
Not for Reproduction
20 BRIGGSandSTRATTON.COM
Všeobecné informace
Tato pøíruèka obsahuje bezpeènostní informace nezbytné pro to, abyste vìdìli, jaká
nebezpeèí a rizika souvisí s motory a jak se jim vyhnout. Obsahuje i pokyny, jak øádnì
motor používat a jak se nìj starat. Vzhledem k tomu, že korporace Briggs & Stratton
nemusí nutnì vìdìt, jaké zaøízení bude tento motor pohánìt, je dùležité, abyste si
pøeèetli a pochopili tyto pokyny a pokyny pro zaøízení, které tento motor pohání.
Uschovejte originál tìchto pokynù pro budoucí použití.
Potøebujete-li náhradní díly nebo technickou pomoc, zapište dolù model motoru, typové a
kódové èíslo a datum nákupu. Tato naleznete na svém motoru (viz kapitola Funkce a
ovládací prvky).
Datum nákupu:
Model motoru:
DD/MM/RRRR
Model: Kód:Typ:
Informace o jmenovitém výkonu motoru
U motorù 3/LC je hrubý výkon motoru uvádìn v souladu s kritérii normy SAE J1995 a
èistý výkon motoru v souladu s kritérii normy SAE J1349. Skuteèný výkon produkèních
motorù nainstalovaných v konkrétních zaøízeních se mùže lišit v závislosti na mnoha
faktorech, vèetnì omezení otáèek motoru (RPM) pøi daném použití, podmínek životního
prostøedí, údržby motoru/zaøízení a dalších promìnných.
Bezpeènost obsluhy
Výbuch
Toxické výparyPohyblivé èásti
Úraz elektrickým
proudem
Horký povrch
Zpìtný ráz
Požár
Uzávìr paliva
Ètìte návod
Sytiè
Olej
Palivo
Zapnuto/Vypnuto
Používejte
ochranu zraku
Pomalu
Rychle
BEZPEÈNOSTNÍ A KONTROLNÍ SYMBOLY
Nebezpeèná
chemikálie
Omrzliny
Horká kapalina
nebo pára
Stop
Symbol bezpeènostního upozornìní oznaèuje bezpeènostní informace týkající se
rizik, která mohou zpùsobit úraz. Signální slovo (NEBEZPEÈÍ, UPOZORNÌNÍ nebo
VÝSTRAHA) se používá spolu s varovným symbolem pro vyznaèení pravdìpodobnosti a
potenciální vážnosti úrazu. Mimo to mùže být pro oznaèení druhu nebezpeèí použit symbol
nebezpeèí.
NEBEZPEÈÍ oznaèuje ohrožení, které, není-li eliminováno, zpùsobí smrt
nebo vážný úraz.
VAROVÁNÍ oznaèuje ohrožení, k teré, není-li eliminováno, mùže zpùsobit
smrt nebo vážný úraz.
POZOR oznaèuje ohrožení, které, není-li eliminováno, mùže zpùsobit lehký,
nebo støednì tìžký úraz.
POZNÁMKA oznaèuje situaci, v níž by mohlo dojít k poškození produktu.
VAROVÁNÍ
Nìkteré s ouèásti tohoto produktu a související pøíslušenství obsahují chemické
látky, o nichž je ve státì Kalifornie známo, že zpùsobují rakovinu, poškození plodu
èi jiné poruchy reprodukce. Po manipulaci si umyjte ruce.
VAROVÁNÍ
Výfukové plyny t ohoto výrobku obsahují chemikálie, o nichž je ve státì Kalifornie
známo, že zpùsobují rakovinu, poškození plodu èi jiné poruchy reprodukce.
VAROVÁNÍ
Briggs & Stratton neschvaluje ani nepovoluje použití tìchto motorù na tøíkolových
terénních vozidlech (ATV), motocyklech, zábavních/rekreaèních motokárách,
letadlech nebo vozidlech urèených pro sportovní soutìže. Takové použití tìchto
motorù by mohlo vést ke škodám na majetku, vážnému zranìní (vèetnì ochrnutí)
nebo i k e smrtelnému úrazu.
POZNÁMKA: Tento motor je dodáván firmou Briggs & Stratton bez oleje. Pøed
spuštìním motoru zkontrolujte hladinu oleje. Pokud spustíte motor bez oleje, mùže dojít
k jeho neopravitelnému poškození, na které se nebude vztahovat záruka.
VAROVÁNÍ
Palivo a jeho páry jsou vysoce hoølavé a výbušné.
Požár nebo výbuch mùže zpùsobit vážné popáleniny nebo i smrt
Když doplòujete palivo
• Vypnìte motor a pøed sejmutím uzávìru palivové nádrže jej nechte nejménì 2
minuty chladnout.
• Nádrž plòte venku nebo v dobøe vìtraném prostoru.
• Palivovou nádrž nepøeplòujte. Kvùli tepelné roztažnosti paliva naplòte nádrž
jen po spodní okraj hrdla.
• Chraòte palivo pøed jiskrami, otevøeným ohnìm, vìèným plamínkem, teplem
a jinými zdroji z apálení.
• Kontrolujte palivové potrubí, nádrž a uzávìr a všechny spoje na tìsnost a
praskliny. V pøípadì potøeby proveïte výmìnu.
• Jestliže rozlijete palivo, poèkejte, až se odpaøí a teprve potom spuste motor.
Pøi spouštìní motoru
• Zkontrolujte, zda jsou na svém místì svíèky, tlumiè výfuku, víèko palivové
nádrže a vzduchový filtr (je-li jím motor vybaven), a zda jsou dobøe zajištìny.
• Neotáèejte motorem pøi odstranìné svíèce.
• Pøi pøeplavení motoru nastavte sytiè (je-li k dispozici) do polohy OPEN/RUN
(chod) a škrtící klapku do polohy FAST (rychle) a protáèejte motor, dokud
nenaskoèí.
Pøi obsluze zaøízení
• Nenaklánìjte motor ani zaøízení do polohy, která by zpùsobila únik paliva.
• Motor se nesmí zastavovat zahlcením karburátoru.
• Nespouštìjte ani neprovozujte motor s odmontovanou sestavou vzduchového
filtru (je-li jím motor vybaven) nebo s vyjmutým vzduchovým filtrem (je-li jím
motor vybaven).
Pøi pøepravì zaøízení
• Zaøízení pøepravujte s PRÁZDNOU palivovou nádrží nebo zavøeným palivovým
kohoutem.
Pøi skladování paliva nebo zaøízení s palivem v nádrži
• Uložte oddìlenì od pecí, kamen, ohøívaèù vody èi jiných zaøízení, která mají
vìèný plamínek nebo od jiných zdrojù zapálení. Mohou zažehnout výpary z
paliva.
Spouštìní motoru je doprovázené jiskøením.
Jiskøení mùže zažehnout pøítomné hoølavé plyny.
Výsledkem mùže být požár nebo výbuch.
VAROVÁNÍ
• Nespouštìjte motor, uniká-li v prostoru zemní plyn nebo propan-butan (LPG).
• Nepoužívejte stlaèené startovací kapaliny, jejich páry jsou hoølavé.
Motory produkují oxid uhelnatý, což je bezbarvý jedovatý plyn bez
zápachu.
Vdechování oxidu uhelnatého mùže zpùsobit nevolnost, mdloby až
smrt.
VAROVÁNÍ
• Spouštìjte a provozujte motor venku.
• Nespouštìjte ani neprovozujte motor v uzavøeném prostoru, i když jsou
otevøená okna i dveøe.
Not for Reproduction
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
Simplicity 580447-0112-E2 Kasutusjuhend
- Kategooria
- Mootorsõidukite tarvikud
- Tüüp
- Kasutusjuhend
- See käsiraamat sobib ka
