Simplicity 543275-0111-E1 Kasutusjuhend
- Kategooria
- Mootorsõidukite tarvikud
- Tüüp
- Kasutusjuhend
See käsiraamat sobib ka
sl
Slovenija
sk
Slovenèina
en
English
bg ru
Ðóññêèé
cs hret hu
Èeština
lt lv pl ro
eesti keel Hrvatski Latviešu Polski
Românã
Áúëãàðñêè LietuviųMagyar
en
Operator’s Manual
bg
Èíñòðóêöèè çà åêñïëîàòàöèÿ
cs
Návod k obsluze
et
Kasutusjuhend
hr
Priruènik za operatora
hu
Kezelési útmutató
lt
Naudojimo instrukcija
lv
Operatora rokasgrāmata
pl
Instrukcja obs³ugi
ro
Manual de utilizare
ru
Ðóêîâîäñòâî ïî ýêñïëóàòàöèè
sk
Pokyny na obsluhu a údržbu
sl
Priroènik za uporabo
Form No. 279768EST
Revision: J
Model 610000
Vanguardt
Gaseous
Model 540000
Vanguardt
Gaseous
Copyright E Briggs & Stratton Corporation,
Milwaukee, WI, USA. All rights reserved.
Briggs & Stratton is a registered trademark
of Briggs & Stratton Corporation.
Not for
Reproduction
2
VanguardEngines.com
J
K
L
H
M
B
C
C
E
F
G
H
I
D
1
N
O
A
B
A
2
C
B
A
B
3
C
A
B
A
B
A
4
A
B
5
Not for
Reproduction
3
A
D
C
B
6
E
F
7
A
B
C
D
E
8
F
G
H
J
K
L
A
B
B
C
C
D
9
D
E
G
H
A
F
F
J
10
Not for
Reproduction
4 VanguardEngines.com
General Information
This manual contains safety information to make you aware of the hazards and risks
associated with engines and how to avoid them. It also contains instructions for the
proper use and care of the engine. Because Briggs & Stratton Corporation does not
necessarily know what equipment this engine will power, it is important that you read and
understand these instructions and the instructions for the equipment. Save these
original instructions for future reference.
For replacement parts or technical assistance, record below the engine model, type, and
code numbers along with the date of purchase. These numbers are located on your
engine (see the Features and Controls page).
Date of purchase:
Engine model:
MM/DD/YYYY
Model: Code:Type:
Operator Safety
Explosion
Toxic Fumes
Moving Parts
Shock
Hot Surface
Kickback
Fire
Fuel Shutoff
Read Manual
Choke
Oil
Fuel
On Off
Wear Eye
Protection
Slow
Fast
SAFETY AND CONTROL SYMBOLS
Hazardous
Chemical
Frostbite
Stop
The safety alert symbol is used to identify safety information about hazards that can
result in personal injury. A signal word (DANGER, WARNING, or CAUTION) is used with the
alert symbol to indicate the likelihood and the potential severity of injury . In addition, a hazard
symbol may be used to represent the type of hazard.
DANGER indicates a hazard which, if not avoided, will result in death or
serious injury.
WARNING indicates a hazard which, if not avoided, could result in death or
serious injury.
CAUTION indicates a hazard which, if not avoided, could result in minor or
moderate injury.
NOTICE indicates a situation that could result in damage to the product.
WARNING
Certain components in this product and its related accessories contain chemicals
known to t he State of California to cause cancer, birth defects, or other reproductive
harm. Wash hands after handling.
WARNING
The engine exhaust from this product contains chemicals k nown to the State of
California to c ause cancer, birth defects, or other reproductive harm.
WARNING
Briggs & Stratton Engines are not designed for and are not to be used to power:
fun-karts; go-karts; children’s, recreational, or sport all-terrain vehicles (ATVs);
motorbikes; hovercraft; aircraft products; or vehicles used in competitive events not
sanctioned by Briggs & Stratton. For information about competitive racing products,
see www.briggsracing.com. For use with utility and side-by-side ATVs, please
contact Briggs & Stratton Engine Application Center, 1-866-927-3349. Improper
engine application may result in serious injury or death.
NOTICE: This engine was shipped from Briggs & Stratton without oil. Before you start
the engine, make sure you add oil according to the instructions in this manual. If you
start the engine without oil, it will be damaged beyond repair and will not be covered
under warranty.
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
When Adding Fuel
Fill fuel tank outdoors or in well -ventilated area.
Check fuel lines, tank, cap, and fittings frequently for cracks or leaks.
Replace if necessary.
When Starting Engine
Ensure that spark plug, muffler, and air cleaner (if equipped) are in place and
secured.
Do not crank engine with spark plug removed.
When Operating Equipment
Never start or run the engine with the air cleaner assembly (if equipped) or the
air filter (if equipped) removed.
When Transporting Equipment
On Natural/Liquid Petroleum (LP) Gas engines, transport with fuel cylinder
empty or v alve closed, or fuel tank disconnected.
When Storing Fuel Or Equipment With Fuel In Tank
Store away from furnaces, stoves, water heaters or other appliances that have
pilot lights or other ignition sources because they can ignite fuel vapors.
Not for
Reproduction
5
en
Starting engine creates sparking.
Sparking can ignite nearby flammable gases.
Explosion and fire could result.
WARNING
If there is natural or LP gas leakage in area, do not start engine.
Do not use pressurized starting fluids because vapors are flammable.
POISONOUS GAS HAZARD. Engine exhaust contains carbon
monoxide, a poisonous gas that could kill you in minutes. You
CANNOT see it, smell it, or taste it. Even if you do not smell exhaust
fumes, you could still be exposed to carbon monoxide gas. If you start
to feel sick, dizzy, or weak while using this product, shut it off and get
to fresh air RIGHT AWAY. See a doctor. You may have carbon
monoxide poisoning.
WARNING
Operate this product ONLY outside far away from windows, doors and vents to
reduce the risk of carbon monoxide gas from accumulating and potentially being
drawn towards occupied spaces.
Install battery--operated carbon monoxide alarms or plug--in carbon monoxide
alarms with battery back-up according to the manufacturer’s instructions.
Smoke alarms cannot detect carbon monoxide gas.
DO NOT run this product inside homes, garages, basements, crawlspaces,
sheds, or other partially-enclosed s paces even if using fans or opening doors
and windows for ventilation. Carbon monoxide can quickly build up in these
spaces and can linger for hours, even after this product has shut off.
ALWAYS place this product downwind and point the engine exhaust away from
occupied spaces.
Rapid r etraction of starter cord (kickback) will pull hand and arm
toward engine faster than you can let go.
Broken bones, fractures, bruises or sprains could result.
WARNING
When starting engine, pull the starter cord slowly until resistance is felt and then
pull rapidly to avoid kickback.
Remove all external equipment/engine loads before starting engine.
Direct-coupled equipment components such as, but not limited to, blades,
impellers, pulleys, sprockets, etc., must be securely attached.
WARNING
Missing or inoperative “fuel lock-off” valve can cause a fire or
explosion.
Do not operate the equipment if the “fuel lock-off” valve is missing or inoperative.
Rotating parts can contact or entangle hands, feet, hair, clothing, or
accessories.
Traumatic amputation or severe laceration can result.
WARNING
Operate equipment with guards in place.
Keep hands and feet away from rotating parts.
Tie up long hair and remove jewelry.
Do not wear loose-fitting clothing, dangling drawstrings or items that could
become caught.
Running engines produce heat. Engine parts, especially muffler,
become extremely hot.
Severe thermal burns can occur on contact.
Combustible debris, such as leaves, grass, brush, etc. can catch fire.
WARNING
Allow muffler, engine cylinder and fins to cool before touching.
Remove accumulated debris from muffler area and cylinder area.
It is a v iolation of California Public Resource Code, Section 4442, to use or
operate the engine on any forest-covered, brush-covered, or grass-covered land
unless the exhaust system is equipped with a spark arrester, as defined in
Section 4442, maintained in effective working order. Other states or federal
jurisdictions may have similar laws. Contact the original equipment
manufacturer, retailer, or dealer to obtain a spark arrester designed for the
exhaust system installed on this engine.
Unintentional sparking can result in fire or electric shock.
Unintentional start-up can result in entanglement, traumatic
amputation, or laceration.
Fire hazard
WARNING
Before performing adjustments or repairs:
Disconnect the spark plug wire and keep it away from the spark plug.
Disconnect battery at negative terminal (only engines with electric start.)
Use only c orrect tools.
Do not tamper with governor spring, links or other parts to increase engine
speed.
Replacement parts must be of the same design and installed in the same
position as the original parts. Other parts may not perform as well, may damage
the unit, and may result in injury.
Do not strike the flywheel with a hammer or hard object because the flywheel
may later shatter during operation.
When testing for spark:
Use approved spark plug tester.
Do not check for spark with s park plug removed.
WARNING
Gaseous fuels are extremely flammable and readily form explosive
air-vapor mixtures at ambient temperatures.
If you smell gas,
Do not start the engine.
Do not actuate any electrical switches.
Do not use a phone in the v icinity.
Evacuate the area.
Contact the gas supplier or fire department.
Installation, adjustment and repair work should be done by a qualified
technician.
Regularly check flexible supply line. Make sure they are in good condition.
Replace damaged or leaking components.
WARNING
Wear eye protection when doing repair work.
Frostbite can result from skin/eye contact with leaking LP liquid.
Not for
Reproduction
6 VanguardEngines.com
Features and Controls
Compare the illustration
1
with your engine to familiarize yourself with the location of
various features and controls.
A. Engine Identification
Model Type Code
B. Spark Plug
C. Air Cleaner, Cyclonic
D. Air Cleaner, Low Profile
E. Dipstick
F. Oil Fill
G. Oil Filter
H. Oil Drain Plug
I. Oil Pressure Sensor
J. Finger Guard / Rotating Screen
K. Electric Starter
L. Starter Solenoid
M. Regulator/Rectifier
N. LPG/NG Mixer
O. Oil Cooler
Operation
Oil capacity (see the Specifications section)
Oil Recommendations
We recommend the use of Briggs & Stratton Warranty Certified oils for best
performance. Other high-quality detergent oils are acceptable if classified for service SF,
SG, SH, SJ or higher. Do not use special additives.
Outdoor temperatures determine the proper oil viscosity for the engine. Use the chart t o
select the best viscosity for the outdoor temperature range expected.
SAE 30
10W-30
Synthetic 5W-30
5W-30
°F °C
* Below 40°F(4°C) the use of SAE 30 will result in hard starting.
** Above 80°F(27°C) the use of 10W-30 may cause increased oil consumption. Check
oil level more frequently.
How To Check/Add Oil - Figure
2
Before adding or checking the oil
Place engine level.
Clean the oil fill area of any debris.
1. Remove the dipstick (A) and wipe with a clean cloth (Figure 2).
2. Insert and tighten the dipstick.
3. Remove the dipstick and check the oil level. It should be at the top of the full indicator
(B) on the dipstick.
4. If low, add oil slowly into the engine oil fill (C). Do not overfill. After adding oil, wait
one minute and then recheck the oil level.
5. Replace and tighten the dipstick.
Low Oil Protection System (if equipped)
Some engines are equipped with a low oil sensor. If the oil is low, the sensor will either
activate a warning light or stop the engine. Stop the engine and follow these steps before
restarting the engine.
Make sure the engine is level.
Check the oil level. See the How To Check/Add Oil section.
If the oil level is low, add the proper amount of oil. Start the engine and make sure
the warning light (if equipped) is not activated.
If the oil level is not low, do not start the engine. Contact an Authorized Briggs &
Stratton Dealer to have the the oil problem corrected.
Fuel Recommendations
WARNING
Missing or inoperative “fuel lock-off” valve can cause a fire or
explosion.
Do not operate the equipment if the “fuel lock-off” valve is missing or inoperative.
Fuel must meet these requirements:
Use clean, dry fuel, free of moisture or any particulate material. Using fuels outside
the following recommended values may cause performance problems.
In engines set up to run on LPG, commercial grade HD5 LPG is r ecommended.
Recommended fuel composition is fuel with a minimum fuel energy of 2500 BTU’s/ft
3
with maximum propylene content of 5% and butane and heavier gas content of 2.5%
and minimum propane content of 90%.
NG or LPG engines are certified to operate on natural or liquid propane gas. The
emissions control system for this engine is EM (Engine Modifications).
WARNING: The equipment on which this engine is mounted is equipped
with an automatic safety gas “fuel lock-off” valve. Do not operate the equipment if the
“fuel lock-off” valve is missing or inoperative.
How To Add Fuel
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
When Adding Fuel
Fill fuel tank outdoors or in well -ventilated area.
Check fuel lines, tank, cap, and fittings frequently for cracks or leaks.
Replace if necessary.
For information on refueling natural or LP gas engines, read the operating instructions
supplied by the equipment manufacturer.
How To Start The Engine - Figure
3
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
When Starting Engine
Ensure that spark plug, muffler, and air cleaner (if equipped) are in place and
secured.
Do not crank engine with spark plug removed.
Not for
Reproduction
7
en
POISONOUS GAS HAZARD. Engine exhaust contains carbon
monoxide, a poisonous gas that could kill you in minutes. You
CANNOT see it, smell it, or taste it. Even if you do not smell exhaust
fumes, you could still be exposed to carbon monoxide gas. If you start
to feel sick, dizzy, or weak while using this product, shut it off and get
to fresh air RIGHT AWAY. See a doctor. You may have carbon
monoxide poisoning.
WARNING
Operate this product ONLY outside far away from windows, doors and vents to
reduce the risk of carbon monoxide gas from accumulating and potentially being
drawn towards occupied spaces.
Install battery--operated carbon monoxide alarms or plug--in carbon monoxide
alarms with battery back-up according to the manufacturer’s instructions.
Smoke alarms cannot detect carbon monoxide gas.
DO NOT run this product inside homes, garages, basements, crawlspaces,
sheds, or other partially-enclosed s paces even if using fans or opening doors
and windows for ventilation. Carbon monoxide can quickly build up in these
spaces and can linger for hours, even after this product has shut off.
ALWAYS place this product downwind and point the engine exhaust away from
occupied spaces.
NOTICE: This engine was shipped from Briggs & Stratton without oil. Before you start
the engine, make sure you add oil according to the instructions in this manual. If you
start the engine without oil, it will be damaged beyond repair and will not be covered
under warranty.
Note: Some engines and equipment have remote controls. See the equipment manual
for location and operation of remote controls.
1. Check the oil level. See the How To Check/Add Oil section.
2. Make sure equipment drive controls, if equipped, are disengaged.
3. Turn the fuel shut-off valve (A), if equipped, to the on position (Figure 3).
4. Move the throttle control (B)tothefast
position. Operate the engine in the fast
position.
5. Turn the electric start switch (C) to the on/start position (Figure 3).
NOTE: If the engine does not start after repeated attempts, contact your local dealer
or go to VanguardEngines.com or call 1-800-999-9333 (in USA).
NOTICE: To extend the life of the starter, use short starting cycles (five seconds
maximum). Wait one minute between starting cycles.
How To Stop The Engine - Figure
3
1. Move the throttle control to the slow position, turn the key switch (C) to the off
position (Figure 3). Remove the key and keep in a safe place out of the reach of
children.
2. After the engine stops, turn t he fuel shut-off valve (A), if equipped, to the closed
position.
Maintenance
We recommend that you see any Briggs & Stratton Authorized Dealer for all
maintenance and service of the engine and engine parts.
NOTICE: All the components used to build this engine must remain in place for proper
operation.
Emissions Control
Maintenance, replacement, or repair of the emissions control devices and systems
may be performed by any off-road engine repair establishment or individual.
However, to obtain “no charge” emissions control service, the work must be performed
by a factory authorized dealer. See the Emissions Warranty.
Unintentional sparking can result in fire or electric shock.
Unintentional start-up can result in entanglement, traumatic
amputation, or laceration.
Fire hazard
WARNING
Before performing adjustments or repairs:
Disconnect the spark plug wire and keep it away from the spark plug.
Disconnect battery at negative terminal (only engines with electric start.)
Use only c orrect tools.
Do not tamper with governor spring, links or other parts to increase engine
speed.
Replacement parts must be of the same design and installed in the same
position as the original parts. Other parts may not perform as well, may damage
the unit, and may result in injury.
Do not strike the flywheel with a hammer or hard object because the flywheel
may later shatter during operation.
When testing for spark:
Use approved spark plug tester.
Do not check for spark with s park plug removed.
Maintenance Chart
Every8HoursorDaily
Check engine oil level
Clean area around muffler and controls
Every 100 Hours or Annually
Clean or change air filter *
Y
Change engine oil and filter
Replace spark plug
Check muffler and spark arrester
Check valve clearance. Adjust if necessary.
Every 400 Hours or Annually
Change air f ilter
Y
Clean air cooling system *
Clean oil c ooler fins *
Every 600 Hours or Annually
Change safety filter (if equipped)
* In dusty conditions or when airborne debris is present, clean more often.
Y
Every third air filter change, replace the inner safety filter (if equipped).
NOTICE: The manufacturer of the equipment on which this engine is installed specifies
the top speed at which the engine will be operated. Do not exceed this speed.
How To Replace The Spark Plug - Figure
4
Check the gap (A, Figure 4) with a wire gauge (B). If necessary, reset the gap. Install
and tighten the spark plug to the recommended torque. For gap setting or torque, see the
Specifications section.
Note: In some areas, local law requires using a resistor spark plug to suppress ignition
signals. If this engine was originally equipped with a resistor spark plug, use the same
type for replacement.
Not for
Reproduction
8
VanguardEngines.com
Inspect Muffler And Spark Arrester - Figure
5
Running engines produce heat. Engine parts, especially muffler,
become extremely hot.
Severe thermal burns can occur on contact.
Combustible debris, such as leaves, grass, brush, etc. can catch fire.
WARNING
Allow muffler, engine cylinder and fins to cool before touching.
Remove accumulated debris from muffler area and cylinder area.
It is a v iolation of California Public Resource Code, Section 4442, to use or
operate the engine on any forest-covered, brush-covered, or grass-covered land
unless the exhaust system is equipped with a spark arrester, as defined in
Section 4442, maintained in effective working order. Other states or federal
jurisdictions may have similar laws. Contact the original equipment
manufacturer, retailer, or dealer to obtain a spark arrester designed for the
exhaust system installed on this engine.
Remove accumulated debris from muffler area and cylinder area. Inspect the muffler (A,
Figure 5) for cracks, corrosion, or other damage. Remove the spark arrester (B), if
equipped, and inspect for damage or carbon blockage. If damage is found, install
replacement parts before operating.
WARNING: Replacement parts must be of the same design and installed
in the same position as the original parts. Other parts may not perform as well, may
damage the unit, and may result in injury.
How To Change The Oil - Figure
6
Used oil is a hazardous waste product and must be disposed of properly. Do not discard
with household waste. Check with your local authorities, service center, or dealer for safe
disposal/recycling facilities.
Remove Oil
1. With engine off but still warm, disconnect the spark plug wire (A) and keep it away
from the spark plug (Figure 6).
2. Remove the oil drain plug (B). Drain the oil into an approved container.
3. After the oil has drained, install and tighten the oil drain plug.
Change The Oil Filter
All models are equipped with an oil filter. For replacement intervals, see the
Maintenance chart.
1. Drain the oil from the engine. See Remove Oil section.
2. Remove the oil filter (C, Figure 6) and dispose of properly.
3. Before installing the new oil filter, lightly lubricate t he oil filter gasket with fresh, clean
oil.
4. Install the oil filter by hand until the gasket contacts the oil filter adapter, then tighten
theoilfilter1/2to3/4turns.
5. Add oil. See Add Oil section.
6. Start and run the engine. As the engine warms up, check for oil leaks.
7. Stop the engine and check the oil level. It should be at the top of the full indicator (F)
on the dipstick.
Add Oil
Place engine level.
Clean the oil fill area of any debris.
See the Specifications section for oil capacity.
1. Remove the dipstick (D, Figure 6) and wipe with a clean cloth.
2. Pour the oil slowly into the engine oil fill (E). Do not overfill. After adding oil, wait
one minute and then check the oil level.
3. Install and tighten the dipstick.
4. Remove the dipstick and check the oil level. It should be at the top of the full indicator
(F) on the dipstick.
5. Install and tighten the dipstick.
How To Service The Air Filter - Figure
7 8
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
Never start or run the engine with the air cleaner assembly (if equipped) or the
air filter (if equipped) removed.
NOTICE: Do not use pressurized air or solvents to clean the filter. Pressurized air can
damage the filter and solvents will dissolve the filter.
The air filter system uses either a cyclonic air filter or a low-profile air filter. See the
Maintenance Chart for service requirements.
Cyclonic Air Filter System
1. Open the latches (A) and remove the cover (B).SeeFigure7.
2. Remove the air filter (C).
3. To loosen debris, gently tap the air filter on a hard surface. If the air filter is
excessively dirty, replace with a new air filter.
4. The cyclonic air filter system also has a safety filter (D) (if equipped). See the
Maintenance Chart for service requirements. To remove, carefully pull the safety
filter away from air cleaner body (E) and discard. Make sure that dirt or debris do not
enter the engine.
5. Install the new safety filter in the air cleaner body.
6. Install the air filter over the safety filter.
7. Install the cover and close the latches.
Low-Profile Air Filter System
1. Remove the knob (F) and the cover (G).SeeFigure8.
2. Remove the nut (H) and the retainer (J).
3. Remove the air filter (K).
4. Remove the pre-cleaner (L), if equipped, from the air filter.
5. To loosen debris, gently tap the air filter on a hard surface. If the air filter is
excessively dirty, replace with a new air filter.
6. Wash the pre-cleaner in liquid detergent and water. Then allow it to thoroughly air
dry. Do not oil the pre-cleaner.
7. Assemble the dry pre-cleaner to the air filter.
8. Install the air filter and secure with retainer and nut.
9. Install the cover and secure with knob.
How To Clean The Air Cooling System - Figure
9 10
Running engines produce heat. Engine parts, especially muffler,
become extremely hot.
Severe thermal burns can occur on contact.
Combustible debris, such as leaves, grass, brush, etc. can catch fire.
WARNING
Allow muffler, engine cylinder and fins to cool before touching.
Remove accumulated debris from muffler area and cylinder area.
NOTICE: Do not use water to clean the engine. Water could contaminate the fuel
system. Use a brush or dry cloth to clean the engine.
This is an air cooled engine. Dirt or debris can restrict air flow and cause the engine to
overheat, resulting in poor performance and reduced engine life.
Use a brush or dry cloth to remove debris from the finger guard/rotating screen (A,
Figure 9). Keep linkage, springs and controls (B) clean. Keep the area around and
behind the muffler (C) free of any combustible debris. Make sure that the oil cooler fins
(D) are free of dirt and debris.
Clean the area under the panel (E, Figure 10). Loosen the two screws (F) until you hear
a click. Remove the panel and clean the area of dirt and debris. Make sure the underside
of the panel is also clean. Install the panel and tighten the screws until you hear a click.
Note: To remove the panel on engines equipped with the Cyclonic Air Filter System (G,
Figure 10), loosen the fastener (H) and pivot the Cyclonic Air Filter away from the
engine. It is not necessary to remove the flexible air cleaner hose (J). After cleaning,
make sure to reposition the air filter and tighten the fastener.
Storage
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
When Storing Fuel Or Equipment With Fuel In Tank
Store away from furnaces, stoves, water heaters or other appliances that have
pilot lights or other ignition sources because they can ignite fuel vapors.
Engine Oil
While the engine is still warm, change the engine oil.
Troubleshooting
Need Assistance? Go to VanguardEngines.com or call 1-800-999-9333 (in USA).
Not for
Reproduction
9
en
Specifications
Engine Specifications
Model 540000
Displacement 54.68 ci (896 cc)
Bore 3.366 in (85.5 mm)
Stroke 3.071 in (78.0 mm)
Oil Capacity 78 -- 80 oz (2.3 -- 2.4 L)
Engine Specifications
Model 610000
Displacement 60.60 ci (993 cc)
Bore 3.366 in (85.5 mm)
Stroke 3.406 in (77.21 mm)
Oil Capacity 78 -- 80 oz (2.3 -- 2.4 L)
Tune-up Specifications *
Model 540000
Spark Plug Gap 0.020 in (0.51 mm)
Spark Plug Torque 180 lb-in (20 Nm)
Armature Air Gap 0.005 - 0.008 in (0.13 - 0.20 mm)
Intake Valve Clearance 0.004 - 0.006 in (0.10 - 0.15 mm)
Exhaust Valve Clearance 0.007 - 0.009 in (0.18 - 0.23 mm)
Tune-up Specifications *
Model 610000
Spark Plug Gap 0.020 in (0.51 mm)
Spark Plug Torque 180 lb-in (20 Nm)
Armature Air Gap 0.005 - 0.008 in (0.13 - 0.20 mm)
Intake Valve Clearance 0.004 - 0.006 in (0.10 - 0.15 mm)
Exhaust Valve Clearance 0.007 - 0.009 in (0.18 - 0.23 mm)
* Engine power will decrease 3.5% for each 1,000 feet (300 meters) above sea level and 1% for each 10 F(5.6 C) above 77 F(25 C). The engine will operate satisfactorily at an
angle up to 15. Refer to the equipment operator’s manual for safe allowable operating limits on slopes.
Common Service Parts n
Service Part Part Number
Air Filter, Cyclonic 841497
Safety Filter, Cyclonic 821136
Air Filter, Low-Profile 692519
Pre-Cleaner, Low-Profile 692520
Oil -- SAE 30 100028
Oil Filter 842921
Service Part Part Number
Resistor Spark Plug 491055
Long Life Platinum Spark Plug 5066
Spark Plug Wrench 19374
Spark Tester 19368
n We recommend that you see any Briggs & Stratton Authorized Dealer for all maintenance and service of the engine and engine parts.
Not for
Reproduction
10 VanguardEngines.com
BRIGGS & STRATTON ENGINE WARRANTY POLICY
January 2014
Briggs & Stratton warrants that, during the warranty period specified below, it will repair or replace, free of charge, any part that is defective in material or workmanship or
both. Transportation charges on product submitted for repair or replacement under this warranty must be borne by purchaser. This warranty is effective for and is subject to
the time periods and conditions stated below. For warranty s ervice, find the nearest Authorized Service Dealer in our dealer locator map at BRIGGSandSTRATTON.COM.
The purchaser must contact the Authorized Service Dealer, and then make the product available to the Authorized Service Dealer for inspection and testing.
There is no other express warranty. Implied warranties, including those of merchantability and fitness for a particular purpose, are limited to the warranty period
listed below, or to the extent permitted by l aw. Liability for incidental or consequential damages are excluded to the extent exclusion is permitted bylaw.Some
states or countries do not allow limitations on how long an implied warranty lasts, and some states or countries do not allow the exclusion or limitation of incidental or
consequential damages, so the above limitation and exclusion may not apply to you. This warranty gives you specific legal rights and you may also have other rights which
vary from state to state and country to country. **
LIMITED WARRANTY
STANDARD WARRANTY TERMS *
Y
Brand/Product Type Consumer Use Commercial Use
Vanguardt
J
3 years 3 years
Commercial Turf Seriest
2 years 2 years
Engines Featuring Dura-Boret Cast Iron Sleeve
2 years 1 year
All Other Briggs & Stratton Engines 2 years 90 days
* These are our standard warranty terms, but occasionally there may be additional warranty coverage that was not determined at time of publication. For a listing of current
warranty terms for your engine, go to BRIGGSandSTRATTON.COM or contact your Briggs & Stratton Authorized Service Dealer.
** In Australia -- Our goods come with guarantees that cannot be excluded under the Australian Consumer Law. You are entitled to a replacement or refund foramajor
failure and for compensation for any other reasonably foreseeable loss or damage. You are also entitled to have the goods repaired or replaced if the goods fail to be of
acceptable quality and the failure does not amount to a major failure. For warranty service, find the nearest Authorized Service Dealer in our dealer locator map at
BRIGGSandSTRATTON.COM, or by calling 1300 274 447, or by emailing or writing to salesenquiries@briggsandstratton.com.au, Briggs & Stratton AustraliaPtyLtd,1
Moorebank Avenue, Moorebank, NSW , Australia, 2170.
Y
There is no warranty for engines on equipment used for prime power in place of a utility or for standby generators used for commercial purposes. Engines used in
competitive racing or on commercial or rental tracks are not warranted.
J
Vanguard installed on standby generators: 2 years consumer use, no warranty commercial use. Vanguard installed on utility vehicles: 2 years consumer use, 2 years
commercial use. Vanguard 3-cylinder liquid cooled: see Briggs & Stratton 3/LC Engine Warranty Policy.
The warranty period begins on the date of purchase by the first retail or c ommercial consumer. “Consumer use” means personal residential household use by a retail consumer.
“Commercial use” means all other uses, including use for commercial, income producing or rental purposes. Once an engine has experienced commercial use, it shall thereafter be
considered as a commercial use engine for purposes of this warranty.
Save your proof of purchase receipt. If you do not provide proof of the initial purchase date at the time warranty service is requested, the manufacturing date of the
product will be used to determine the warranty period. Product registration is not required to obtain warranty service on Briggs & Stratton products.
About Your Warranty
This limited warranty covers engine-related material and/or workmanship issues only,
and not replacement or refund of the equipment to which the engine may be mounted.
Routine maintenance, tune-ups, adjustments, or normal wear and tear are not covered
under this warranty. Similarly, warranty is not applicable if the engine has been altered or
modified or if the engine serial number has been defaced or removed. This warranty
does not include used, reconditioned, second-hand, or demonstration equipment or
engines. This warranty does not cover engine damage or performance problems caused
by:
1 The use of parts that are not original Briggs & Stratton parts;
2 Operating the engine with insufficient, contaminated, or an incorrect grade of
lubricating oil;
3 The use of contaminated or stale fuel, gasoline formulated with ethanol greater than
10%, or t he use of alternative fuels such as liquefied petroleum or natural gas on
engines not originally designed/manufactured by Briggs & Stratton to operate on
such fuels;
4 Dirt which entered the engine because of improper air cleaner maintenance or
re--assembly;
5 Striking an object with the cutter blade of a rotary lawn mower, loose or improperly
installed blade adapters, impellers, or other crankshaft coupled devices, or
excessive v-belt tightness;
6 Associated parts or assemblies such as clutches, transmissions, equipment
controls, etc., which are not supplied by Briggs & Stratton;
7 Overheating due to grass clippings, dirt and debris, or rodent nests which plug or
clog the cooling fins or flywheel area, or by operating the engine without sufficient
ventilation;
8 Excessive vibration due to over-speeding, loose engine mounting, loose or
unbalanced cutter blades or impellers, or improper coupling of equipment
components to the crankshaft;
9 Misuse, lack of routine maintenance, shipping, handling, or warehousing of
equipment, or improper engine installation.
W arranty service is available only through Briggs & Stratton Authorized Service
Dealers. Locate your nearest Authorized Service Dealer in our dealer locator map at
BRIGGSandSTRATTON.COM or by calling 1-800-233-3723 (in USA).
Not for
Reproduction
11
en
U.S. EPA and Briggs & Stratton Corporation Emissions Control Warranty Statement
Your Warranty Rights And Obligations
For Briggs & Stratton Engine Models with ”J” Trim Designation
(Model--Type--Trim Representation xxxxxx xxxx Jx)
The U.S. EPA and Briggs & Stratton (B&S) are pleased to explain the emissions control
system warranty on your Model Year 2015--2017 engine. In the U.S, new small off-road
engines and large spark ignited engines less than or equal to 1.0 liter must be designed,
built, and equipped to meet stringent anti-smog standards. B&S must warrant the
emissions control system on your engine for the periods of time listed below provided
there has been no abuse, neglect, or improper maintenance of your engine.
Your exhaust emissions control system may include parts such as the carburetor or fuel
injection system, ignition system, and catalytic converter. Also included may be hoses,
belts, connectors, sensors, and other emissions-related assemblies.
Where a warrantable condition exists, B&S will repair your engine at no cost to you
including diagnosis, parts, and labor.
Manufacturer’s Warranty Coverage:
Small off-road engines and large s park ignited engines less than or equal to 1.0 liter, are
warranted for two years, or for the time time period listed in the respective engine or
product warranty statement, whichever is greater. If any emissions -related part on your
B&S engine is defective, the part will be repaired or replaced by B&S.
Owner’s Warranty Responsibilities:
As the engine owner, you are responsible for the performance of the required
maintenance listed in your Operator’s Manual. B&S recommends that you retain all
receipts covering maintenance on your engine, but B&S cannot deny warranty solely
for the lack of receipts or your failure to ensure the performance of all scheduled
maintenance.
As the engine owner, you should however be aware that B&S may deny you
warranty coverage if your engine or a part has failed due to abuse, neglect, improper
maintenance, or unapproved modifications.
You are responsible for presenting your engine to a B&S distribution center, servicing
dealer, or other equivalent entity, as applicable, as soon as a problem exists. The
warranty repairs should be completed in a reasonable amount of time, not to exceed
30 days. If you have any questions regarding your warranty rights and
responsibilities, you should contact B&S at 1--800--444--7774 (in USA) or
BRIGGSandSTRATTON.COM.
Briggs & Stratton Emissions Control Warranty Provisions
The following are specific provisions relative to your Emissions Control Warranty
Coverage. It is in addition to the B&S engine warranty for non-regulated engines found in
the Operator’s Manual.
1. Warranted Emissions Parts
Coverage under this warranty extends only to the parts listed below (the emissions
control systems parts) to the extent these parts were present on the B&S engine.
a. Fuel Metering System
Cold start enrichment system (soft choke)
Carburetor or fuel injection system
Oxygen sensor
Electronic control unit
Fuel pump module
b. Air Induction System
Air cleaner
Intake manifold
c. Ignition System
Spark plug(s)
Magneto ignition system
d. Catalyst System
Catalytic converter
Exhaust manifold
Air injection system or pulse valve
e. Miscellaneous Items Used in Above Systems
Vacuum, temperature, position, time sensitive valves and switches
Connectors and assemblies
2. Length of Coverage
Coverage is for a period of two years from date of original purchase, or for the time
period listed in the respective engine or product warranty statement, whichever is
greater. B&S warrants to the original purchaser and each subsequent purchaser that
the engine is designed, built, and equipped so as to conform with all applicable
regulations adopted under Section 213 of the Clean Air Act; that it is free from
defects in material and workmanship that could cause the failure of a warranted part;
and that it is identical in all material respects to the engine described in the
manufacturer’s application for certification. The warranty period begins on the date
the engine is originally purchased.
The warranty on emissions-related parts is as follows:
Any warranted part that is not scheduled for replacement as required
maintenance in the Operator’s Manual supplied, is warranted for the warranty
period stated above. If any such part fails during the period of warranty
coverage, the part will be repaired or replaced by B&S at no charge to the
owner. Any such part repaired or replaced under the warranty will be warranted
for the remaining warranty period.
Any warranted part that is scheduled only for regular inspection in the
Operator’s Manual supplied, is warranted for the warranty period stated above.
Any such part repaired or replaced under warranty will be warranted for the
remaining warranty period.
Any warranted part that is scheduled for replacement as required maintenance
in the Operator’s Manual supplied, is warranted for the period of time prior to
the first scheduled replacement point for that part. If the part fails prior to the
first scheduled replacement, the part will be repaired or replaced by B&S at no
charge to the owner. Any such part repaired or replaced under warranty will be
warranted for the remainder of the period prior to the first scheduled
replacement point for the part.
Add-on or modified parts that are not exempted by the U.S. EPA may not be
used. The use of any non-exempted add-on or modified parts by the owner will
be grounds for disallowing a warranty claim. The manufacturer will not be liable
to warrant failures of warranted parts caused by the use of a non-exempted
add-on or modified part.
3. Consequential Coverage
Coverage shall extend to the failure of any engine components caused by the
failure of any warranted emissions parts.
4. Claims and Coverage Exclusions
Warranty claims shall be filed according to the provisions of the B&S engine
warranty policy. Warranty coverage does not apply to failures of emissions parts
that are not original equipment B&S parts or to parts that fail due to abuse, neglect,
or improper maintenance as s et forth in the B&S engine warranty policy. B&S is not
liable for warranty coverage of failures of emissions parts caused by the use of
add-on or modified parts.
Look For Relevant Emissions Durability Period and Air I ndex Information
On Your Small Off-Road Engine Emissions Label
Briggs & Stratton engines are certified to meet the United States Environmental
Protection Agency (USEPA) Phase 3 emissions standards. The Emissions Compliance
Period referred to on the Emissions Compliance label indicates the number of operating
hours for which the engine has been shown to meet Federal emissions requirements.
For engines at or less than 80 cc displacement:
Category C = 50 hours, Category B = 125 hours, Category A = 300 hours
For engines greater than 80 cc displacement and less than 225 cc displacement:
Category C = 125 hours, Category B = 250 hours, Category A = 500 hours
For engines of 225 cc or more displacement:
Category C = 250 hours, Category B = 500 hours, Category A = 1000 hours
80012791 (Rev A)
Not for
Reproduction
12 VanguardEngines.com
Îáùà èíôîðìàöèÿ
‚îâà ˜úêîâîäñòâî ñúäú˜¥à ñâåäåíè çà áåçîïàñíà ˜àáîòà, çà äà ñòå íàñíî ñ
àâà˜èèòå è îïàñíîñòèòå, ñâú˜çàíè ñ òåçè äâèãàòåëè è êàê äà ãè èçáãâàòå. ‚î
ñúäú˜¥à è èíñò˜óêöèè çà ï˜àâèëíàòà èì óïîò˜åáà è ïîää˜ú¥êà. ‚úé êàòî â
ÿî˜ïî˜àöè Briggs & Stratton íå áèõà ìîãëè äà çíàò êàêâà ìàμèíà ùå ñå
çàäâè¥âà ñ òîçè äâèãàòåë, âà¥íî å äà ï˜î…åòåòå è ˜àçáå˜åòå òåçè èíñò˜óêöèè u
èíñò˜óêöèèòå çà çàäâè¥âàíàòà ìàμèíà. Çàïèøåòå òåçè îðèãèíàëíè èíñòðóêöèè
çà áúäåùè ñïðàâêè.
Çà ˜åçå˜âíè …àñòè èëè òåõíè…åñêà ïîìîù çàïèμåòå îòäîëó ìîäåëà íà äâèãàòåë,
òèïà è êîäîâèòå íîìå˜à ñ äàòàòà íà êóïóâàíåòî ìó. ‚åçè íîìå˜à ñå íàìè˜àò âú˜õó
äâèãàòåë âè. (íàï˜àâåòå ñï˜àâêà íà ñò˜àíèöàòà ñ ˜àçäåë Åëåìåíòè è
Óïðàâëåíèÿ).
Äàòà íà êóïóâàíå:
Ìîäåë íà äâèãàòåëÿ:
MM/ÄÄ/øøøø
flîäåë: ÿîä:‚èï:
Òåõíèêà çà áåçîïàñíîñò íà îïåðàòîðà
Âçðèâîîïàñíî
Îòðîâíè
ãàçîâå
Äâèæåùè
ñå ÷àñòè
Îïàñíîñò çà ïîðàæåíèÿ
îò åëåêòðè÷åñêè ò îê
Ãîðåùà
ïîâúðõíîñò
Îáðàòåí
óäàð
Îãíåîïàñíî
Ïðåêðàòÿâàíå
ïîäàâàíåòî íà ãîðèâî
Ïðî÷åòåòå
Ðúêîâîäñòâîòî
Ñìóêà÷
Ìàñëî
Ãîðèâî
Âêë. Èçêë.
Äà ñå íîñÿò
ïðåäïàçíè î÷èëà
Áúðçè
îáîðîòè
Áàâíè
îáîðîòè
ÑÈÌÂÎËÈ ÇÀ ÁÅÇÎÏÀÑÍÎÑÒ È ÓÏÐÀÂËÅÍÈÅ
Îïàñíè
õèìèêàëè
Îïàñíîñò îò
èçìðúçâàíå
Ñòîï
fi˜åäóï˜åäèòåëíèò ñèìâîë çà îïàñíîñò îï˜åäåë ï˜åäîõ˜àíèòåëíà
èíôî˜ìàöè çà ˜èñêîâå, êîèòî ìîãàò äà äîâåäàò äî íà˜àíâàíå íà ïå˜ñîíàëà.
Ñèãíàëèçè˜àùà äóìà (›fiæÑ‹›, fiˆÅćfiˆÅ≠ÄÅ‹¤Å èëè ◊‹¤fl拤Å) ñå ïîñòàâ
çàåäíî ñ ï˜åäóï˜åäèòåëåí ñèìâîë, çà äà ïîñî…è âå˜îòíîñòòà è ïîòåíöèàëíàòà
ñå˜èîçíîñò íà íà˜àíâàíåòî. Äîïúëíèòåëíî, åäèí ñèìâîë çà îïàñíîñò ìî¥å äà
ïîêàçâà âèäà íà îïàñíîñòòà.
ÎÏÀÑÍÎ ïîñî…âà îïàñíîñò, êîòî, àêî íå áúäå èçáåãíàòà, ùå äîâåäå
äî ñìúðò èëè ñåðèîçíî íàðàíÿâàíå.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ ïîñî…âà îïàñíîñò, êîòî, àêî íå áúäå
èçáåãíàòà, ìîæå äà äîâåäå äî ñìúðò èëè ñåðèîçíî íàðàíÿâàíå.
ÂÍÈÌÀÍÈÅ ïîñî…âà îïàñíîñò, êîòî, àêî íå áúäå èçáåãíàòà, ìîæå äà
äîâåäå äî ìàëêà èëè ñðåäíà ñòåïåí íà íàðàíÿâàíå.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ ïîñî…âà ñèòóàöè,êîòî áèìîãëàäàäîâåäå
äî ïîâðåæäàíå íà ïðîäóêòà.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
‹êîè îò ñúñòàâíèòå åëåìåíòè íà òîçè ï˜îäóêò è ñâú˜çàíèòå ñ òõ
ï˜èñïîñîáëåíè ñúäú˜¥àò õèìè…íè âåùåñòâà, èçâåñòíè â ùàòà ÿàëèôî˜íè
êàòî ï˜è…èíèòåëè íà ˜àê, óâ˜åäà íà íîâî˜îäåíèòå èëè ä˜óãè óâ˜åäè íà
˜åï˜îäóêòèâíàòà ñïîñîáíîñò. Ñëåä ˜àáîòà ñ òõ, èçìèâàéòå ˜úöåòå ñè.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
¤çãî˜åëèòå ãàçîâå îò òîçè äâèãàòåë ñúäú˜¥àò õèìè…åñêè ñúåäèíåíè,
èçâåñòíè íà ùàòà ÿàëèôî˜íè êàòî ï˜è…èíèòåëè íà ˜àê, óâ˜å¥äàíè ï˜è
˜à¥äàíå, èëè ä˜óãè óâ˜å¥äàíè, ñâú˜çàíè ñ ˜åï˜îäóêòèâíîñòòà.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Äâèãàòåëèòå Briggs & Stratton íå ñà ï˜îåêòè˜àíè è íå ñà ï˜åäíàçíà…åíè çà
çàäâè¥âàíå íà óâåñåëèòåëíè êà˜òîâå, ñúñòåçàòåëíè êà˜òîâå, äåòñêè
àâòîìîáèëè, êîëè çà çàáàâëåíè, âñúäåõîäíè ñúñòåçàòåëíè àâòîìîáèëè
(ATV), ìîòîöèêëåòè, ò˜àíñïî˜òíè ñ˜åäñòâà íà âúçäóμíà âúçãëàâíèöà,
ëåòàòåëíè àïà˜àòè èëè ò˜àíñïî˜òíè ñ˜åäñòâà çà ó…àñòèå â ñúñòåçàòåëíè
ìå˜îï˜èòè, íåîäîá˜åíè îò ôè˜ìàòà Briggs & Stratton. Çà èíôî˜ìàöè
îòíîñíî ñúñòåçàòåëíè ñ˜åäñòâà âè¥òå íà óåáñò˜àíèöàòà
www.briggsracing.com. ›òíîñíî èçïîëçâàíåòî èì çà àâòîìîáèëè ñ îáùî
ï˜åíàçíà…åíèå èëè çà ñúñòåçàòåëíè âñúäåõîäè, ñòà˜òè˜àùè â ˜åäèöà, ìîëèì
äà ñå îáú˜íåòå êúì Öåíòú˜à çà ï˜èëî¥íî èçïîëçâàíå íà äâèãàòåëèòå Briggs &
Stratton, òåë. 1-866-927-3349. ‹åï˜àâèëíîòî ï˜èëî¥åíèå íà äâèãàòåë ìî¥å äà
äîâåäå äî ñå˜èîçíî íà˜àíâàíå èëè ñìú˜ò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ‹àñòîùèò äâèãàòåë ñå äîñòàâ îò Briggs & Stratton áåç
ìàñëî. fi˜åäè äà ñòà˜òè˜àòå äâèãàòåë ñå óâå˜åòå, …å ñòå íàëåëè ìàñëî â íåãî
ñïî˜åä èíñò˜óêöèèòå â òîâà ˜úêîâîäñòâî. æêî ãî ñòà˜òè˜àòå áåç ìàñëî, òîé ùå ñå
ïîâ˜åäè, áåç äà áúäå âúçìî¥íî äà ñå ˜åìîíòè˜à è áåç ïîê˜èòèå îò ãà˜àíöèòà.
Not for
Reproduction
13
bg
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
Ïðè äîëèâàíå íà ãîðèâî
fiúëíåòå ˜åçå˜âîà˜à çà ãî˜èâî íà îòê˜èòî èëè â äîá˜å âåíòèëè˜àíî
ïîìåùåíèå.
fi˜îâå˜âàéòå …åñòî ãî˜èâîï˜îâîäèòå, ˜åçå˜âîà˜à, êàïà…êàòà è
ñúåäèíåíèòà çà ïóêíàòèíè èëè òå…îâå. Çàìåíåòå ãè, àêî å íåîáõîäèìî.
Ïðè ñòàðòèðàíå íà äâèãàòåëÿ
‡âå˜åòå ñå, …å çàïàëèòåëíàòà ñâåù, μóìîçàãëóμèòåë è âúçäóμíè
ôèëòú˜ (àêî èìà òàêèâà) ñà íà ìñòîòî ñè è ñà äîá˜å çàê˜åïåíè.
‹å ˜àçâú˜òàéòå äâèãàòåë ñ èçâàäåíà çàïàëèòåëíà ñâåù.
Ïðè ðàáîòåùà ìàøèíà
‹èêîãà íå ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåë ï˜è îòñò˜àíåí êîìïëåêò
íà âúçäóμíè ôèëòú˜ (àêî èìà òàêúâ) èëè ï˜è îòñò˜àíåí âúçäóμåí
ôèëòú˜ (àêî èìà òàêúâ).
Ïðè òðàíñïîðòèðàíå íà ìàøèíàòà
Äâèãàòåëèòå, ˜àáîòåùè ñ âòå…íåí ï˜è˜îäåí ãàç/âòå…íåí ï˜îïàí-áóòàí
(LP) äà ñå ò˜àíñïî˜òè˜àò ñ ï˜àçåí öèëèíäú˜ èëè çàòâî˜åí ê˜àí çà
ãî˜èâîòî, èëè ñ ˜àçêà…åí ˜åçå˜âîà˜.
Ïðè ñêëàäèðàíå íà ãîðèâî èëè íà ìàøèíà ñ ãîðèâî â ðåçåðâîàðà
Ñêëàäè˜àéòå äàëå… îò ïåùè, ïå…êè, âîäîíàã˜åâàòåëè èëè ä˜óãè
åëåêò˜è…åñêè ï˜èáî˜è, êîèòî èìàò ñèãíàëíè ëàìïè èëè ä˜óãè çàïàëèòåëíè
èçòî…íèöè, çàùîòî òå ìîãàò äà âúçïëàìåíò èçïà˜åíèòà îò ãî˜èâîòî.
Ïóñêàíåòî íà äâèãàòåëÿ ñúçäàâà èñêðåíå.
Èñêðåíåòî ìîæå äà âúçïëàìåíè íàìèðàùèòå ñå íàîêîëî
çàïàëèìè ãàçîâå.
Òîâà ìîæå äà äîâåäå äî åêñïëîçèÿ è ïîæàð.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
æêî èìà èçòè…àíå íà ï˜è˜îäåí èëè âòå…íåí ãàç ï˜îïàí â ïîìåùåíèåòî, íå
ñòà˜òè˜àéòå äâèãàòåë.
‹å èçïîëçâàéòå ãî˜èâà çà íà…àëíî çàïàëâàíå ïîä íàëãàíå, çàùîòî
ïà˜èòå èì ñà çàïàëèòåëíè.
ÎÏÀÑÍÎÑÒ ÎÒ ÎÒÐÎÂÅÍ ÃÀÇ. Îòðàáîòèëèòå ãàçîâå ñúäúðæàò
âúãëåðîäåí îêèñ, îòðîâåí ãàç, êîéòî áè ìîãúë äà âè óáèå çà
ìèíóòè. Âèå ÍÅ ÌÎÆÅÒÅ äà ãî âèäèòå, ïîìèðèøåòå èëè äà ãî
âêóñèòå. Äîðè äà íå ïîìèðèñâàòå îòðàáîòèëèòå äèìíè ãàçîâå, âèå
âñå îùå áèõòå ìîãëè äà áúäåòå èçëîæåíè íà âëèÿíèåòî íà
âúãëåðîäíèÿ îêèñ. Àêî çàïî÷íå äà âè ïðèçëÿâà, äà èìàòå
ñâåòîâúðòåæ èëè ñëàáîñò, äîêàòî ïîåìàòå òîçè ïðîäóêò,
çàòâîðåòå èçòî÷íèêà ìó è ÍÅÇÀÁÀÂÍÎ èçëåçòå íà ÷èñò âúçäóõ.
Îòèäåòå íà äîêòîð. Âúçìîæíî å äà ñòå ïîëó÷èëè îòðàâÿíå îò
âúãëåðîäåí îêèñ.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
ˆàáîòåòå ñ òîçè ï˜îäóêò Ñæfl› íà îòê˜èòî, äàëåêî îò ï˜îçî˜öè, â˜àòè è
âåíòèëàöèîííè îòâî˜è, çà äà íàìàëèòå îïàñíîñòòà îò íàò˜óïâàíå íà
âúãëå˜îäåí îêèñ è îò ïîòåíöèàëíîòî ìó íàñî…âàíå êúì ïîìåùåíè ñ õî˜à.
flîíòè˜àéòå àëà˜ìåíè óñò˜îéñòâà çà âúãëå˜îäåí îêèñ, ˜àáîòåùè ñ
áàòå˜è èëè ñìåíâàùè ñå òàêèâà ñ ˜åçå˜âíà áàòå˜è ñïî˜åä
èíñò˜óêöèèòå íà ï˜îèçâîäèòåë. æëà˜ìåíèòå óñò˜îéñòâà çà äèì íå ìîãàò
äà îòê˜èâàò âúãëå˜îäíè îêèñ.
‹Å Ä›fi‡ÑÿæÉ‚Å òîçè ï˜îäóêò â äîìîâå, ãà˜à¥è, ìàçåòà, ñàíèòà˜íè
ïîìåùåíè, õàíãà˜è èëè ä˜óãè …àñòè…íî çàòâî˜åíè ï˜îñò˜àíñòâà, äî˜è è
ñíàáäåíè ñ âåíòèëàòî˜è èëè äú˜¥àíè ñ îòâî˜åíè â˜àòè è ï˜îçî˜öè çà
ï˜îâåò˜âàíå. ◊úãëå˜îäíèò îêèñ ìî¥å áú˜çî äà ñå íàò˜óïà è ìî¥å äà ñå
çàäú˜¥à ñ … àñîâå, äî˜è è ñëåä êàòî å áèë ñï˜í.
◊¤‹æø¤ ïîñòàâéòå òîçè ï˜îäóêò ïî ïîñîêà íà âúçäóμíîòî òå…åíèå è
íàñî…âàéòå îò˜àáîòèëèòå äèìíè ãàçîâå íàäàëåêî îò çàåòèòå ñ õî˜à
ïîìåùåíè.
Áúðçîòî ïðèòåãëÿíå íà ïóñêîâîòî âúæå (îáðàòåí óäàð)
ïðèäúðïâà ðúêàòà êúì äâèãàòåëÿ ïî-áúðçî, îòêîëêîòî âèå
ìîæåòå äà ÿ îòäðúïíåòå.
Òîâà ìîæå äà ïðè÷èíè ñ÷óïåíè êîñòè, ôðàêòóðè, êîíòóçèè è
íàâÿõâàíèÿ.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
fi˜è ñòà˜òè˜àíå íà äâèãàòåë, èçòåãëåòå âíèìàòåëíî âú¥åòî íà ˜ú…íè
ñòà˜òå˜, äîêàòî óñåòèòå ñúï˜îòèâëåíèå, à ñëåä òîâà ä˜úïíåòå ˜çêî, çà
äà èçáåãíåòå îá˜àòíè óäà˜.
¤çêë˚…åòå âñêî âúíμíî îáî˜óäâàíå/çàäâè¥âàíî îò äâèãàòåë, ï˜åäè äà
ãî ñòà˜òè˜àòå.
Äè˜åêòíî ï˜èêà…åíèòå êúì äâèãàòåë ìàμèííè åëåìåíòè êàòî íî¥îâå,
ïå˜êè, ëåáåäêè, çúáíè êîëåëà, çàäâè¥âàùè âå˜èãè è ä˜óãè, ò˜áâà äà
áúäàò ñèãó˜íî ï˜èê˜åïåíè.
Âúðòÿùèòå ñå ÷àñòè ìîãàò äà äîïðàò èëè çàõâàíàò ðúöå, êðàêà,
êîñà, îáëåêëî èëè ïðèíàäëåæíîñòè.
Ìîæå äà ñå äîñòèãíå äî òðàâìàòè÷íà àìïóòàöèÿ èëè ñåðèîçíî
íàðàíÿâàíå.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
ˆàáîòåòå ñ äâèãàòåë ï˜è ïîñòàâåíè çàùèòíè êàïàöè.
Ęú¥òå ˜úöåòå è ê˜àêàòà ñè äàëå… îò âú˜òùè ñå …àñòè.
fi˜èâú˜çâàéòå äúëãèòå êîñè è ñâàëéòå óê˜àμåíèòà.
‹å íîñåòå ïî ñåáå ñè μè˜îêî îáëåêëî, âèñùè μíó˜îâå èëè âåùè, êîèòî
ìîãàò äà áúäàò çàõâàíàòè.
Ðàáîòåùèòå äâèãàòåëè îòäåëÿò òîïëèíà. ×àñòèòå íà äâèãàòåëèòå,
îñîáåíî øóìîçàãëóøèòåëÿ, ñòàâàò èçêëþ÷èòåëíî ãîðåùè.
Ïðè äîïèð ìîæå äà ïîëó÷èòå ñåðèîçíî èçãàðÿíå.
Ãîðèìèòå îòïàäúöè, êàòî ëèñòà, òðåâè, õðàñòàëàê è äðóãè, ìîãàò
äà ñå çàïàëÿò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
›ñòàâåòå μóìîçàãëóμèòåë,öèëèíäú˜àíàäâèãàòåë è ˜åá˜àòà äà ñå
îõëàäò, ï˜åäè äà ãè äîêîñâàòå.
›òñò˜àíåòå íàò˜óïàíèòå îòëîìêè îêîëî μóìîçàãëóμèòåë è öèëèíäú˜à.
¤çïîëçâàíåòî èëè ˜àáîòàòà ñ äâèãàòåë, ïî çàëåñåíè ñ ãî˜è, õ˜àñòè èëè ñ
ò˜åâè ïëîùè, ñïî˜åä fi˜àâèëíèêà íà ÿàëèôî˜íè çà îáùåñòâåíèòå
˜åñó˜ñè, ˆàçäåë 4442, ï˜åäñòàâëâà íà˜óμåíèå, îñâåí àêî äâèãàòåëò
íå å ñíàáäåí ñ èñê˜îãàñèòåë, ïîääú˜¥àí â åôèêàñíî ˜àáîòíî ñúñòîíèå,
êàêòî å îï˜åäåëåíî â ˆàçäåë 4442. ◊ ä˜óãèòåùàòèèôåäå˜àëíè
˚˜èñäèêöèè ìî¥å äà èìà ïîäîáíè çàêîíè. Ñâú˜¥åòå ñå ñ ï˜îèçâîäèòåë,
ï˜îäàâà…à íà ä˜åáíî èëè äèñò˜èáóòî˜à íà î˜èãèíàëíîòî ñúî˜ú¥åíèå, çà
äà ïîëó…èòå èñê˜îãàñèòåë, ï˜îåêòè˜àí çà ìîíòè˜àíàòà íà òîçè äâèãàòåë
èçïóñêàòåëíà ñèñòåìà.
Ñëó÷àéíî èñêðåíå ìîæå äà äîâåäå äî ïîæàð èëè ïîðàçÿâàíå îò
åëåêòðè÷åñêè òîê.
Íåâîëíî ñòàðòèðàíå ìîæå äà äîâåäå äî çàõâàùàíå, òðàâìàòè÷íà
àìïóòàöèÿ èëè äî ðàíÿâàíå.
Îïàñíîñò îò ïîæàð
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ïðåäè èçâúðøâàíå íà ðåãóëèðîâêè è ïîïðàâêè:
›òêà…åòå êàáåëà íà çàïàëèòåëíàòà ñâåù è ãî ä˜ú¥òå äàëå… îò íå.
›òêà…åòå ìèíóñ-êëåìàòà íà àêóìóëàòî˜à (ñàìî ï˜è äâèãàòåëè ñ
åëåêò˜è…åñêè ñòà˜òå˜).
¤çïîëçâàéòå ñàìî ïîäõîäùè èíñò˜óìåíòè.
‹å çàñòîïî˜âàéòå ñ ˜åãóëè˜àùàòà ï˜ó¥èíà, ëîñòîâèòå ñèñòåìè èëè ñ
ä˜óãè…àñòè,çàäàïîâèμèòå îáî˜îòèòå íà äâèãàòåë.
ˆåçå˜âíèòå …àñòè ò˜áâà äà áúäàò ñúñ ñúùàòà êîíñò˜óêöè èäàñå
ìîíòè˜àò â ñúùîòî ïîëî¥åíèå, êàêòî î˜èãèíàëíèòå …àñòè. ˝àñòè îò ä˜óã
ï˜îèçâîäèòåë ìî¥å äà íå ˜àáîòò äîá˜å, ìî¥å äà ïîâ˜åäòàã˜åãàòàèëè
äà äîâåäàò äî íà˜àíâàíå.
‹å óä˜éòå ìàõîâèêà ñ …óê èëè òâú˜ä ï˜åäìåò, çàùîòî òîé ìî¥å äà ñå
ñò˜îμè ïî â˜åìå íà ˜àáîòà.
Ïðè èçïðîáâàíå çà èñêðà:
¤çïîëçâàéòå îäîá˜åí òèï òåñòå˜ çà ñâåùè.
‹å ï˜àâåòå ï˜îâå˜êà çà èñê˜à ï˜è èçâàäåíà çàïàëèòåëíà ñâåù.
Not for
Reproduction
14
VanguardEngines.com
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãàçîâèòå ãîðèâà ñà èçêëþ÷èòåëíî îãíåîïàñíè è ëåñíî îáðàçóâàò
åêñïëîçèâíè ñìåñè îò ïàðè è âúçäóõ ïðè îêîëíèòå òåìïåðàòóðè.
Àêî óñåòèòå ìèðèñ íà ãàç,
Íå ñòà˜òè˜àéòå äâèãàòåë.
Íå çàäåéñòâàéòå íèêàêâè åëåêò˜è…åñêè êë˚…îâå.
Íå èçïîëçâàéòå òåëåôîí â áëèçîñò.
‹àïóñíåòå ìñòîòî.
Ñâú˜¥åòå ñå ñ äîñòàâ…èêà íà áåíçèí èëè ï˜îòèâîïî¥à˜íàòà ñëó¥áà.
flîíòà¥úò, ˜åãóëè˜àíåòî è ˜åìîíòúò ò˜áâà äà ñå èçâú˜μâàò îò
êâàëèôèöè˜àí òåõíèê.
ˆåäîâíî ï˜îâå˜âàéòå ãúâêàâèòå çàõ˜àíâàùè ï˜îâîäè. ‡âå˜åòå ñå, …å ñà
â äîá˜î ñúñòîíèå. Ñìåíåòå ïîâ˜åäåíèòå èëè ñúëçùè êîìïîíåíòè.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Íîñåòå çàùèòíè î÷èëà, êîãàòî èçâúðøâàòå ðåìîíòíà äåéíîñò.
Äîïèðúò íà êîæà/îêî äî óòå÷êà íà âòå÷íåí ïðîïàí-áóòàí ãàç
ìîæå äà äîâåäå äî èçìðúçâàíåòî èì.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ëèïñâàù èëè íåäåéñòâàù ”èçêëþ÷âàù ãîðèâîòî” êëàïàí ìîæå äà
ïðè÷èíè ïîæàð èëè åêñïëîçèÿ.
Íå ˜àáîòåòå ñ ìàμèíàòà, àêî ∆èçêë˚…âàùèò ãî˜èâîòî∆ êëàïàí ëèïñâà èëè
íå äåéñòâà.
Not for
Reproduction
15
bg
Åëåìåíòè è óïðàâëåíèÿ
јàâíåòå èë˚ñò˜àöèòà
1
ñâàμè äâèãàòåë, çà äà ñå çàïîçíàåòå ñ
˜àçïîëî¥åíèåòî íà ˜àçëè…íèòå åëåìåíòè è óï˜àâëåíè.
A. flà˜êè˜îâêà íà äâèãàòåë
Ìîäåë Òèï Êîä
B. Çàïàëèòåëíà ñâåù
C. ◊úçäóμåí ôèëòú˜ öèêëîíåí òèï
D. ◊úçäóμåí ôèëòú˜ ñ íèñúê ï˜îôèë
E. ‹èâîïîêàçàòåë
F. ›òâî˜ çà íàëèâàíå íà ìàñëî
G. flàñëåí ôèëòú˜
H. fi˜îáêà çà èçòî…âàíå íà ìàñëîòî
I. Äàò…èê çà íàëãàíå íà ìàñëîòî
J. fi˜åäïàçèòåë çà ï˜úñòèòå / ◊ú˜òù ñå åê˜àí
K. Åëåêò˜è…åñêè ñòà˜òå˜
L. ¤íäóêöèîííà áîáèíà çà ñòà˜òè˜àíå
M. ˆåãóëàòî˜/ fi˜å…èñòâàòåë
N. LPG/NG Ñìåñèòåë çà ï˜è˜îäåí ãàç/ãàç ï˜îïàí áóòàí
O. ›õëàäèòåë íà ìàñëî
Ðàáîòà
◊ìåñòèìîñò çà ìàñëî (íàï˜àâåòå ñï˜àâêà â ˜àçäåë Òåõíè÷åñêè äàííè).
Ïðåïîðúêè çà ìàñëîòî
Çà ïîëó…àâàíå íà íàé-äîá˜è òåõíè…åñêè ïîêàçàòåëè ï˜åïî˜ú…âàìå èçïîëçâàíåòî
íà ìàñëàòà íà Briggs & Stratton ñ ãà˜àíöè è ñå˜òèôèêàò çà êà…åñòâî. Ęóãè
âèñîêîêà…åñòâåíè ìàñëà ñ ìèåùè ï˜èñàäêè ñà ï˜èåìëèâè, àêî ñà êëàñèôèöè˜àíè
çà ˜àáîòíè ˜å¥èìè SF, SG, SH, SJ èëè ïî-âèñîêè. Äà íå ñå èçïîëçâàò ñïåöèàëíè
äîáàâêè.
◊úíμíèòå òåìïå˜àòó˜è îï˜åäåëò ï˜àâèëíè âèñêîçèòåò íà ìàñëîòî çà
äâèãàòåë. ¤çïîëçâàéòå òàáëèöàòà, çà äà èçáå˜åòå íàé-äîá˜è âèñêîçèòåò çà
î…àêâàíè äèàïàçîí íà âúíμíèòå òåìïå˜àòó˜è.
SAE 30.
10W-30
Ñèíòåòè÷íî 5W-30
5W-30
°F °C
* ¤çïîëçâàíåòî íà ìàñëî SAE 30 ï˜è òåìïå˜àòó˜è ïîä 40° F(4°C) ùå äîâåäå äî
ò˜óäíî ñòà˜òè˜àíå íà äâèãàòåë.
** ¤çïîëçâàíåòî íà ìàñëî 10 W-30 ï˜è òåìïå˜àòó˜è íàä 80°F(27°C) ìî¥å äà
ïîâèμè êîíñóìàöèòà íà ìàñëî. fi˜îâå˜âàéòå ïî-…åñòî íèâîòî ìó.
Êàê äà ïðîâåðÿâàòå/äîëèâàòå ìàñëî - Ôèãóðà
2
Ïðåäè íàëèâàíå èëè ïðîâåðÿâàíå íà ìàñëîòî
ˆàçïîëî¥åòå õî˜èçîíòàëíî äâèãàòåë.
fiî…èñòåòå ìñòîòî îêîëî îòâî˜à çà íàëèâàíå íà ìàñëî îò âñè…êè îòëîìêè.
1. Ñâàëåòå íèâîïîêàçàòåë (A) è ãî èçáú˜μåòå ñ …èñò ïëàò (·èãó˜à 2).
2. fiîñòàâåòå íèâîïîêàçàòåë è ãî çàòåãíåòå.
3. Ñâàëåòå íèâîïîêàçàòåë è ï˜îâå˜åòå íèâîòî íà ìàñëîòî. ‚î ò˜áâà äà áúäå
äî íàé-âèñîêè çíàê çà íàïúëâàíå (B) íà íèâîïîêàçàòåë.
4. æêî å íèñêî, íàëåéòå âíèìàòåëíî ìàñëî ï˜åç îòâî˜à çà ïúëíåíå (C). Íå
ïðåïúëâàéòå. Ñëåä íàëèâàíå íà ìàñëî, èç…àêàéòå åäíà ìèíóòà è ïîñëå ïàê
ï˜îâå˜åòå íèâîòî ìó.
5. fiîñòàâåòå îòíîâî íèâîïîêàçàòåë è ãî çàòåãíåòå.
Ñèñòåìà çà çàùèòà ïðè íèñêî íèâî íà ìàñëîòî (àêî èìà
òàêàâà)
‹êîè äâèãàòåëè ñà îáî˜óäâàíè ñ äàò…èê çà íèñêî íèâî íà ìàñëîòî. æêî íèâîòî íà
ìàñëîòî å íèñêî, äàò…èêúò èëè ùå âêë˚…è ï˜åäóï˜åäèòåëåí ñâåòëèíåí ñèãíàë,
èëè ùå ñï˜å äâèãàòåë. Ñï˜åòå äâèãàòåë è ñëåäâàéòå ñëåäíèòå ñòúïêè ï˜åäè äà
ãî ñòà˜òè˜àòå îòíîâî.
‡âå˜åòå ñå, …å äâèãàòåëò å õî˜èçîíòàëíî ˜àçïîëî¥åí.
fi˜îâå˜åòå íèâîòî íà ìàñëîòî. ‹àï˜àâåòå ñï˜àâêà â ˜àçäåë Êàê ñå
ïðîâåðÿâà/íàëèâà ìàñëî.
æêî íèâîòî íà ìàñëîòî å íèñêî, äîáàâåòå òî…íîòî êîëè…åñòâî ìàñëî.
Ñòà˜òè˜àéòå äâèãàòåë è ñå óâå˜åòå, …å ï˜åäóï˜åäèòåëíèò ñâåòëèíåí ñèãíàë
(àêî èìà òàêúâ) íå å çàäåéñòâàí.
æêî íèâîòî íà ìàñëîòî å íèñêî, íå ñòàðòèðàéòå äâèãàòåë. ›áú˜íåòå ñå êúì
‡ïúëíîìîùåí ï˜åäñòàâèòåë íà Briggs & Stratton, çà äà îòñò˜àíèòå ï˜îáëåìà ñ
ìàñëîòî.
Ïðåïîðúêè çà ãîðèâîòî
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ëèïñâàù èëè íåäåéñòâàù ”èçêëþ÷âàù ãîðèâîòî” êëàïàí ìîæå äà
ïðè÷èíè ïîæàð èëè åêñïëîçèÿ.
Íå ˜àáîòåòå ñ ìàμèíàòà, àêî ∆èçêë˚…âàùèò ãî˜èâîòî∆ êëàïàí ëèïñâà èëè
íå äåéñòâà.
Ãîðèâîòî òðÿáâà äà îòãîâàðÿ íà ñëåäíèòå èçèñêâàíèÿ:
¤çïîëçâàéòå …èñòî, ñóõî ãî˜èâî, áåç âëàãà èëè íêàêúâ ï˜àõîâ ìàòå˜èàë.
¤çïîëçâàíåòî íà ãî˜èâà, èçâúí ï˜åïî˜ú…âàíèòå ïî-äîëó êàòåãî˜èè, ìî¥å äà
äîâåäå äî ï˜îáëåìè â ˜àáîòíàòà õà˜àêòå˜èñòèêà.
fi˜è äâèãàòåëè, íàñò˜îåíè äà ˜àáîòò ñ âòå…íåí ãàç ï˜îïàíáóòàí, ñå
ï˜åïî˜ú…âà òú˜ãîâñêàòà ìà˜êà HD5 LPG. fi˜åïî˜ú…âàíèò ñúñòàâ íà ãî˜èâîòî
å òîçè, ñ ìèíèìàëåí ñïåöèôè…åí òå˜ìîäèíàìè…åí ïîòåíöèàë ïî îáåì, îò
ìèíèìóì 2500 BTU/ôóòà3 (93150 kJ/m
3
), ñ 5% ìàêñèìàëíî ñúäú˜¥àíèå íà
ï˜îïèëåí, ñ 2,5% ñúäú˜¥àíèå íà áóòàí è ïî-òå¥êè ãàçîâå è ñ 90% ìèíèìàëíî
ñúäú˜¥àíèå íà ï˜îïàí.
Äâèãàòåëèòå ñ ùåìïåë NG èëè LPG ñà ñå˜òèôèöè˜àíè çà ˜àáîòà ñ ï˜è˜îäåí ãàç
èëè âòå…íåí ãàç ï˜îïàí. Ñèñòåìàòà çà áî˜áà ñ â˜åäíèòå åìèñèè çà òîçè äâèãàòåë
åEM(flîäèôèêàöèè íà äâèãàòåëèòå).
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: flàμèíàòà, íà êîòî ùå ñå ìîíòè˜à òàêúâ
äâèãàòåë, å îáî˜óäâàíà ñ àâòîìàòè…åí, ï˜åäïàçåí, ∆èçêë˚…âàù ãî˜èâîòî∆
êëàïàí. ‹å ˜àáîòåòå ñ ìàμèíàòà, àêî ∆èçêë˚…âàùè ãî˜èâîòî∆ êëàïàí ëèïñâà
èëè íå äåéñòâà.
Êàê ñå íàëèâà ìàñëî
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
Ïðè äîëèâàíå íà ãîðèâî
fiúëíåòå ˜åçå˜âîà˜à çà ãî˜èâî íà îòê˜èòî èëè â äîá˜å âåíòèëè˜àíî
ïîìåùåíèå.
fi˜îâå˜âàéòå …åñòî ãî˜èâîï˜îâîäèòå, ˜åçå˜âîà˜à, êàïà…êàòà è
ñúåäèíåíèòà çà ïóêíàòèíè èëè òå…îâå. Çàìåíåòå ãè, àêî å íåîáõîäèìî.
fi˜î…åòåòå ˜àáîòíèòå èíñò˜óêöèè, äîñòàâåíè îò ï˜îèçâîäèòåë íà ìàμèíàòà, çà
ñâåäåíè îòíîñíî çà˜å¥äàíåòî íà äâèãàòåëè, ˜àáîòåùè ñ ï˜è˜îäåí ãàç èëè
âòå…íåí ãàç ï˜îïàíáóòàí.
Êàê äà ñòàðòèðàòå äâèãàòåëÿ - Ôèãóðà
3
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
Ïðè ñòàðòèðàíå íà äâèãàòåëÿ
‡âå˜åòå ñå, …å çàïàëèòåëíàòà ñâåù, μóìîçàãëóμèòåë è âúçäóμíè
ôèëòú˜ (àêî èìà òàêèâà) ñà íà ìñòîòî ñè è ñà äîá˜å çàê˜åïåíè.
‹å ˜àçâú˜òàéòå äâèãàòåë ñ èçâàäåíà çàïàëèòåëíà ñâåù.
Not for
Reproduction
16 VanguardEngines.com
ÎÏÀÑÍÎÑÒ ÎÒ ÎÒÐÎÂÅÍ ÃÀÇ. Îòðàáîòèëèòå ãàçîâå ñúäúðæàò
âúãëåðîäåí îêèñ, îòðîâåí ãàç, êîéòî áè ìîãúë äà âè óáèå çà
ìèíóòè. Âèå ÍÅ ÌÎÆÅÒÅ äà ãî âèäèòå, ïîìèðèøåòå èëè äà ãî
âêóñèòå. Äîðè äà íå ïîìèðèñâàòå îòðàáîòèëèòå äèìíè ãàçîâå, âèå
âñå îùå áèõòå ìîãëè äà áúäåòå èçëîæåíè íà âëèÿíèåòî íà
âúãëåðîäíèÿ îêèñ. Àêî çàïî÷íå äà âè ïðèçëÿâà, äà èìàòå
ñâåòîâúðòåæ èëè ñëàáîñò, äîêàòî ïîåìàòå òîçè ïðîäóêò,
çàòâîðåòå èçòî÷íèêà ìó è ÍÅÇÀÁÀÂÍÎ èçëåçòå íà ÷èñò âúçäóõ.
Îòèäåòå íà äîêòîð. Âúçìîæíî å äà ñòå ïîëó÷èëè îòðàâÿíå îò
âúãëåðîäåí îêèñ.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
ˆàáîòåòå ñ òîçè ï˜îäóêò Ñæfl› íà îòê˜èòî, äàëåêî îò ï˜îçî˜öè, â˜àòè è
âåíòèëàöèîííè îòâî˜è, çà äà íàìàëèòå îïàñíîñòòà îò íàò˜óïâàíå íà
âúãëå˜îäåí îêèñ è îò ïîòåíöèàëíîòî ìó íàñî…âàíå êúì ïîìåùåíè ñ õî˜à.
flîíòè˜àéòå àëà˜ìåíè óñò˜îéñòâà çà âúãëå˜îäåí îêèñ, ˜àáîòåùè ñ
áàòå˜è èëè ñìåíâàùè ñå òàêèâà ñ ˜åçå˜âíà áàòå˜è ñïî˜åä
èíñò˜óêöèèòå íà ï˜îèçâîäèòåë. æëà˜ìåíèòå óñò˜îéñòâà çà äèì íå ìîãàò
äà îòê˜èâàò âúãëå˜îäíè îêèñ.
‹Å Ä›fi‡ÑÿæÉ‚Å òîçè ï˜îäóêò â äîìîâå, ãà˜à¥è, ìàçåòà, ñàíèòà˜íè
ïîìåùåíè, õàíãà˜è èëè ä˜óãè …àñòè…íî çàòâî˜åíè ï˜îñò˜àíñòâà, äî˜è è
ñíàáäåíè ñ âåíòèëàòî˜è èëè äú˜¥àíè ñ îòâî˜åíè â˜àòè è ï˜îçî˜öè çà
ï˜îâåò˜âàíå. ◊úãëå˜îäíèò îêèñ ìî¥å áú˜çî äà ñå íàò˜óïà è ìî¥å äà ñå
çàäú˜¥à ñ … àñîâå, äî˜è è ñëåä êàòî å áèë ñï˜í.
◊¤‹æø¤ ïîñòàâéòå òîçè ï˜îäóêò ïî ïîñîêà íà âúçäóμíîòî òå…åíèå è
íàñî…âàéòå îò˜àáîòèëèòå äèìíè ãàçîâå íàäàëåêî îò çàåòèòå ñ õî˜à
ïîìåùåíè.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ‹àñòîùèò äâèãàòåë ñå äîñòàâ îò Briggs & Stratton áåç
ìàñëî. fi˜åäè äà ñòà˜òè˜àòå äâèãàòåë ñå óâå˜åòå, …å ñòå íàëåëè ìàñëî â íåãî
ñïî˜åä èíñò˜óêöèèòå â òîâà ˜úêîâîäñòâî. æêî ãî ñòà˜òè˜àòå áåç ìàñëî, òîé ùà ñå
ïîâ˜åäè áåç äà áúäå âúçìî¥íî äà ñå ˜åìîíòè˜à è ãà˜àíöèòà íìà äà ïîê˜èâà
ùåòàòà.
Çàáåëåæêà: ‹êîè äâèãàòåëè è îáî˜óäâàíå ñà ñíàáäåíè ñ óñò˜îéñòâà çà
äèñòàíöèîííî óï˜àâëåíèå. ‹àï˜àâåòå ñï˜àâêà â ˆúêîâîäñòâîòî çà ˜àáîòà ñ
îáî˜óäâàíåòî ç à ˜àçïîëî¥åíèåòî è ˜àáîòàòà ñ óñò˜îéñòâàòà çà äèñòàíöèîííî
óï˜àâëåíèå.
1. fi˜îâå˜åòå íèâîòî íà ìàñëîòî. ‹àï˜àâåòå ñï˜àâêà â ˜àçäåëà Êàê ñå
ïðîâåðÿâà/íàëèâà ìàñëî.
2. ‡âå˜åòå ñå, …å óï˜àâëåíèòà íà ñúî˜ú¥åíèåòî, àêî èìà ò àêèâà, ñà èçêë˚…åíè.
3. Çàâú˜òåòå ê˜àí…åòî çà ïîäàâàíå íà ãî˜èâî (A), àêî èìà òàêîâà, íà ïîçèöè on
(·èãó˜à 3).
4. fi˜åìåñòåòå
ëîñòà
íà ˜ú…íàòà ãàç (B) íà ïîçèöè çà áú˜çè îáî˜îòè
.
ˆàáîòåòå ñ äâèãàòåë ï˜è ïîçèöè
íà áú˜çè îáî˜îòè.
5. Çàâú˜òåòå êë˚…à çà åëåêò˜è…åñêè ñòà˜òå˜ (C) íà ïîçèöè on/s tart (·èãó˜à 3).
ÇÀÁÅËÅÆÊÀ: æêî äâèãàòåëò íå ñòà˜òè˜à ñëåä íêîëêî ïîâòî˜íè îïèòà,
ñâú˜¥åòå ñå ñ âàμè ìåñòåí äèñò˜èáóòî˜ èëè ñå îáàäåòå íà
VanguardEngines.com or call 1-800-999-9333 (â ÑæÂ).
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: Çà äà ï˜îäúë¥èòå ¥èâîòà íà ñòà˜òå˜à, èçïîëçâàéòå
ê˜àòêè ñòà˜òîâè öèêëè (ïåò ñåêóíäè ìàêñèìóì). ¤ç…àêâàéòå åäíà ìèíóòà
ìå¥äó îòäåëíèòå ñòà˜òîâè öèêëè.
Êàê äà ñïðåòå äâèãàòåëÿ - Ôèãóðà
3
1. fi˜åìåñòåòå ëîñòà íà ˜ú…íàòà ãàç íà ïîçèöè çà áàâíè îáî˜îòè, çàâú˜òåòå
êë˚…à (C) íà ïîçèöè off (·èãó˜à 3). ¤çâàäåòå êë˚…àèãîïàçåòåíàñèãó˜íî
ìñòî, äàëå…å îò îáñåãà íà äåöà.
2. Ñëåä ñïè˜àíå íà äâèãàòåë, çàâú˜òåòå ê˜àí…åòî çà ïîäàâàíå íà ãî˜èâîòî (A),
àêî èìà òàêîâà íà çàòâî˜åíî ïîëî¥åíèå.
Òåõíè÷åñêî îáñëóæâàíå
‹èå âè ï˜åïî˜ú…âàìå äà ïîñåòèòå ›òî˜èçè˜àí ñå˜âèçåí ï˜åäñòàâèòåë íà Briggs &
Stratton çà âñè…êè îïå˜àöèè ïî òåõíè…åñêîòî è ñå˜âèçíîòî îáñëó¥âàíå íà
äâèãàòåë è ˜åçå˜âíèòå …àñòè.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ◊ñè…êè êîìïîíåíòè, èçïîëç âàíè ï˜è ï˜îèçâîäñòâîòî íà
òîçè äâèãàòåë, ò˜áâà äà áúäàò íà ìñòîòî ñè çà ï˜àâèëíàòà ìó ˜àáîòà.
Êîíòðîë íà åìèñèèòå
Ïîääðúæêàòà, ñìÿíàòà èëè ðåìîíòúò íà óñòðîéñòâàòà è ñèòåìèòå çà êîíòðîë
íà âðåäíèòå åìèñèè ìîãàò äà áúäàò èçâúðøâàíè îò âñåêè ðåìîíòåí öåõ èëè
òåõíèê, ðåìîíòèðàùè äâèãàòåëè çà ÌÏÑ ñ ïîâèøåíà ïðîõîäèìîñò. ◊ñå ïàê, çà
äà ïîëó…èòå ∆áåçïëàòíî∆ îáñëó¥âàíå íà óñò˜îéñòâàòà çà êîíò˜îë íà â˜åäíèòå
åìèñèè, ˜àáîòàòà ò ˜áâà äà áúäå èçâú˜μåíà îò óïúëíîìîùåí çàâîäñêè
ï˜åäñòàâèòåë. ‹àï˜àâåòå ñï˜àâêà â øà˜àíöèòà îòíîñíî â˜åäíèòå åìèñèè.
Ñëó÷àéíî èñêðåíå ìîæå äà äîâåäå äî ïîæàð èëè ïîðàçÿâàíå îò
åëåêòðè÷åñêè òîê.
Íåâîëíî ñòàðòèðàíå ìîæå äà äîâåäå äî çàõâàùàíå, òðàâìàòè÷íà
àìïóòàöèÿ èëè äî ðàíÿâàíå.
Îïàñíîñò îò ïîæàð
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ïðåäè èçâúðøâàíå íà ðåãóëèðîâêè è ïîïðàâêè:
›òêà…åòå êàáåëà íà çàïàëèòåëíàòà ñâåù è ãî ä˜ú¥òå äàëå… îò íå.
›òêà…åòå ìèíóñ-êëåìàòà íà àêóìóëàòî˜à (ñàìî ï˜è äâèãàòåëè ñ
åëåêò˜è…åñêè ñòà˜òå˜).
¤çïîëçâàéòå ñàìî ïîäõîäùè èíñò˜óìåíòè.
‹å çàñòîïî˜âàéòå ñ ˜åãóëè˜àùàòà ï˜ó¥èíà, ëîñòîâèòå ñèñòåìè èëè ñ
ä˜óãè…àñòè,çàäàïîâèμèòå îáî˜îòèòå íà äâèãàòåë.
ˆåçå˜âíèòå …àñòè ò˜áâà äà áúäàò ñúñ ñúùàòà êîíñò˜óêöè èäàñå
ìîíòè˜àò â ñúùîòî ïîëî¥åíèå, êàêòî î˜èãèíàëíèòå …àñòè. ˝àñòè îò ä˜óã
ï˜îèçâîäèòåë ìî¥å äà íå ˜àáîòò äîá˜å, ìî¥å äà ïîâ˜åäòàã˜åãàòàèëè
äà äîâåäàò äî íà˜àíâàíå.
‹å óä˜éòå ìàõîâèêà ñ …óê èëè òâú˜ä ï˜åäìåò, çàùîòî òîé ìî¥å äà ñå
ñò˜îμè ïî â˜åìå íà ˜àáîòà.
Ïðè èçïðîáâàíå çà èñêðà:
¤çïîëçâàéòå îäîá˜åí òèï òåñòå˜ çà ñâåùè.
‹å ï˜àâåòå ï˜îâå˜êà çà èñê˜à ï˜è èçâàäåíà çàïàëèòåëíà ñâåù.
Ãðàôèê çà òåõíè÷åñêî îáñëóæâàíå
Íà âñåêè 8 ÷àñà èëè åæåäíåâíî
Äà ñå ï˜îâå˜âà íèâîòî íà ìàñëîòî â äâèãàòåë
Äà ñå ïî…èñòâàò ïîâú˜õíîñòèòå îêîëî μóìîçàãëóμèòåë è óï˜àâëåíèòà.
Íà âñåêè 100 ÷àñà èëè åæåãîäíî
fiî…èñòåòå èëè ñìåíåòå âúçäóμíè ôèëòú˜ *
Y
Äà ñå ñìåí ìàñëîòî è ôèëòú˜à íà äâèãàòåë
Äà ñå ñìåíè çàïàëèòåëíàòà ñâåù
Äà ñå ï˜åãëå¥äàò μóìîçàãëóμèòåë è èñê˜îãàñèòåë
Äà ñå ï˜îâå˜ò ìå¥äèíàòà íà êëàïàíèòå. Peryëèpaéòe , aêo e íeoáxoäèìo.
Íà âñåêè 400 ÷àñà èëè åæåãîäíî
Äà ñå ñìåí âúçäóμíè ôèëòú˜
Y
Äà ñå ïî…èñòè âúçäóμíàòà îõëàäèòåëíà ñèñòåìà *
Äà ñå ïî…èñòâàò îõëàäèòåëíèòå ïëàñòèíè *
Íà âñåêè 600 ÷àñà èëè åæåãîäíî
Äà ñå ñìåí ï˜åäïàçíè ôèëòú˜ (àêî èìà òàêúâ)
* fi˜è íàëè…èå íà çàï˜àμåíîñò èëè íîñåùè ñå â îêîëíîòî ï˜îñò˜àíñòâî
îòëîìêè, äà ñå ïî…èñòâà ïî-…åñòî.
Y
fi˜è âñêà ò˜åòà ñìíà íà âúçäóμíè ôèëòú˜ ñìåíâàéòå âúò˜åμíè
ï˜åäîõ˜àíèòåëåí ôèëòú˜ (àêî èìà òàêúâ).
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: fi˜îèçâîäèòåëò íà îáî˜óäâàíåòî, íà êîåòî òîçè äâèãàòåë
ùå áúäå ìîíòè˜àí, îï˜åäåë ìàêñèìàëíèòå îáî˜îòè, ï˜è êîèòî ùå ˜àáîòè
äâèãàòåëò. Íå íàäâèøàâàéòå òåçè îáî˜îòè.
Êàê ñå ñìåíÿ çàïàëèòåëíàòà ñâåù - Ôèãóðà
4
fi˜îâå˜âàéòå ìå¥äèíàòà ìå¥äó åëåêò˜îäèòå (A,·èãó˜à4)ñïîìîùòàíà
êàëèáú˜ çà òåë (B). æêî å íåîáõîäèìî, ˜åãóëè˜àéòå ìå¥äèíàòà. flîíòè˜àéòå è
çàòåãíåòå ñâåùòà ñ ï˜åïî˜ú…âàíè âú˜òù ìîìåíò. Çà ˜åãóëè˜àíå íà ìå¥äèíàòà
èëè îòíîñíî âú˜òùè ìîìåíò çà çàòãàíå, íàï˜àâåòå ñï˜àâêà â ˜àçäåë
Òåõíè÷åñêè äàííè.
Çàáåëåæêà: ‹à íêîè ìåñòà, ìåñòíèò çàêîí èçèñêâà óïîò˜åáà íà ˜åçèñòî˜íà
ñâåù, çà äà ñå ïîäòèñíàò ˜àäèîñìóùåíèòà. æêî íàñòîùèòäâèãàòåëå
ôàá˜è…íî îáî˜óäâàí ñ ˜åçèñòî˜íà ñâåù, èçïîëçâàéòå ñúùè òèï ñâåù çà ñìíà.
Not for
Reproduction
17
bg
Äà ñå ïðîâåðÿâà âíèìàòåëíî øóìîçàãëóøèòåëÿ è
èñêðîãàñèòåëÿ - Ôèãóðà
5
Ðàáîòåùèòå äâèãàòåëè îòäåëÿò òîïëèíà. ×àñòèòå íà äâèãàòåëèòå,
îñîáåíî øóìîçàãëóøèòåëÿ, ñòàâàò èçêëþ÷èòåëíî ãîðåùè.
Ïðè äîïèð ìîæå äà ïîëó÷èòå ñåðèîçíî èçãàðÿíå.
Ãîðèìèòå îòïàäúöè, êàòî ëèñòà, òðåâè, õðàñòàëàê è äðóãè, ìîãàò
äà ñå çàïàëÿò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
›ñòàâåòå μóìîçàãëóμèòåë, öèëèíäú˜à íà äâèãàòåë è ˜åá˜àòà äà ñå
îõëàäò, ï˜åäè äà ãè äîêîñâàòå.
›òñò˜àíåòå íàò˜óïàíèòå îòëîìêè îêîëî μóìîçàãëóμèòåë è öèëèíäú˜à.
Äà ñå èçïîëçâà èëè ˜àáîòè ñ äâèãàòåë â ç åìè, ïîê˜èòè ñ ãî˜à, õ˜àñòè èëè
ò˜åâà å íà˜óμåíèå íà fi˜àâèëíèêà çà îáùåñòâåíèòå ˜åñó˜ñè â
ÿàëèôî˜íè, ˆàçäåë 4442, îñâåí àêî òîé íå å îáî˜óäâàí ñ èñê˜îãàñèòåë,
ïîääú˜¥àí â åôåêòèâíî ˜àáîòíî ñúñòîíèå, êàêòî ˜àçïî˜å¥äà ˆàçäåë
4442. ◊úçìî¥íî å ä˜óãè ùàòè èëè ä˜óãè ˚˜èñäèêöèè äà èìàò ïîäîáíè
çàêîíè. Ñâú˜¥åòå ñå ñúñ ï˜îèçâîäèòåë íà î˜èãèíàëíîòî îáî˜óäâàíå, ñ
ï˜îäàâà… íà ä˜åáíî èëè äèëú˜, çà äà ñè íàáàâèòå èñê˜îãàñèòåë,
ï˜îåêòè˜àí çà èçïóñêàòåëíàòà ñèñòåìà íà òîçè äâèãàòåë.
›òñò˜àíåòå íàò˜óïàíèòå îòëîìêè îò ï˜îñò˜àíñòâàòà îêîëî μóìîçàãëóμèòåë è
öèëèíäú˜à. fi˜îâå˜åòå μóìîçàãëó μèòåë (A, ·èãó˜à 5) çà ïóêíàòèíè, êî˜îçè èëè
ä˜óãà ïîâ˜åäà. Äåìîíòè˜àéòå èñê˜îãàñèòåë (B), (àêî èìà òàêúâ) è ãî ï˜îâå˜åòå
çà ïîâ˜åäà èëè çàïóμâàíå ñúñ ñà¥äè. æêî îòê˜èåòå ïîâ˜åäà, ìîíòè˜àéòå
˜åçå˜âíèòå …àñòè, ï˜åäè äà çàïî…íåòå ˜àáîòà.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ˆåçå˜âíèòå …àñòè ò˜áâà äà áúäàò ñúñ
ñúùàòà êîíñò˜óêöè è äà ñå ìîíòè˜àò â ñúùîòî ïîëî¥åíèå, êàêòî
î˜èãèíàëíèòå …àñòè. ˝àñòè îò ä˜óã ï˜îèçâîäèòåë ìî¥å äà íå ˜àáîòò äîá˜å,
ìî¥å äà ïîâ˜åäò àã˜åãàòà èëè äà äîâåäàò äî íà˜àíâàíå.
Êàê äà ñå ñìåíÿ ìàñëîòî - Ôèãóðà
6
›ò˜àáîòèëîòî ìàñëî å îïàñåí îòïàäú…åí ï˜îäóêò è ò˜áâà äà ñå ñêëàäè˜à ïî
ïîäõîäù íà…èí. ‹å ãî èçõâú˜ëéòå ñ äîìàêèíñêèòå îòïàäúöè. fi˜îâå˜åòå
ñúâìåñòíî ñ îáùèíñêèòå âëàñòè, çà îáñëó¥âàù öåíòú˜ èëè çà ï˜åäñòàâèòåë íà
èíñòàëàöèè çà áåçîïàñíî äåïîíè˜àíå/˜åöèêëè˜àíå íà îò˜àáîòèëîòî ìàñëî.
Èçòî÷åòå îòðàáîòèëîòî ìàñëî
1. fi˜è èçêë˚…åí, íî âñå îùå òîïúë äâèãàòåë, îòêà…åòå êàáåëà íà ç àïàëèòåëíàòà
ñâåù (A) è ãî ä˜ú¥òå íà ˜àçñòîíèå îò ñâåùòà (·èãó˜à 6).
2. Ñâàëåòå ï˜îáêàòà çà èçòî…âàíå íà ìàñëîòî (B). ¤çòî…åòå ãî â ïîäõîäù
êîíòåéíå˜.
3. Ñëåä êàòî ìàñëîòî å èçòî…åíî, ïîñòàâåòå è çàòåãíåòå ï˜îáêàòà.
Ñìÿíà íà ìàñëåíèÿ ôèëòúð
◊ñè…êè ìîäåëè èìàò ìàñëåí ôèëòú˜. ›òíîñíî èíòå˜âàëèòå çà ñìíàòà ìó
íàï˜àâåòå ñï˜àâêà â êà˜òàòà Òåõíè÷åñêî îáñëóæâàíe.
1. ¤çòî…åòå ìàñëîòî îò äâèãàòåë. ‹àï˜àâåòå ñï˜àâêà â ˜àçäåë Èçòî÷âàíå íà
ìàñëîòî.
2. Ñâàëåòå ìàñëåíè ôèëòú˜ (C,·èãó˜à6).è ãî äåïîíè˜àéòå ïî ïîäõîäùè
íà…èí.
3. fi˜åäè äà ìîíòè˜àòå íîâè ìàñëåí ôèëòú˜, ëåêî ñìà¥åòå ôèëòú˜íàòà
ãà˜íèòó˜à ñ íîâî, …èñòî ìàñëî.
4. flîíòè˜àéòå ìàñëåíè ôèëòú˜ íà ˜úêà, äîêàòî ãà˜íèòó˜àòà îï˜å âúâ
ôèëòú˜íè àäàïòå˜, ñëåä êîåòî ãî çàòåãíåòå ñ îùå 1/2 äî 3/4 îáî˜îòà.
5. ‹àëèâàíå íà ìàñëî. ‹àï˜àâåòå ñï˜àâêà â ˜àçäåë Íàëèâàíå íà ìàñëî.
6. Ñòà˜òè˜àéòå è îñòàâåòå äâèãàòåë äà ˜àáîòè. Âîì çàã˜åå, ï˜îâå˜åòå ãî çà
òå…îâå íà ìàñëî.
7. Ñï˜åòå äâèãàòåë è ï˜îâå˜åòå íèâîòî íà ìàñëîòî. ‚î ò˜áâà äà áúäå äî
íàé-âèñîêè çíàê çà íàïúëâàíå (F) íà íèâîïîêàçàòåë.
Íàëèâàíå íà ìàñëî
ˆàçïîëî¥åòå õî˜èçîíòàëíî äâèãàòåë.
fiî…èñòåòå ìñòîòî îêîëî îòâî˜à çà íàëèâàíå íà ìàñëî îò âñè…êè îòëîìêè.
‹àï˜àâåòå ñï˜àâêà â ˜àçäåë Òåõíè÷åñêè äàííè îòíîñíî âìåñòèìîñòòà çà
ìàñëîòî.
1. Ñâàëåòå íèâîïîêààçàòåë (D,·èãó˜à6) è ãî èçáú˜μåòå ñ …èñò ïëàò.
2. ‹àëåéòå âíèìàòåëíî ìàñëîòî ï˜åç îòâî˜à çà ïúëíåíå (E). Íå ïðåïúëâàéòå.
Ñëåä íàëèâàíåòî íà ìàñëîòî, èç…àêàéòå åäíà ìèíóòà è ïîñëå îòíîâî
ï˜îâå˜åòå íèâîòî ìó.
3. flîíòè˜àéòå è çàòåãíåòå íèâîïîêàçàòåë.
4. Ñâàëåòå íèâîïîêàçàòåë è ï˜îâå˜åòå íèâîòî íà ìàñëîòî. ‚î ò˜áâà äà áúäå
äî íàé-âèñîêè çíàê çà íàïúëâàíå (F) íà íèâîïîêàçàòåë.
5. flîíòè˜àéòå è çàòåãíåòå íèâîïîêàçàòåë.
Êàê äà ñå îáñëóæâà âúçäóøíèÿ ôèëòúð - Ôèãóðà
7 8
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
‹èêîãà íå ñòà˜òè˜àéòå è íå ˜àáîòåòå ñ äâèãàòåë ï˜è îòñò˜àíåí êîìïëåêò
íà âúçäóμíè ôèëòú˜ (àêî èìà òàêúâ) èëè ï˜è îòñò˜àíåí âúçäóμåí
ôèëòú˜ (àêî èìà òàêúâ).
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ‹å èçïîëçâàéòå ñ ãúñòåí âúçäóõ èëè ˜àçòâî˜èòåëè, çà äà
ïî…èñòâàòå ôèëòú˜à. Ñãúñòåíèò âúçäóõ ìî¥å äà ïîâ˜åäè ôèëòú˜à, à
˜àçòâî˜èòåëèòå ãî ˜àçòâà˜ò.
Ñèñòåìàòà íà âúçäóμíè ôèëòú˜ èçïîëçâà èëè öèêëîíåí òèï, èëè íèñêî
ï˜îôèëåí âúçäóμåí ôèëòú˜. ‹àï˜àâåòå ñï˜àâêà îòíîñíî èçèñêâàíèòà çà
ñå˜âèçíî îáñëó¥âàíå â Êàðòàòà çà òåõíè÷åñêîòî îáñëóæâàíå.
Öèêëîíåí òèï âúçäóøåí ôèëòúð
1. ›òâî˜åòå ôèêñàòî˜èòå (A) è ñâàëåòå êàïàêà (B). ◊è¥òå â ·èãó˜à 7.
2. Ñâàëåòå âúçäóμíè ôèëòú˜ (C).
3. Çà äà ïî…èñòèòå íàñëîâàíèòà, ëåêî ïî…óêâàéòå ôèëòú˜à âú˜õó òâú˜äà
ïîâú˜õíîñò. æêî ôèëòú˜úò å ï˜åêîìå˜íî çàìú˜ñåí, çàìåíåòå ãî ñ íîâ.
4. Ñèñòåìàòà ñ öèêëîíåí òèï âúçäóμåí ôèëòú˜ èìà ñúùî è ï˜åäïàçåí ôèëòú˜
(D) (àêî èìà òàêúâ). ‹àï˜àâåòå ñï˜àâêà îòíîñíî èçèñêâàíèòà çà ñå˜âèçíî
îáñëó¥âàíå â Êàðòàòà çà òåõíè÷åñêîòî îáñëóæâàíå.Çàäàãîñâàëèòå,
âíèìàòåëíî èçòåãëåòå ï˜åäïàçíè ôèëòú˜ îò êî˜ïóñà íà âúçäóμíè ôèëòú˜
(E) è ãî èçõâú˜ëåòå. ‡âå˜åòå ñå, …å çàìú˜ñâàíåòî èëè íàñëîâàíèòà íìà äà
ïîïàäíàò â äâèãàòåë.
5. fiîñòàâåòå íîâè ï˜åäïàçåí ôèëòú˜ â êî˜ïóñà íà âúçäóμíè ôèëòú˜.
6. flîíòè˜àéòå
âúçäóμ
íè ôèëòú˜ âú˜õó ï˜åäïàçíè ôèëòú˜.
7. fiîñòàâåòå êàïàêà è ç àòâî˜åòå ôèêñàòî˜èòå.
Ñèñòåìà ñ íèñêî ïðîôèëåí âúçäóøåí ôèëòúð
1. Ñâàëåòå ï嘅àòàòà ãàéêà (F) è êàïàêà (G). See ·èãó˜à 8.
2. Ñâàëåòå ãàéêàòà (H) è ñêîáàòà (J).
3. Ñâàëåòå âúçäóμíè ôèëòú˜ (K).
4. æêî èìà ï˜åäôèëòú˜ (L), ñâàëåòå ãî îò âúçäóμíè ôèëòú˜.
5. Çà äà ïî…èñòèòå íàñëîâàíèòà, ëåêî ïî…óêâàéòå ôèëòú˜à âú˜õó òâú˜äà
ïîâú˜õíîñò. æêî ôèëòú˜úò å ï˜åêîìå˜íî çàìú˜ñåí, çàìåíåòå ãî ñ íîâ.
6. fi˜îìèéòå ï˜åäôèëòú˜à âúâ âîäåí ˜àçòâî˜ íà ïî…èñòâàù ï˜åïà˜àò. ›ñòàâåòå
ãî äîá˜å äà ñå èçñóμèíàâúçäóõ.Íå ñìàçâàéòå ï˜åäôèëòú˜à.
7. flîíòè˜àéòå âå…å ñóõè ï˜åäôèëòú˜ êúì âúçäóμíè ôèëòú˜.
8. flîíòè˜àéòå âúçäóμíè ôèëòú˜ è ãî çàê˜åïåòå ñúñ ñêîáàòà è ãàéêàòà.
9. fiîñòàâåòå êàïàêà è ãî çàê˜åïåòå ñ ï嘅àòàòà ãàéêà.
Êàê äà ñå ïî÷èñòâà âúçäóøíî-îõëàäèòåëíàòà ñèñòåìà - Ôèãóðà
9 10
Ðàáîòåùèòå äâèãàòåëè îòäåëÿò òîïëèíà. ×àñòèòå íà äâèãàòåëèòå,
îñîáåíî øóìîçàãëóøèòåëÿ, ñòàâàò èçêëþ÷èòåëíî ãîðåùè.
Ïðè äîïèð ìîæå äà ïîëó÷èòå ñåðèîçíî èçãàðÿíå.
Ãîðèìèòå îòïàäúöè, êàòî ëèñòà, òðåâè, õðàñòàëàê è äðóãè, ìîãàò
äà ñå çàïàëÿò.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
›ñòàâåòå μóìîçàãëóμèòåë,öèëèíäú˜àíàäâèãàòåë è ˜åá˜àòà äà ñå
îõëàäò, ï˜åäè äà ãè äîêîñâàòå.
›òñò˜àíåòå íàò˜óïàíèòå îòëîìêè îêîëî μóìîçàãëóμèòåë è öèëèíäú˜à.
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ: ‹å èçïîëçâàéòå âîäà, çà äà ïî…èñòâàòå äâèãàòåë. ◊îäàòà
ìî¥å äà çàìú˜ñè ãî˜èâíàòà ñèñòåìà. ¤çïîëçâàéòå …åòêà èëè ñóõ ïëàò, çà äà ãî
ïî…èñòèòå.
‚îâà å äâèãàòåë ñ âúçäóμíî îõëà¥äàíå. ‹å…èñòîòèèòå è íàñëîâàíèòà ìîãàò äà
îã˜àíè…àò âúçäóμíè ïîòîê è äà ï˜è…èíò ï˜åã˜âàíåòî ìó, êîåòî âîäè äî
íàìàëâàíå íà ïîêàçàòåëèòå è ï˜îäúë¥èòåëíîñòòà íà ¥èâîòà ìó.
¤çïîëçâàéòå …åòêà èëè ñóõ ïëàò, çà äà îòñò˜àíèòå íàñëîâàíèòà îò
ï˜åäïàçèòåë íà ï˜úñòèòå/âú˜òùè ñå åê˜àí (A,·èãó˜à9). fiàçåòå …èñòè
ëîñòîâàòà ñèñòåìà, ï˜ó¥èíèòå è óï˜àâëåíèòà (B). fiàçåòå ï˜îñò˜àíñòâîòî îêîëî
èçàäμóìîçàãëóμèòåë (C) ñâîáîäíî îò âñêàêâè ãî˜èìè íàñëîâàíè. ‡áåäåòå
ñå, …å ïëàñòèíèòå çà îõëà¥äàíå íà ìàñëîòî (D) ñà ïî…èñòåíè îò çàìú˜ñâàíå è
íàñëîâàíè.
fiî…èñòåòå ï˜îñò˜àíñòâîòî ïîä ïàíåëà (E,·èãó˜à10).
ˆàçõëàáåòå äâàòà âèíòà (F)
äîêàòî
…óåòå ù˜àêâàíå. Ñâàëåòå ïàíåëà è ïî…èñòåòå ìñòîòî îò çàìú˜ñâàíå è
íàñëîâàíè. ‡áåäåòå ñå, …å äîëíàòà ïîâú˜õíîñò íà ïàíåëà ñúùî å …èñòà.
flîíòè˜àéòå ïàíåëà è çàòåãíåòå âèíòîâåòå, äîêàòî …óåòå ù˜àêâàíåòî.
Çàáåëåæêà: Çà äà ñâàëèòå ïàíåëà ï˜è äâèãàòåëè, ñíàáäåíè ñúñ ñèñòåìà çà
öèêëîíåí òèï âúçäóμåí ôèëòú˜ (G,·èãó˜à10), ˜àçõëàáåòå ñêîáàòà (H)è
çàâú˜òåòå öèêëîííè âúçäóμåí ôèëòú˜ íàñò˜àíè îò äâèãàòåë. ‹å å íåîáõîäèìî
äà ñâàëòå ãúâêàâè ìà˜êó… íà âúçäóμíè ôèëòú˜ (J). Ñëåä ïî…èñòâàíåòî ñå
óáåäåòå, …å ï˜àâèëíî ñòå ïîñòàâèëè âúçäóμíè ôèëòú˜ è ñòå çàòåãíàëè ñêîáàòà.
Not for
Reproduction
18
VanguardEngines.com
Ñêëàäèðàíå
ÏÐÅÄÓÏÐÅÆÄÅÍÈÅ
Ãîðèâîòî è íåãîâèòå ïàðè ñà èçêëþ÷èòåëíî îãíåîïàñíè è
èçáóõëèâè.
Ïîæàð èëè âçðèâ ìîãàò äà ïðè÷èíÿò ñåðèîçíè îáãàðÿíèÿ èëè
ñìúðò.
Ïðè ñêëàäèðàíå íà ãîðèâî èëè íà ìàøèíà ñ ãîðèâî â ðåçåðâîàðà
Ñêëàäè˜àéòå äàëå… îò ïåùè, ïå…êè, âîäîíàã˜åâàòåëè èëè ä˜óãè
åëåêò˜è…åñêè ï˜èáî˜è, êîèòî èìàò ñèãíàëíè ëàìïè èëè ä˜óãè çàïàëèòåëíè
èçòî…íèöè, çàùîòî òå ìîãàò äà âúçïëàìåíò èçïà˜åíèòà îò ãî˜èâîòî.
Ìàñëîòî íà äâèãàòåëÿ
Äîêàòî äâèãàòåëò å âñå îùå òîïúë ñìåíåòå ìàñëîòî.
Îòêðèâàíå è îòñòðàíÿâàíå íà íåèçïðàâíîñòè
‹ó¥äàåòå ëè ñå îò ïîìîù? fiîñåòåòå VanguardEngines.com èëè ñå îáàäåòå íà
1-800-999-9333 (â ÑæÂ).
Òåõíè÷åñêè äàííè
Ñïåöèôèêàöèè çà äâèãàòåëÿ
flîäåë 540000
ˆàáîòåí îáåì 54,68 in
3
(896 cm
3
)
◊úò˜åμåí äèàìåòú˜ íà öèëèíäú˜à 3,366 in (85,5 mm)
ˆàáîòåí õîä íà áóòàëîòî 3,071 in (78,0 mm)
◊ìåñòèìîñò çà ìàñëî 78 -- 80 oz (2,3 -- 2,4 L)
Ñïåöèôèêàöèè çà äâèãàòåëÿ
flîäåë 610000
ˆàáîòåí îáåì 60,60 in
3
(993 cm
3
)
◊úò˜åμåí äèàìåòú˜ íà öèëèíäú˜à 3,366 in (85,5 mm)
ˆàáîòåí õîä íà áóòàëîòî 3,406 in (77,21 mm)
◊ìåñòèìîñò çà ìàñëî 78 -- 80 oz (2,3 -- 2,4 L)
Ðåãóëèðîâú÷íè äàííè *
flîäåë 540000
¤ñê˜îâà ìå¥äèíà íà çàïàëèòåëíàòà ñâåù 0,020 in (0,51 mm)
◊ú˜òù ìîìåíò çà çàòãàíå íà
çàïàëèòåëíàòà ñâåù
180 lb-in (20 Nm)
◊úçäóμíà ìå¥äèíà ìå¥äó ˜îòî˜à è
ñòàòî˜à
0,005 - 0,008 in (0,13 - 0,20 mm)
flå¥äèíà íà ñìóêàòåëíè êëàïàí 0,004 - 0,006 in (0,10 - 0,15 mm)
flå¥äèíà íà èçïóñêàòåëíè êëàïàí 0,007 - 0,009 in (0,18 - 0,23 mm)
Ðåãóëèðîâú÷íè äàííè *
flîäåë 610000
¤ñê˜îâà ìå¥äèíà íà çàïàëèòåëíàòà ñâåù 0,020 in (0,51 mm)
◊ú˜òù ìîìåíò çà çàòãàíå íà
çàïàëèòåëíàòà ñâåù
180 lb-in (20 Nm)
◊úçäóμíà ìå¥äèíà ìå¥äó ˜îòî˜à è
ñòàòî˜à
0,005 - 0,008 in (0,13 - 0,20 mm)
flå¥äèíà íà ñìóêàòåëíè êëàïàí 0,004 - 0,006 in (0,10 - 0,15 mm)
flå¥äèíà íà èçïóñêàòåëíè êëàïàí 0,007 - 0,009 in (0,18 - 0,23 mm)
* flîùíîñòòà íà äâèãàòåë íàìàëâà ñ 3,5% íà âñåêè 1000 ôóòà (300 ìåò˜à) íàä ìî˜ñêîòî íèâî è ñ 1% çà âñåêè 10 F(5,6 C) íàä 77 F(25 C). Äâèãàòåëò ùå ˜àáîòè
çàäîâîëèòåëíî ï˜è íàêëîí äî 15. ‹àï˜àâåòå ñï˜àâêà â ˆúêîâîäñòâîòî çà ˜àáîòà ñ îáî˜óäâàíåòî çà áåçîïàñíèòå ã˜àíèöè çà ˜àáîòà íà íàêëîíè.
Îáèêíîâåíè ÷àñòè çà ïîääðúæêà n
Ñåðâèçíà ÷àñò Íîìåð íà ÷àñòòà
◊úçäóμåí ôèëòú˜ öèêëîíåí òèï 841497
fi˜åäïàçåí ôèëòú˜ öèêëîíåí òèï 821136
◊úçäóμåí ôèëòú˜ ñ íèñúê ï˜îôèë 692519
fi˜åäôèëòú˜ ñ íèñúê ï˜îôèë 692520
flàñëî √ SAE 30 100028
Ñåðâèçíà ÷àñò Íîìåð íà ÷àñòòà
flàñëåí ôèëòú˜ 842921
ˆåçèñòî˜íà çàïàëèòåëíà ñâåù 491055
Äúëãîò˜àéíà ïëàòèíåíà çàïàëèòåëíà ñâåù 5066
ÿë˚… çà ñâåù 19374
¤ñê˜îâ òåñòå˜ 19368
n ‹èå âè ï˜åïî˜ú…âàìå äà ïîñåòèòå íêîé îò ‡ïúëíîìîùåíèòå ï˜åäñòàâèòåëè íà Briggs & Stratton çà âñè…êè îïå˜àöèè ïî òåõíè…åñêîòî è ñå˜âèçíîòî îáñëó¥âàíå íà
äâèãàòåë è ˜åçå˜âíèòå …àñòè.
Not for
Reproduction
19
bg
ÃÀÐÀÍÖÈÎÍÍÀ ÏÎËÈÒÈÊÀ ÍÀ BRIGGS & STRATTON ÎÒÍÎÑÍÎ ÄÂÈÃÀÒÅËÈÒÅ
ßíóàðè 2014 ã.
ÿî˜ïî˜àöè Briggs & Stratton ãà˜àíòè˜à, …å ïî â˜åìå íà îï˜åäåëåíè ïî-äîëó ãà˜àíöèîíåí ïå˜èîä, ùå ˜åìîíòè˜à èëè çàìåíè áåçïëàòíî âñêà äåôåêòíà …àñò
ïî˜àäè íåêà…åñòâåí ìàòå˜èàë èëè èç˜àáîòêà, èëè ïî˜àäè äâåòå ï˜è…èíè. ‚˜àíñïî˜òíèòå ˜àçõîäè íà èçï˜àòåíèòå çà ˜åìîíò èëè ñìíà …àñòè ïî òàçè ãà˜àíöè
ñå ïîåìàò îò êóïóâà…à. ‚àçè ãà˜àíöè å âàëèäíà çà îï˜åäåëåíè ñ˜îê è å ï˜åäìåò íà ñ˜îêà è óñëîâèòà, ôèêñè˜àíè ïî-äîëó. Çà îáñëó¥âàíå ïî ãà˜àíöèòà ñå
îáú˜íåòå êúì íàé-áëèçêè ‡ïúëíîìîùåí ñå˜âèçåí ï˜åäñòàâèòåë, êîéòî ìî¥å äà îòê˜èåòå â íàμè óêàçàòåë íà ¤íòå˜íåò àä˜åñ BRIGGSandSTRATTON.com.
ÿóïóâà…úò ò˜áâà äà ñå îáú˜íå êúì ‡ïúëíîìîùåíè ñå˜âèçåí ï˜åäñòàâèòåë, ñëåä êîåòî äà ï˜åäîñòàâè ï˜îäóêòà â ñå˜âèçà ìó çà ï˜îâå˜êà è èçïèòâàíå.
Íÿìà äðóãà ñïåöèàëíà ãàðàíöèÿ. Ïîäðàçáèðàùèòå ñå ãàðàíöèè, âêëþ÷èòåëíî òåçè çà ãîäíîñòòà çà ïðîäàæáà èëè çà íÿêàêâà ñïåöèàëíà öåë, ñà
îãðàíè÷åíè äî ãàðàíöèîíåí ïåðèîä, ïîñî÷åí ïî-äîëó, èëè äî ñðîêà, ðàçðåøåí ïî çàêîí. Îòãîâîðíîñò çà ñëó÷àéíè èëè ïîñëåäâàùè ùåòè ñå èçêëþ÷âà
â ñòåïåí, ðàçðåøåíà ïî çàêîí. ‹êîè ùàòè èëè ñò˜àíè íå ïîçâîëâàò îã˜àíè…åíè çà â˜åìåò˜àåíåòî íà ïîä˜àçáè˜àùàòà ñå ãà˜àíöè,àíêîè ùàòè èëè
ñò˜àíè íå ïîçâîëâàò èçêë˚…âàíåòî èëè îã˜àíè…àâàíåòî íà ñëó…àéíè èëè ïîñëåäâàùè ùåòè, òàêà …å å âúçìî¥íî ãî˜íîòî îã˜àíè…åíèå è èçêë˚…åíèåäàíåâà¥è
çà âàñ. ‚àçè ãà˜àíöè âè äàâà ñïåöèôè…íè çàêîíîâè ï˜àâà, à âèå ìî¥åòå äà èìàòå è ä˜óãè òàêèâà, êîèòî ñå èçìåíò â åäèí èëè ä˜óã ùàò, èëè â åäíà èëè ä˜óãà
ñò˜àíà. **
ÎÃÐÀÍÈ×ÅÍÀ ÃÀÐÀÍÖÈß
ÑÒÀÍÄÀÐÒÍÈ ÃÀÐÀÍÖÈÎÍÍÈ ÓÑËÎÂÈß *
Y
Ìàðêà/Âèä ïðîäóêò Çà ïîëçâàíå çà ñîáñòâåíè íóæäè Çà ïîëçâàíå çà ïðîìèøëåíè íóæäè
Vanguardt
J
3 ãîäèíè 3 ãîäèíè
‚ú˜ãîâñêà ñå˜è çà …èìîâåt 2 ãîäèíè 2 ãîäèíè
Äâèãàòåëè, ñíàáäåíè ñ …óãóíåíà ˜èçà Dura-Boret 2 ãîäèíè 1 ãîäèíà
◊ñè…êè ä˜óãè äâèãàòåëè íà Briggs & Stratton 2 ãîäèíè 90 äíè
* ‚åçè ñà íàμèòå ñòàíäà˜òíè ãà˜àíöèîííè óñëîâè, íî åïèçîäè…íî å âúçìî¥íî äîïúëíèòåëíî ãà˜àíöèîííî ïîê˜èòèå, êîåòî íå å áèëî îï˜åäåëåíî êúì
ìîìåíòà íà ïóáëèêóâàíåòî èì. Çà ñïèñúêà ñ òåêóùèòå ãà˜àíöèîííè óñëîâè çà âàμè äâèãàòåë ïîñåòåòå àä˜åñà íè â ¤íòå˜íåò
BRIGGSandSTRATTON.COM èëè ñå îáú˜íåòå êúì ‡ïúëíîìîùåí ñå˜âèçåí ï˜åäñòàâèòåë íà Briggs & Stratton.
** Çà æâñò˜àëè√‹àμèòå ñòîêè ï˜èñòèãàò ñ ãà˜àíöèèòå, êîèòî íå ìîãàò äà áúäàò èçêë˚…åíè ñúãëàñíî àâñò˜àëèéñêè ïîò˜åáèòåëñêè çàêîí. Äàâà âè ñå
ï˜àâî íà çàìíà èëè â˜úùàíå íà ñóìàòà ï˜è ñúùåñòâåíà íåèçï˜àâíîñò è çà êîìïåíñàöè çà âñ êà ä˜óãà îáîñíîâàíà è îáîç˜èìà çàãóáà èëè ùåòà. ¤ìàòå
ï˜àâî è äà ïîëó…èòå ñòîêèòå ñè ïîï˜àâåíè èëè ñìåíåíè, àêî òå íå ïîêà¥àò ï˜èåìëèâî êà…åñòâî è ïîâ˜åäàòà èì íå âîäè äî ñúùåñòâåíà íåèçï˜àâíîñò. Çà
îáñëó¥âàíå ïî ãà˜àíöèòà ñå îáú˜íåòå êúì íàé-áëèçêè ‡ïúëíîìîùåí ñå˜âèçåí ï˜åäñòàâèòåë â íàμè óêàçàòåë íà èíòå˜íåò àä˜åñ
BRIGGSandSTRATTON.COM, èëè ñå îáàäåòå íà òåë. 1300 274 447, èëè íàïèμåòå e-mail èëè ïèñìî ñúîòâåòíî íà åëåêò˜îííà ïîùà
salesenquiries@briggsandstratton.com.au, èëè íà àä˜åñ Briggs & Stratton Australia Pty Ltd, 1 Moorebank Avenue, Moorebank, NSW, Australia, 2170.
Y
‹ìà ãà˜àíöè çà äâèãàòåëè, ìîíòè˜àíè íà îáî˜óäâàíå, ïîëçâàíî êàòî èçòî…íèê íà ïú˜âè…íà ìîùíîñò âìåñòî öåíò˜àëíî çàõ˜àíâàíå èëè êàòî ˜åçå˜âíè
ãåíå˜àòî˜è, ïîëçâàíè çà òú˜ãîâñêè öåëè. Äâèãàòåëè, èçïîëçâàíè çà ñúñòåçàíè, çà òú˜ãîâñêè öåëè èëè çà îòäàâàíå ïîä íàåì, íå ñà ïîê˜èòè îò
ãà˜àíöèòà.
J
Çà äâèãàòåëè Vanguard, ìîíòè˜àíè íà ˜åçå˜âíè ãåíå˜àòî˜è: ñàìî 2-ãîäèμíà ãà˜àíöè çà êóïóâà…à, áåç ãà˜àíöè ï˜è òú˜ãîâñêî ïîëçâàíå. Çà Vanguard,
ìîíòè˜àíè íà àâòîìîáèëè ñ îáùî ïîëçâàíå: 2-ãîäèμíà ãà˜àíöè çà êóïóâà…à, 2 ãîäèíè ï˜è òú˜ãîâñêî ïîëçâàíå. Çà 3-öèëèíä˜îâ äâèãàòåë Vanguard ñ
òå…íî îõëà¥äàíå: âè¥òå ãà˜àíöèîííàòà ïîëèöà íà Briggs & Stratton çà ò˜è-öèëèíä˜îâ äâèãàòåë ñ òå…íî îõëà¥äàíå - 3/LC.
øà˜àíöèîííèò ïå˜èîä çàïî…âà îò äàòàòà íà êóïóâàíå îò ïú˜âè ïîò˜åáèòåë íà ä˜åáíî èëè îò ê˜àéíè ïîò˜åáèòåë ç à ï˜îìèμëåíè íó¥äè. ∆Çà ïîëçâàíå çà ñîáñòâåíè
íó¥äè∆ îçíà…àâà ëè…íî èçïîëçâàíå â äîìàêèíñòâîòî îò ïîò˜åáèòåë íà ä˜åáíî. ∆Çà ïîëçâàíå çà ï˜îìèμëåíè íó¥äè∆ îçíà…àâà âñè…êè ä˜óãè óïîò˜åáè, âêë˚…èòåëíî
òú˜ãîâñêà óïîò˜åáà, êàêòî è òàêàâà, ôî˜ìè˜àùà äîõîä èëè îòäàâàíå ïîä íàåì. Ñëåä êàòî äàäåí äâèãàòåë å áèë ïîëçâàí çà ï˜îìèμëåíè íó¥äè, çà öåëèòå íà òàçè
ãà˜àíöè òîé ùå áúäå ˜àçãëå¥äàí êàòî ï˜îäóêò çà ï˜îìèμëåíè íó¥äè.
Ïàçåòå çà äîêàçàòåëñòâî êâèòàíöèÿòà îò ïîêóïêàòà. Àêî íå îñèãóðèòå äîêàçàòåëñòâî çà íà÷àëíàòà äàòà íà êóïóâàíå ïðè ïîèñêâàíå íà ãàðàíöèîííî ñåðâèçíî
îáñëóæâàíå, äàòàòà íà ïðîèçâîäñòâî íà ïðîäóêòà ùå ñå èçïîëçâà çà îïðåäåëÿíå íà ãàðàíöèîííèÿ ïåðèîä. Íå å íåîáõîäèìà ðåãèñòðàöèÿ íà èçäåëèåòî, çà äà
ïîëó÷àâàòå ãàðàíöèîííî îáñëóæâàíå íà àðòèêóëèòå íà Briggs & Stratton.
Îòíîñíî âàøàòà ãàðàíöèÿ
‚àçè îã˜àíè…åíà ãà˜àíöè ïîê˜èâà ñàìî äåôåêòåí ìàòå˜èàë è/èëè èç˜àáîòêà,
ï˜èëî¥åíè â äâèãàòåë,àíåñìíà èëè â˜úùàíå íà ïà˜èòå çà ìàμèíàòà, êúì
êîòî äâèãàòåëò ìî¥å äà áúäå ìîíòè˜àí. ‚åêóùîòî òåõíè…åñêî îáñëó¥âàíå,
˜åãóëè˜îâêè, íàñò˜îéêè èëè íî˜ìàëíîòî èçíîñâàíå è èçõàáâàíå íå ñå ïîê˜èâàò
îò òàçè ãà˜àíöè. Ñúùî òàêà, ãà˜àíöèòà å íåâàëèäíà, àêî äâèãàòåëòå
âèäîèçìåíí, ï˜åîá˜àçóâàí èëè ñå˜èéíèò ìó íîìå˜ å ïîâ˜åäåí èëè îòñò˜àíåí.
‚àçè ãà˜àíöè íå âêë˚…âà óïîò˜åáâàíè, ˜åìîíòè˜àíè, êóïåíè íà ñòà˜î èëè
äåìîíñò˜àöèîííè ñúî˜ú¥åíè è äâèãàòåëè. ‚àçè ãà˜àíöè íå ïîê˜èâà ïîâ˜åäà íà
äâèãàòåë èëè ï˜îáëåìè ïî òåõíè…åñêèòå ìó ïîêàçàòåëè, ï˜è…èíåíè îò:
1 èçïîëçâàíåòî íà …àñòè, êîèòî íå ñà î˜èãèíàëíè …àñòè íà Briggs & Stratton;
2 åêñïëîàòè˜àíå íà äâèãàòåë ñ íåäîñòàòú…íî, çàìú˜ñåíî èëè íåï˜àâèëíî
èçá˜àíî ìàñëî çà ñìàçâàíå;
3 èçïîëçâàíåòî íà çàìú˜ñåíî èëè îñòà˜ëî ãî˜èâî, íà áåíçèí, ñìåñâàí ñ
ïîâå…å îò 10% åòàíîë, èëè èçïîëçâàíåòî íà àëòå˜íàòèâíè ãî˜èâà, íàï˜èìå˜
âòå…íåí íåôòåí èëè ï˜è˜îäåí ãàç çà äâèãàòåëè, êîèòî, ïî íà…àëî, íå ñà
ï˜îåêòè˜àíè/ï˜îèçâåäåíè îò Briggs & Stratton, çà äà ˜àáîòò ñ òàêèâà ãî˜èâà;
4çàìú˜ñâàíå, êîåòî å ï˜îíèêíàëî â äâèãàòåë ïî˜àäè íåï˜àâèëíî ò åõíè…åñêî
îáñëó¥âàíå íà âúçäóμíè ôèëòú˜ è íåï˜àâèëíîòî ìó ïîñëåäâàùî
ìîíòè˜àíå;
5óä˜íå íà ï˜åäìåò ñ ˜å¥åùè íî¥ íà ˜îòàöèîííàòà ïîëåâà êîñà…êà,
˜àçõëàáåíè èëè íåï˜àâèëíî ïîñòàâåíè àäàïòå˜è çà íî¥îâåòå, ëîïàòêèòå èëè
ä˜óãè óñò˜îéñòâà, ñâú˜çàíè êúì êîëíîâè âàë, èëè îò ï˜åêîìå˜íî íàòãàíå
íà ò˜àïåöîâèäíè ˜åìúê;
6 ñúîòâåòñòâàùè …àñòè è âúçëè êàòî ñúåäèíèòåëè, ï˜åäàâàòåëíè ìåõàíèçìè,
ó˜åäè çà óï˜àâëåíèå íà îáî˜óäâàíåòî è ä˜., êîèòî íå ñà äîñòàâåíè îò Briggs
& Stratton;
7 ï˜åã˜âàíå, äúë¥àùî ñå íà îêîñåíà ò˜åâà, íà çàìú˜ñâàíå èëè îòëîìêè, èëè
íà ãíåçäà íà ã˜èçà…è, êîèòî çàïóμâàò èëè çàä˜úñòâàò îõëà¥äàùèòå ïëàñòèíè
èëè êî¥óõà íà ìàõîâèêà, èëè íà ˜àáîòà íà äâèãàòåë áåç äîñòàòú…íî
îõëà¥äàíå;
8 ï˜åêîìå˜íà âèá˜àöè,
ï˜è…èíåíà
îò ï˜åâèμåíè îáî˜îòè, õëàáàâ ìîíòॠíà
äâèãàòåë, õëàáàâè èëè íåáàëàíñè˜àíè íî¥îâå èëè ïå˜êè, èëè íåï˜àâèëíî
ñâú˜çâàíå íà åëåìåíòèò å íà îáî˜óäâàíåòî êúì êîëíîâè âàë;
9 íåï˜àâèëíà óïîò˜åáà, ëèïñà íà ˜åäîâíî òåõíè…åñêî îáñëó¥âàíå, íåï˜àâèëíî
ò˜àíñïî˜òè˜àíå, ìàíåâ˜è˜àíå èëè ñêëàäè˜àíå íà îáî˜óäâàíåòî èëè
íåï˜àâèëåí ìîíòॠíà äâèãàòåë.
Ãàðàíöèîííîòî îáñëóæâàíå å äîñòúïíî åäèíñòâåíî ïðè Îòîðèçèðàíèòå
ñåðâèçíè ïðåäñòàâèòåëè íà Êîðïîðàöèÿ Briggs & Stratton. Íàìåðåòå
íàé-áëèçêèÿ Îòîðèçèðàí ñåðâèçåí ïðåäñòàâèòåë â íàøàòà óêàçàòåëíà êàðòà
çà ïðåäñòàâèòåëèòå íà àäðåñ BRIGGSandSTRATTON.COM èëè êàòî ñå îáàäèòå
íà òåë. 1-800-233-3723 (â ÑÀÙ).
Not for
Reproduction
20 VanguardEngines.com
Všeobecné informace
Tato pøíruèka obsahuje bezpeènostní informace nezbytné pro to, abyste vìdìli, jaká
nebezpeèí a rizika souvisí s motory a jak se jim vyhnout. Obsahuje i pokyny, jak øádnì
motor používat a jak se nìj starat. Vzhledem k tomu, že korporace Briggs & Stratton
nemusí nutnì vìdìt, jaké zaøízení bude tento motor pohánìt, je dùležité, abyste si
pøeèetli a pochopili tyto pokyny a pokyny pro zaøízení, které tento motor pohání.
Uschovejte originál tìchto pokynù pro budoucí použití.
Potøebujete-li náhradní díly nebo technickou pomoc, zapište dolù model motoru, typové a
kódové èíslo a datum nákupu. Tato naleznete na svém motoru (viz kapitola Funkce a
ovládací prvky).
Datum nákupu:
Model motoru:
DD/MM/RRRR
Model: Kód:Typ:
Bezpeènost obsluhy
Výbuch
Toxické výparyPohyblivé èásti
Úraz elektrickým
proudem
Horký povrch
Zpìtný ráz
Požár
Uzávìr paliva
Ètìte návod
Sytiè
Olej
Palivo
Zapnuto/Vypnuto
Používejte
ochranu zraku
Pomalu
Rychle
BEZPEÈNOSTNÍ A KONTROLNÍ SYMBOLY
Nebezpeèná chemikálie
Omrzliny
Stop
Symbol bezpeènostního upozornìní oznaèuje bezpeènostní informace týkající se
rizik, která mohou zpùsobit úraz. Signální slovo (NEBEZPEÈÍ, UPOZORNÌNÍ nebo
VÝSTRAHA) se používá spolu s varovným symbolem pro vyznaèení pravdìpodobnosti a
potenciální vážnosti úrazu. Mimo to mùže být pro oznaèení druhu nebezpeèí použit symbol
nebezpeèí.
NEBEZPEÈÍ oznaèuje ohrožení, které, není-li eliminováno, zpùsobí smrt
nebo vážný úraz.
VAROVÁNÍ oznaèuje ohrožení, které, není-li eliminováno, mùže zpùsobit
smrt nebo vážný úraz.
POZOR oznaèuje ohrožení, které, není-li eliminováno, mùže zpùsobit lehký,
nebo støednì tìžký úraz.
POZNÁMKA oznaèuje situaci, v níž by mohlo dojít k poškození produktu.
VAROVÁNÍ
Nìkteré s ouèásti tohoto produktu a související pøíslušenství obsahují chemické
látky, o nichž je ve státì Kalifornie známo, že zpùsobují rakovinu, poškození plodu
èi jiné poruchy reprodukce. Po manipulaci si umyjte ruce.
VAROVÁNÍ
Výfukové plyny t ohoto výrobku obsahují chemikálie, o nichž je ve státì Kalifornie
známo, že zpùsobují rakovinu, poškození plodu èi jiné poruchy reprodukce.
VAROVÁNÍ
Motory znaèky Briggs & Stratton nejsou zkonstruovány pro pohánìní vozítek,
motokár, dìtských, rekreaèních nebo sportovních terénních vozidel (ATV),
motocyklù, vznášedel, leteckých produktù nebo vozidel používaných v soutìžích,
které s poleènost Briggs & Stratton neschválila, a nesmìjí být tedy takto použity.
Informace o soutìžních a závodních výrobcích naleznete na adrese
www.briggsracing.com. Informace o používání ve ètyøkolkách a ATV vozidlech
side-by-side získáte v Engine Application Center, støedisku pro aplikaci motorù
spoleènosti Briggs & Stratton, tel. 1-866-927-3349. Nesprávné použití motoru mùže
vést k vážnému zranìní nebo smrti.
POZNÁMKA: Tento motor je dodáván firmou Briggs & Stratton bez oleje. Pøed
spuštìním motoru zkontrolujte hladinu oleje. Pokud spustíte motor bez oleje, mùže dojít
k jeho neopravitelnému poškození, na které se nebude vztahovat záruka.
VAROVÁNÍ
Palivo a jeho páry jsou vysoce hoølavé a výbušné.
Požár nebo výbuch mùže zpùsobit vážné popáleniny nebo i smrt
Když doplòujete palivo
Nádrž plòte venku nebo v dobøe vìtraném prostoru.
Kontrolujte palivové potrubí, nádrž a uzávìr a všechny spoje na tìsnost a
praskliny. V pøípadì potøeby proveïte výmìnu.
Pøi spouštìní motoru
Zkontrolujte, zda jsou na svém místì svíèky, tlumiè výfuku a vzduchový filtr (je-li
jím motor vybaven) a zda jsou dobøe zajištìny.
Neotáèejte motorem pøi odstranìné svíèce.
Pøi obsluze zaøízení
Nespouštìjte ani neprovozujte motor s odmontovanou sestavou vzduchového
filtru (je-li jím motor vybaven) nebo s vyjmutým vzduchovým filtrem (je-li jím
motor vybaven).
Pøi pøepravì zaøízení
U motorù na zemní plyn/zkapalnìný propan (LP) pøed pøepravou motoru
vyprázdnìte tlakovou nádobu a zavøete kohout, nebo nádobu odpojte.
Pøi skladování paliva nebo zaøízení s palivem v nádrži
Uložte oddìlenì od pecí, kamen, ohøívaèù vody èi jiných zaøízení, která mají
vìèný plamínek nebo od jiných zdrojù zapálení. Mohou zažehnout výpary z
paliva.
Not for
Reproduction
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
Leht laadib ...
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
Simplicity 543275-0111-E1 Kasutusjuhend
- Kategooria
- Mootorsõidukite tarvikud
- Tüüp
- Kasutusjuhend
- See käsiraamat sobib ka
teistes keeltes
Seotud paberid
-
Simplicity 613277-0114-E1 Kasutusjuhend
-
Simplicity 613275-0006-E1 Kasutusjuhend
-
Simplicity 040243-0 Kasutusjuhend
-
Simplicity 543277-0005-01 Kasutusjuhend
-
-
Simplicity 130G32-0225-01 Kasutusjuhend
-
-
Simplicity 150212-2526-E9 Kasutusjuhend